Wrench.Pro

2016 Mitsubishi Lancer Recalls, Problems & Maintenance

The 2016 Mitsubishi Lancer carries 2 open NHTSA recalls — most recently covering relay and control module (tcm/pcm/tecm). Owners report 3 recurring issue clusters, led by “CVT transmission hesitation, jerking, and limp-mode failure.” Mitsubishi publishes short, conservative intervals: oil every 7,500 miles normal / 3,750 severe, and — unlike many rivals — an explicit CVT fluid replacement schedule rather than a 'lifetime fill' claim. Read the severe-service column honestly: stop-and-go city trips, short hops, and hot climates all qualify, and they describe how most Mirages actually live. The 10-year/100,000-mile powertrain warranty stays intact only with documented on-schedule service.

Save this car as:

2 Open Recalls

Source: NHTSA

ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY

Campaign #17V609000 · Sep 29, 2017

Issue: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2015-2017 Outlander, 2015-2016 Lancer and Outlander Sport, and 2015 Lancer Evolution vehicles. These vehicles may have defective relays that can result in an engine stall, reduced engine power or the engine overheating.

Risk: If the engine stalls, there is an increased the risk of a crash.

Fix: MMNA will notify owners, and dealers will replace the affected relays, free of charge. The recall began October 24, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-005.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Campaign #16V563000 · Jul 28, 2016

Issue: Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2015-2016 Outlander Sport vehicles and 2016 Outlander and Lancer vehicles. The affected vehicles are equipped with a constant velocity transmission (CVT) that, in certain driving conditions, may cause a delay in the vehicle accelerating.

Risk: A hesitation during acceleration can increase the risk of a crash.

Fix: MMNA has notified owners, and dealers will reprogram the CVT control unit with modified software, free of charge. The recall began on August 15, 2016. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-006.

Recall data refreshed Sep 20, 2026.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2016 Mitsubishi Lancer.

Reported to NHTSA

CVT transmission hesitation, jerking, and limp-mode failure

POWER TRAIN

22 NHTSA complaints · 2017-03 → 2026-08

“It’s throwing a P084A code and it feels like the transmission is about to let loose. I bought the car with 30,000 on it in 2016 and it has a hair over 136,000 and ever since I’ve had it it’s always had this transmission lag jerk in it. Very scuttle but you can feel it. Then all o”
— Owner report, NHTSA ODI #11674840
“Our 2016 lancer has suddenly started hesitating/ taking seconds to shift from park to reverse/drive. Also while driving vehicle its rpms fluctuate causing a shudder and surge in power or acceleration. This is a very alarming problem as it puts mine and my kids safety as it hesita”
— Owner report, NHTSA ODI #11438417
“I HAVE NOTICED AN ISSUE WITH MY CARS ACCELERATION FROM A 0 MILE PER HOUR STARTING POINT TO A 30 MPH. IT IS VERY SUDDEN AND RANDOM. IT HAS OCCURRED SEVERAL TIMES FROM A STOP AT A TRAFFIC LIGHT OR A STOP SIGN. THERE IS A SECOND TO AS LONG AS 4 SECOND HESITATION IN ACCELERATION. ACC”
— Owner report, NHTSA ODI #10979053

Read all complaints on NHTSA →

Subframe corrosion and structural failure

STRUCTURE

2 NHTSA complaints · 2022-09 → 2024-08

“I've had the vehicle for 7 years and after inspection performed by the dealer, there is so much subframe rot that my car will not pass the next inspection due in April. I've contacted Mitsubishi and they said there is nothing they can do as there isn't any recall. This model of M”
— Owner report, NHTSA ODI #11607451
“The contact owns a 2016 Mitsubishi Lancer. The contact stated while driving down his driveway at an undisclosed speed, he heard an abnormal popping sound coming from underneath the front end of the vehicle. The contact engaged the parking brake. The vehicle was taken to an indepe”
— Owner report, NHTSA ODI #11483994

Read all complaints on NHTSA →

Electrical system failure causing loss of motive power

ELECTRICAL SYSTEM

3 NHTSA complaints · 2020-06 → 2022-08

“The contact owns a 2016 Mitsubishi Lancer. The contact stated that while his wife was driving approximately 50 MPH, the RPM increased from 2,000 to 5,000. Additionally, speedometer became inoperable, he brake was not working as designed, and the Service Transmission message was d”
— Owner report, NHTSA ODI #11482208
“The contact owns a 2016 Mitsubishi Lancer. The contact stated while driving approximately 35 MPH, the vehicle lost motive power. The contact stated he was not sure if any warning lights were illuminated. The contact was able to safely pull over to the side of the road. The vehicl”
— Owner report, NHTSA ODI #11457333
“THE CAR DOESNT CRANK AND WE HAVE TO WAIT LIKE 2 OR 3 MIN AND THEN WILL CRANK BUT STRUGGLING”
— Owner report, NHTSA ODI #11331284

Read all complaints on NHTSA →

Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 7,500 mi

Replace every 7,500 miles normal / 3,750 severe. Mirage's 1.2L three-cylinder holds barely over 3 quarts — small sumps punish stretched intervals. 0W-20 on most recent models.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

CVT Fluid

Every 60,000 mi

Mitsubishi schedules CVT fluid replacement — commonly every 60,000 miles normal / 30,000 severe (check your year's table). Use only the specified CVT fluid (J4/CVTF-J4 family); generic ATF destroys the belt-and-pulley unit.

Estimated cost — typical U.S. ranges

Dealer

~$360–$500

Shop

~$255–$355

DIY

~$80–$180

CVT fluid is manufacturer-specific and pricey — do NOT substitute conventional ATF.

Tire Rotation

Every 7,500 mi

Rotate with every oil change. Light Mirages are easy on tires but the economy-focused OEM rubber wears fast when neglected.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors/drums, and lines at each service — Mirage G4 retains rear drums, which need periodic adjustment checks.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace every 2-3 years per the schedule. Cheap job, big ABS-unit insurance.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Spark Plugs

Every 60,000 mi

Iridium plugs commonly every 60,000 miles on the Mirage's 3A92 and Lancer's 4B11 — verify your year's table, as some engines list up to 105,000.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 15,000 mi

Mitsubishi's schedule replaces the engine air filter every 15,000 miles — shorter than most brands, and a 5-minute DIY on the Mirage.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Drive Belt

Every 60,000 mi

Inspect from 60,000 miles and replace on cracking. The Mirage's single serpentine belt also drives the A/C — a failure strands the car's accessories at once.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace every 15,000 miles, behind the glovebox. Often skipped at quick-lube visits — worth checking if airflow feels weak.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Coolant Replacement

Every 60,000 mi

First change around 60,000 miles, then roughly every 30,000-45,000 per the schedule. Mitsubishi long-life coolant or equivalent OAT for your year.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Battery Test & Service

Every 25,000 mi

Test annually after year 3. Small-battery economy cars have little reserve — the first cold snap finds a weak one.

Estimated cost — typical U.S. ranges

Dealer

~$225–$390

Shop

~$160–$280

DIY

~$130–$250

Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

4 crashes 1990–2024

How the 4 occupant deaths break down

4

driver deaths

0

passenger deaths

4

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2016 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

1

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2016 Mitsubishi Lancer reflects Mitsubishi's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →