Wrench.Pro

2016 Bmw I3 Recalls, Issues & Maintenance

The 2016 Bmw I3 carries 2 open NHTSA recalls — most recently covering frontal and hoses, lines/piping, and fittings. Owners report 4 recurring issue clusters, led by “Carbon fiber roof panel delamination.” BMW vehicles use Condition-Based Service (CBS) — the dashboard shows each service item with its own remaining mileage and time, calculated by sensors. The schedule below shows BMW's underlying targets. BMW Ultimate Care covers the first 3 years / 36,000 miles of factory-scheduled maintenance on most new vehicles.

2 Open Recalls

Source: NHTSA

AIR BAGS:FRONTAL

Campaign #17V720000 · Nov 16, 2017

Issue: BMW of North America, LLC (BMW) is recalling certain 2014-2018 BMW i3 electric and hybrid electric vehicles. Unbelted, small adult, drivers may be at a higher risk of neck injury in the event of a frontal crash. These vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Risk: During a frontal impact, unbelted, small adult, drivers could be at a higher risk of neck injury.

Fix: BMW will notify owners, and dealers will update the Driver air bag control unit software, free of charge. The recall is expected to begin January 8, 2018. Owners may contact BMW customer service at the dedicated i3 recall number 1-855-269-3361.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Campaign #17V088000 · Sep 2, 2017

Issue: BMW of North America, LLC (BMW) is recalling certain 2014-2017 i3 REx hybrid electric vehicles. The fuel tank vent line may rub against the ribbed wire protection sleeve of the battery positive (B+) cable, creating a hole in the vent line and causing a fuel vapor leak.

Risk: A fuel vapor leak in the presence of an ignition source can increase the risk of a fire.

Fix: BMW will notify owners, and dealers will inspect the fuel vent line, replacing it as necessary, and install a clip to prevent it from chafing, free of charge. The recall beganApril 3, 2017. Owners may contact BMW customer service at 1-800-525-7417.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2016 Bmw I3.

Reported to NHTSA

Carbon fiber roof panel delamination

STRUCTURE

9 NHTSA complaints · 2023-08 → 2025-03

“The roof has bubbled and peeled away leaving an exposed permeable roof, meaning if it rains, water will get into the car because of the roof material being not safe, not strong, peeling away. Just terrible! Looking online, so many people with i3s ha e all had the same issue!”
— Owner report, NHTSA ODI #11646070
“The contact owns a 2016 BMW I3. The contact stated while driving 75 MPH, the contact heard a whistling sound, and the roof detached from the vehicle. The vehicle was taken to the dealer, but no assistance was provided. The vehicle was not repaired. The manufacturer was”
— Owner report, NHTSA ODI #11539150
“The roof is bubbling and peeling up. Water gets in it when it rains, then it bubbles greatly. BMW won’t fix it, repair shops don’t want to fix it because it’s an obscure roof. They recommend I take it to BMW which won’t fix it (roof replacement suggested). I just bought this car”
— Owner report, NHTSA ODI #11548761

Read all complaints on NHTSA →

Loss of propulsion with Range Extender engaged

POWER TRAIN

4 NHTSA complaints · 2016-05 → 2026-01

“While driving my 2016 BMW i3 with Range Extender, the vehicle experiences sudden and complete loss of propulsion at very low state of charge (0–1%). The car abruptly loses motive power, forcing me to pull over, sometimes while in traffic. After sitting for several minutes”
— Owner report, NHTSA ODI #11711282
“WHEN ELECTRIC RANGE IS OUT, THE ENGINE KICKS IN AND SPEED IMMEDIATELY DROP TO 50+MPH ON THE FREEWAY CLIMBING UP A HILL THE FIRST DAY I BOUGHT THE CAR WHICH SCARES ME AND I HAVE TO STAY ON THE LEFT LANE AND QUICKLY EXIT. I JUST READ THE LAWSUIT WHICH IS EXACTLY WHAT HAPPEN TO ME”
— Owner report, NHTSA ODI #10865893
“STARTED THE CAR AFTER CHARGING IT OVERNIGHT AND "DRIVETRAIN: STOP CAREFULLY" AND "TRANSMISSION MALFUNCTION" APPEARED ON THE DASHBOARD. THE CAR HAS BEEN COMPLETELY FINE BEFORE THIS”
— Owner report, NHTSA ODI #11306969

Read all complaints on NHTSA →

Intermittent power steering assist loss

STEERING

9 NHTSA complaints · 2019-08 → 2023-02

“Vehicle experiences periodic loss of "power steering". Very difficult to steer or control. Steering does not re-center making control difficult. Steering is restored after shutting down the car for a few minutes. Dealership cannot find any faults or codes”
— Owner report, NHTSA ODI #11438343
“POWER STEERING FAILURE WHILE IN MOTION - OPERATING THE VEHICLE ON PUBLIC ROADWAY - MAKING IT DIFFICULT AND DANGEROUS TO NAVIGATE A TURN. NO WARNING LIGHTS APPEARED”
— Owner report, NHTSA ODI #11404544
“EVERY 3 TO 21 DAYS, MY STEERING PULLS HARD TO THE LEFT. THIS OCCURS ON FLAT ROADS ON DRY PAVEMENT. I HAVE TO PULL THE STEERING WHEEL HARD TO THE RIGHT TO KEEP THE VEHICLE GOING STRAIGHT AT CITY DRIVING SPEEDS (0-35 MPH). ON ONE OCCASION THIS OCCURRED WHILE ON THE FREEWAY DRIVING”
— Owner report, NHTSA ODI #11361132

Read all complaints on NHTSA →

Driver airbag module fault and warning light

AIR BAGS

5 NHTSA complaints · 2021-11 → 2026-06

“Driver airbag warning light illuminated. Vehicle was diagnosed at BMW of Sherman Oaks (RO# 176741) and confirmed as a faulty driver airbag module - part# 32-30-6-870-366. BMW technician found fault code 930904: Driver's airbag interval stage 1, resistance too high stored. BMW NA”
— Owner report, NHTSA ODI #11743788
“Involved in a frontal collision and air bag did not deploy. Airbag could've prevented more serious injuries suffered. I contacted the service center at BMW Roseville and left a message for the service manager, no return call. The vehicle has been inspected by an insurance”
— Owner report, NHTSA ODI #11439937
“The contact owns a 2016 BMW I3. The contact stated that the driver restraint warning light was illuminated. The vehicle was diagnosed by the dealer, and the contact was informed that the front driver’s side air bag system was defective and needed to be replaced. The vehicle was”
— Owner report, NHTSA ODI #11502605

Read all complaints on NHTSA →

Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil Service (CBS)

Every 10,000 mi

Replace BMW Longlife-04 (LL-04) full-synthetic oil and filter every 10,000 miles or annually — whichever the CBS system signals first. M-series engines may require shorter intervals; check the vehicle-specific iDrive screen.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Brake Fluid Service (CBS)

Every 24,000 mi

Replace DOT 4 LV brake fluid every 2 years regardless of mileage. CBS triggers based on time, not miles, due to moisture absorption.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Vehicle Check / Inspection (CBS)

Every 30,000 mi

Multi-point inspection covering brakes, suspension, steering, exhaust, fluids, lighting, and underbody. CBS signals every 30,000 miles or 2 years.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free with any paid service. A flashlight and 10 minutes covers the basics yourself.

Engine Air Filter

Every 40,000 mi

Replace engine air filter every 40,000 miles. Higher-performance N55, B58, and S58 engines should be inspected at every oil service.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs

Every 60,000 mi

B48 (2.0L turbo) and B58 (3.0L turbo) require new spark plugs every 60,000 miles. N20/N55 engines often spec 45,000 miles. M-series typically 30,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Automatic Transmission Fluid (ZF 8HP)

Every 60,000 mi

BMW labels the ZF 8HP automatic as 'lifetime fill,' but independent transmission specialists strongly recommend replacement every 60,000 miles. Use BMW-spec ZF Lifeguard 8 — no substitutes.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Rear Differential Fluid

Every 60,000 mi

RWD and xDrive AWD: replace rear diff fluid every 60,000 miles, sooner with M-Sport or active differential. M-cars require BMW SAF-XO synthetic.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

xDrive Transfer Case Fluid

Every 60,000 mi

BMW xDrive AWD: replace transfer case fluid every 60,000 miles. Skipping this causes the most common xDrive failure — actuator stuck in 100/0 split.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Microfilter (Cabin Air Filter)

Every 30,000 mi

Replace the activated-carbon microfilter every 30,000 miles. Most BMWs have a single combined cabin/charcoal filter behind the engine bay firewall.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Engine Coolant (G48 / HT-12)

On condition / lifetime

BMW labels coolant as lifetime fill on most modern vehicles. Independent BMW specialists recommend replacement every 4-5 years to prevent water-pump and thermostat housing degradation.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

1 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

3

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2016 Bmw I3 reflects BMW's published service intervals and the Condition-Based Service system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →