Wrench.Pro

2016 Audi Q5 Recalls, Issues & Maintenance

The 2016 Audi Q5 carries 5 open NHTSA recalls — most recently covering wiring and cooling system. Owners report 8 recurring issue clusters, led by “Excessive oil consumption.” Audi follows the VW Group Longlife service rhythm: oil and minor service every 10,000 miles or 12 months, whichever comes first, using oil that meets VW 502 00 / 504 00 (or 508 00 for newer 0W-20 engines) — generic synthetic does not qualify. S tronic dual-clutch gearboxes need fluid service every 40,000 miles despite 'lifetime fill' claims. Fully electric models (e-tron, e-tron GT) skip oil service entirely but keep brake-fluid, cabin-filter, and coolant-circuit intervals.

5 Open Recalls

Source: NHTSA

ELECTRICAL SYSTEM:WIRING

Campaign #17V622000 · May 10, 2017

Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2016 Audi A5 Coupe, A5 Cabriolet, A4 Sedan, A4 Allroad and Q5 vehicles. Contact corrosion within the electrical connector for the auxiliary heater may cause the heater wires to overheat or melt.

Risk: The melted wires can increase the risk of a fire.

Fix: Audi will notify owners, and dealers will replace the auxiliary heater and, as necessary, update the software, free of charge. The Recall began November 27, 2017. Owners may contact Audi customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 80C5 and 80C6.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

Campaign #17V002000 · Mar 1, 2017

Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5, A5 Cabriolet and Q5 vehicles, 2013-2016 Audi Allroad and Audi A4 vehicles and 2012-2015 Audi A6 vehicles. These vehicles, equipped with 2.0l Turbo FSI engines, have an electric coolant pump that can be blocked with debris from the cooling system, resulting in the pump overheating.

Risk: If the coolant pump overheats, it can increase the risk of a fire.

Fix: Audi will notify owners, and dealers will update the software so that the power supply to the coolant pump is deactivated if the pump becomes blocked with debris, free of charge. The recall is expected to begin February 20, 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 19M1.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

Campaign #17V001000 · Mar 1, 2017

Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2011-2017 Audi Q5 vehicles. The sunroof drainage system may allow water to soak into the foam surrounding the side head air bag inflator canister resulting in the corrosion of the canister. If this happens, the corrosion can weaken the canister and the inflator could fracture without air bag deployment, propelling fragments into the passenger compartment, striking and causing serious injury to vehicle occupants.

Risk: An inflator rupture may result in metal fragments striking the driver or other occupants resulting in serious injury or death.

Fix: Audi will notify owners, and dealers will inspect the inflator and either coat it or replace it, as necessary, after removing the surrounding foam, free of charge. The recall is expected to began March 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69P1.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

Campaign #18V229000 · Nov 4, 2018

Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5 Cabriolet, A5 Sedan and Audi Q5 vehicles, 2012-2015 Audi A6 vehicles and 2013-2016 Audi A4 Sedan and A4 allroad vehicles. These vehicles, equipped with 2.0l Turbo FSI engines, have an electric coolant pump that can either become blocked with debris from the cooling system causing it to overheat or can short-circuit from moisture within the pump.

Risk: A blocked pump or a short-circuited pump can increase the risk of a fire.

Fix: Audi will notify owners, and dealers will replace the pumps, free of charge. The recall began September 14, 2018. Owners may contact Audi customer service at 1-800-253-2834. Audi's number's for this recall is 19N3/19N4. Note: This recall is in additional to the coolant pump software update applied as a remedy under recall 17V002.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Campaign #17V298000 · Mar 5, 2017

Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2013-2017 Audi Q5 and 2013-2017 Audi Q7 vehicles. These gasoline-powered vehicles have a fuel pump flange that may crack, allowing fuel to leak.

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

Fix: Audi will notify owners, and dealers will replace the fuel pump flange if cracks are present. Flanges that do not have cracks will have a protective film applied. These repairs will be performed free of charge. The recall began July 3, 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20Z8. Note: This recall is an expansion of recall 16V-660.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2016 Audi Q5.

Reported to NHTSA

Excessive oil consumption

ENGINE

12 NHTSA complaints · 2020-11 → 2025-01

“Excessive oil consumption”
— Owner report, NHTSA ODI #11515925
“My Q5 requires an additional quart of oil approximately every 500-1000 miles since purchased in early August . Services included two oil changes, replacement of pan gasket and fill tube O-ring. No drips on the ground, just a minimum level reading every 30 days”
— Owner report, NHTSA ODI #11597585
“Audi had Valves and pistons fail on the highway at 75mph on Nov 28,2024 at 117000 miles Had the vehicle since 2021 and 17000 miles. Complained to the dealerships at the last 3 oil changes about excessive oil consumption”
— Owner report, NHTSA ODI #11635505

Read all complaints on NHTSA →

Rear subframe corrosion

SUSPENSION

3 NHTSA complaints · 2026-05 → 2026-07

“My Q5 failed inspection due to a rusted subframe, so badly there is a huge hole in it. The dealership sent photos and notes to Audi but the dealership claims Audi denied my warranty claim (12 Year Corrosion Warranty) because it's not a body panel (the verbiage used in the”
— Owner report, NHTSA ODI #11738767
“1) Rear subframe supports differential, axels, suspension, brakes, wheels and tires 2) If rear suspension fails , above noted assemblies will fall out of the car”
— Owner report, NHTSA ODI #11747832
“Mechanic was checking the car and noticed subframe is rusted through underneath the plastic cladding. Audi dealers should cover this under warranty as it’s a safety issue. This happened due to poor designing”
— Owner report, NHTSA ODI #11735390

Read all complaints on NHTSA →

Power steering rack and control module failure

STEERING

9 NHTSA complaints · 2020-08 → 2026-07

“Driving on May 20, 2026 near my home in Florida, power steering assist failed suddenly making it very difficult to steer. Red light on dashboard lit up indicating steering failure”
— Owner report, NHTSA ODI #11751001
“Power steering failure. While driving warning light came on and power steering immediately went out. No prior warnings”
— Owner report, NHTSA ODI #11628068
“The entire steering system failed. While the car was in motion, the steering wheel completely locked up and could not be turned even a degree. This caused extreme safety concern as the road was curving but the car could not be steered”
— Owner report, NHTSA ODI #11512533

Read all complaints on NHTSA →

Coolant pump and engine cooling recall repair delays

ENGINE AND ENGINE COOLING

19 NHTSA complaints · 2018-06 → 2024-08

“IN THE LAST SIX MONTHS I HAVE RECEIVED FOUR LETTERS FROM AUDI SAYING THAT THERE IS A SAFETY RECALL 19N4 ABOUT A ELECTRIC AFTER RUN COOLANT PUMP. IN THEIR LETTERS THEY SAY THIS CAN LEAD TO POTENTIAL VEHICLE FIRE”
— Owner report, NHTSA ODI #11181578
“TL* THE CONTACT OWNS A 2016 AUDI Q5. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 18V229000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO REPAIR THE VEHICLE”
— Owner report, NHTSA ODI #11131976
“The contact owns a 2016 Audi Q5. The contact stated while driving at various speeds, an abnormal rattling sound was coming from the vehicle with the check engine warning light illuminated”
— Owner report, NHTSA ODI #11421134

Read all complaints on NHTSA →

Fuel system leaks and gasoline odor

FUEL/PROPULSION SYSTEM

5 NHTSA complaints · 2021-12 → 2026-05

“While driving and when parked, a strong odor of gasoline enters the cabin and garage. This poses a significant risk of fire and health hazards from fumes. The issue relates to the fuel system”
— Owner report, NHTSA ODI #11681153
“On Wednesday, December 1, 2021 I filled my car up with gas. Shortly after I noticed a fuel smell from the outside and on the inside of the car”
— Owner report, NHTSA ODI #11442651
“I am reporting a safety issue involving my 2016 Audi Q5. The vehicle previously underwent recall 20Z8/20W9, which addresses fuel pump flange cracking that can cause fuel leaks and fuel vapor odors”
— Owner report, NHTSA ODI #11735198

Read all complaints on NHTSA →

Unintended acceleration during braking or parking

VEHICLE SPEED CONTROL

5 NHTSA complaints · 2016-11 → 2023-11

“I HAVE A 2016 AUDI Q5 AND RECENTLY WAS INVOLVED IN A SERIOUS SINGLE-CAR ACCIDENT. I WAS PARKING MY CAR AND MOVED MY FOOT TO BRAKE WHEN THE CAR SURGED FORWARD OVER A COUPLE OF BOULDERS THROUGH THE TREES FLIPPING ONCE AND ROLLING DOWN AN EMBANKMENT”
— Owner report, NHTSA ODI #10926196
“I was pulling into a parking space at approximately 5 mph and the car unintentionally accelerated causing me to jump the curb, go over a grass median and land perpendicularly onto a one-way active road”
— Owner report, NHTSA ODI #11552472
“VEHICLE EXPERIENCED UNINTENDED ACCELERATION. HAPPENED [INTERMITTENTLY] WHEN DECELERATING; INSTEAD OF GEARING DOWN TO IDLE/STOP, THE ENGINE CONTINUED TO REV...I HAD TO LEAN HEAVILY ON THE BRAKES [WHICH THEN FELT MUSHY] TO CONTINUE TO A STOP”
— Owner report, NHTSA ODI #11118743

Read all complaints on NHTSA →

Airbag non-deployment in frontal and rear-end collisions

AIR BAGS

3 NHTSA complaints · 2016-07 → 2025-04

“The impact was hard enough to severely damage the vehicle—the pole intruded deep into the engine bay, fluids leaked, and the front end was totaled. Despite this, none of the airbags deployed”
— Owner report, NHTSA ODI #11655859
“AIR BAGS DID NOT DEPLOY IN AUDI AT FULL STOP WHEN STRUCK FROM THE REAR BY VEHICLE TRAVELING AT SPEED SUFFICIENT FOR THEIR AIR BAGS TO DEPLOY”
— Owner report, NHTSA ODI #11363817
“I WAS SURPRISED TO SEE THAT THE AIRBAGS DIDN'T DEPLOY EVEN THOUGH MY FRONT LIGHTS AND HOOD ARE TOTALLY DAMAGED”
— Owner report, NHTSA ODI #10882324

Read all complaints on NHTSA →

Side mirror blind spots obstructing driver view

VISIBILITY/WIPER

3 NHTSA complaints · 2016-02 → 2019-09

“THE MIRRORS ON MY AUDI Q5 ARE TOO HIGH AND BIG. THEY COMPLETELY OBSTRUCT MY VIEW WHEN MAKING A LEFT HAND TURN. I EITHER HAVE TO LOOK BELOW OR ABOVE THEM SOMEHOW TO SEE”
— Owner report, NHTSA ODI #10836266
“SIDE MIRRORS TOTALLY BLOCK VISION AT CERTAIN ANGLES. I WAS STOPPED AT A TRAFFIC LIGHT ON A DOWNTOWN STREET. LIGHT CHANGED AND I MADE A LEFT TURN AND CRASHED RIGHT INTO A CAR THAT WAS TOTALLY BLOCKED FROM VIEW BY THE SIDE VIEW MIRROR”
— Owner report, NHTSA ODI #10915100
“MY EXPERIENCE WITH SAFETY HAZARDS IN REFERENCE TO MOTOR VEHICLES I HAVE CONCLUDED THAT THE SIDE VIEW MIRRORS ON THE Q5 (2016)ARE WAY TOO BIG AND OBSTRUCTS YOUR VISUAL FIIELD ESPECIALLY THE DRIVERS SIDE MIRROR”
— Owner report, NHTSA ODI #11253302

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Longlife Service)

Every 10,000 mi

Replace oil and filter every 10,000 miles or 12 months with VW 502 00 / 504 00 / 508 00 spec oil. S and RS models driven hard: many owners shorten to 5,000-7,500 miles. Wrong-spec oil is the leading cause of TFSI timing-chain tensioner and PCV problems.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 10,000 mi

Rotate every 10,000 miles with the oil service. quattro models: keep all four tires within 4/32" of each other — mismatched wear stresses the center differential.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect pads, rotors, and wear sensors every 10,000 miles. Audi uses electronic pad-wear sensors on most models — replace the sensor with the pads.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 24,000 mi

Replace DOT 4 brake fluid every 2 years regardless of mileage — Audi's published schedule is time-based because the fluid absorbs moisture.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

S tronic Dual-Clutch Fluid

Every 40,000 mi

S tronic (DSG) gearboxes on A3/S3/RS 3, Q3, TT, and many A5/Q5 models: replace fluid and filter every 40,000 miles with the VW Group-spec fluid for your gearbox code. Skipping this service is the most common cause of mechatronic failure.

Estimated cost — typical U.S. ranges

Dealer

~$470–$640

Shop

~$330–$450

DIY

Pro only

VW/Audi DSG service needs a fluid-fill procedure at a specific temperature — shop equipment territory.

Important maintenance

Keeps your vehicle running smoothly and efficiently

quattro Coupling Fluid (Transverse Models)

Every 40,000 mi

A3/S3/RS 3, Q3, and TT use a Haldex-style rear coupling: replace its fluid roughly every 40,000 miles (some model years specify sooner — check your manual). Longitudinal quattro (A5-A8, Q5, Q8) has no coupling service; see differential fluid instead.

Estimated cost — typical U.S. ranges

Dealer

~$220–$290

Shop

~$155–$205

DIY

~$40–$90

VW/Audi/Volvo AWD coupling — specific fluid required. Filter usually swapped at the same time.

Spark Plugs

Every 40,000 mi

TFSI turbo engines: new plugs every 40,000 miles. RS models with the 2.5 TFSI five-cylinder: consider 30,000 miles under track or hard street use.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 40,000 mi

Replace every 40,000 miles; inspect at 20,000 on turbocharged engines — a clogged filter shows up as sluggish boost response first.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Timing Chain (EA888 — Inspect Tensioner)

On condition / lifetime

2.0 TFSI (EA888) engines before roughly 2013 had timing-chain tensioner failures — have the tensioner revision checked by 80,000 miles on earlier cars. Later engines carry the updated design with no scheduled service.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Differential Fluid (Longitudinal quattro)

Every 60,000 mi

Q5, Q8, and A5-A8 quattro: independent Audi specialists recommend front/rear differential fluid service around 60,000 miles even where Audi lists it as lifetime fill.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Dust & Pollen Filter

Every 20,000 mi

Replace the cabin air filter every 20,000 miles or 2 years. Audi specifies an activated-carbon filter on most models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

G12evo / G13 Coolant

On condition / lifetime

Audi coolant is labeled lifetime fill. Independent VW/Audi specialists recommend a refresh around 5 years or 100,000 miles to protect the water pump and thermostat housing — and only with the correct pink/lilac VW Group coolant.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

13 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

9

complaints mentioning a crash

1

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2016 Audi Q5 reflects Audi's published service intervals and the Audi Service Interval Display system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →