The 2016 Chevrolet Sonic carries 2 open NHTSA recalls — most recently covering software and radio/tape deck/cd etc.. Owners report 6 recurring issue clusters, led by “Infotainment and electrical system malfunctions.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.
ELECTRICAL SYSTEM:SOFTWARE
Campaign #16V422000 · Oct 6, 2016
Issue: General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Sonic and Trax, and 2013-2015 Spark vehicles equipped with a Bring Your Own Media radio. The affected radios may fail to provide an audible warning chime when the driver fails to fasten their seatbelt or if the driver leaves the key in the ignition. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208 "Occupant Crash Protection" and 114 "Theft Protection."
Risk: Without audible indicators, the driver may not fasten their seatbelt, increasing the risk of injury during a crash.
Fix: GM will notify owners, and dealers will update the radio software, free of charge. The recall began on July 22, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 45340.
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
Campaign #16V257000 · Apr 28, 2016
Issue: General Motors LLC (GM) is recalling certain model year 2013-2016 Chevrolet Sonic and Trax vehicles and 2013-2015 Chevrolet Spark vehicles equipped with a Bring Your Own Media radio. The affected radios may fail to provide an audible warning chime when the driver, after turning off the ignition and leaving the key in the cylinder, waits 10 minutes or longer to open the door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114 "Theft Protection."
Risk: Without audible indicators, the driver may leave the key in the ignition, increasing the risk of theft.
Fix: GM will notify owners, and dealers will update the radio software, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17130.
What drivers and federal regulators have officially reported about the 2016 Chevrolet Sonic.
ELECTRICAL SYSTEM
7 NHTSA complaints · 2019-02 → 2026-01
“TURN SIGNAL INDICATORS DO NOT MAKE SOUND WHEN ACTIVE”
“Radio malfunctions. Channels automatically change and touch screen doesn't work all the time. I believe 2015 Sonic has a recall for this issue , but not 2016. It appears to be the same issue”
STEERING
3 NHTSA complaints · 2016-07 → 2025-08
“WHEN BACKING UP AND GOING FORWARD UP TO 25 MPH THE FRONT SUSPENSION WAS VERY NOISY. FRONT SWAY LINKS REPLACED BY DEALER UNDER WARRANTY”
“THE VEHICLE WAS PURCHASED NEW WITH LESS THAN 50 MILES ON IT. THE VEHICLE SWAYS AND DRIFTS AT HIGHWAY SPEEDS. IT MOVES LEFT AND RIGHT IN THE LANE. I DON'T FEEL SAFE IN THE VEHICLE. I DON'T FEEL I AM IN CONTROL OF THE VEHICLE. I NOTICE THIS AT SPEEDS OF ABOUT 45 MPH AND ABOVE”
ENGINE
12 NHTSA complaints · 2018-11 → 2024-06
“CAR SHUTS OFF RANDOMLY DURING STOP LIGHTS. I'VE RESEARCHED IT AND HAVE FOUND IT'S A KNOWN ISSUE WITH MY MODEL. WHEN IDLING IT WILL RANDOMLY SHUT OFF COMPLETELY AND WON'T TURN BACK ON FOR A FEW SECONDS TO MINUTES. IT WILL DO IT AT STOP SIGNS STOP LIGHTS. EVEN IN IM JUST PARKED”
“CAR SHUTS OFF AND CHECK ENGINE LIGHT COMES ON, WHEN IT IS BEING DRIVEN. ALWAYS WHEN WE HAVE HAD RAIN. WE HAVE TAKEN CAR TO DEALER AND THEY CANNOT FIND THE PROBLEM. ONCE WE PUT HEAT IN THE GAS TANK IT STARTS TO DRIVE UNTIL ANOTHER RAIN HITS”
ENGINE AND ENGINE COOLING, ENGINE
4 NHTSA complaints · 2018-10 → 2026-02
“This car overheated and a head gasket blew. I am on a Facebook forum, and it seems like all of these cars have these problems. The Chevy Sonic ltz turbo 1.4 2016 is known for coolant issues and head gasket failures. My car only had 104,000 miles on it. It should last a lot”
“TL* THE CONTACT OWNS A 2016 CHEVROLET SONIC. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE OVERHEATED, STALLED, AND COMPLETELY SHUT OFF”
AIR BAGS
6 NHTSA complaints · 2018-03 → 2020-10
“THE AIRBAG WARNING LIGHT KEEPS GOING ON AND OFF. THIS HAS BEEN GOING ON FOR APPROX 2 MONTHS”
“THE PASSENGER SEAT SENSOR FOR THE AIR BAGS INTERMITTENLY TURNS THE AIR BAG ON FOR AN ADULT SITTING IN THE SEAT. MY WIFE WEIGHS 93 # AND SHOULD ACTIVATE THAT SENSOR BUT DOES NOT DO SO CONSISTENTLY. DEALER CLAIMS IT IS SET FOR 95 # BUT EVEN WHEN MY WIFE HOLDS AN 8# WEIGHT IN HER”
SERVICE BRAKES
3 NHTSA complaints · 2017-12 → 2021-12
“TL* THE CONTACT OWNS A 2016 CHEVROLET SONIC. WHILE PULLING INTO A PARKING SPOT, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE ACCELERATED. THE VEHICLE DROVE OVER A CONCRETE MEDIAN AND THROUGH BUSHES BEFORE COMING TO A COMPLETE STOP. THE CONTACT SUSTAINED A THUMB INJURY”
“My vehicle malfunctioned Driving on my way to work entering a large parking area connected stores. I saw a available parking spot in between 2 cars I drove in the spot lined up car and put my car in park completely stopped.I looked to my right then to my left to be sure I wasn't”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Extends the life of your vehicle and improves comfort
Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
51 crashes 2010–2024
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
8
complaints mentioning a crash
1
complaints mentioning a fire
Reviewed known issues for this vehicle·Open recalls for this vehicle
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2016 Chevrolet Sonic reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.