2016 Nissan Titan Recalls, Problems & Maintenance

The 2016 Nissan Titan carries 3 open NHTSA recalls — most recently covering tank assembly and labels. No recurring owner-reported issue clusters are on file. Nissan owner's manuals split service into Schedule 1 (severe) and Schedule 2 (normal). Most US drivers fall under Schedule 1. The biggest preventable failure on Nissan vehicles is CVT transmission damage from extended fluid intervals — owners of Altima, Rogue, Sentra, Pathfinder, and Murano with CVT should not skip it.

Save this car as:

3 Open Recalls

Source: NHTSA

FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

Campaign #16V847000 · Nov 22, 2016

Issue: Nissan North America, Inc. (Nissan) is recalling certain model year 2016 Titan Diesel XD vehicles manufactured August 7, 2015, to September 1, 2016. The affected vehicles may not have had the temporary fuel tank breather tube cap removed during the vehicle's assembly and the fuel tank breather tube may not have been connected to the bed rail. As a result, the fuel tank may not have the proper ventilation, possibly causing the fuel gauge and the distance to empty meter to both display inaccurately.

Risk: If the fuel gauge reads incorrectly, the vehicle can run out of fuel without the driver being aware, increasing the risk of a crash.

Fix: Nissan will notify owners, and dealers will inspect the fuel tank breather tube, replacing the fuel tank, fuel sending unit, and/or fuel tank breather tube, as necessary, free of charge. The recall began on December 12, 2016. Owners may contact Nissan customer service at 1-800-647-7261.

EQUIPMENT:OTHER:LABELS

Campaign #18V240000 · Apr 16, 2018

Issue: Nissan North America, Inc. (Nissan) is recalling certain 2016-2018 Nissan Titan, 2016 and 2018 Nissan Titan XD vehicles. Accessories installed on these vehicles reduced the load carrying capacity, however, a Load Carrying Capacity modification label was not installed, possibly allowing the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Risk: An overloaded vehicle can increase the risk of a crash.

Fix: Nissan will notify owners and provide a new modification label, with installation instructions, free of charge. The recall began on June 4, 2018. Owners may contact Nissan customer service at 1-800-867-7669.

SEAT BELTS:REAR/OTHER

Campaign #17V268000 · Apr 24, 2017

Issue: Nissan North America, Inc. (Nissan) is recalling certain 2016-2017 Nissan Titan Crew Cab and Titan XD Crew Cab vehicles. In the event of a crash, the rear seatbelt assembly may not adequately protect the occupant's head, allowing it to contact the D-ring bolt trim cap. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 201, "Occupant Protection in Interior Impact."

Risk: If the occupant's head contacts the D-ring bolt trim cap during a crash, there is an increased risk of injury.

Fix: Nissan will notify owners, and dealers will install energy absorbing material to the C-Pillar Finishers and replace the Seatbelt Bolt and Bolt Cap, free of charge. The recall began September 19, 2017. Owners may contact Nissan customer service at 1-800-647-7261.

Recall data refreshed Sep 20, 2026.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2016 Nissan Titan.

Reported to NHTSA

No common issues reported to NHTSA for the 2016 Nissan Titan. That doesn't mean nothing can go wrong — just that the federal complaint database doesn't flag a pattern.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 5,000 mi

Replace synthetic-blend or full-synthetic oil every 5,000 miles under Schedule 1. Schedule 2: 7,500 miles. VR30DDTT (3.0L twin-turbo): full synthetic only.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 5,000 mi

Rotate tires every 5,000 miles. Front-wheel-drive Nissans (Altima, Sentra, Versa) wear front tires fast — don't skip rotations.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

CVT Fluid (NS-3)

Every 60,000 mi

Nissan officially calls CVT fluid 'lifetime,' but independent technicians and Nissan TSBs recommend replacement every 60,000 miles to prevent CVT failure. Use Nissan NS-3 fluid only — substitutes destroy the belt-and-pulley system.

Estimated cost — typical U.S. ranges

Dealer

~$360–$500

Shop

~$255–$355

DIY

~$80–$180

CVT fluid is manufacturer-specific and pricey — do NOT substitute conventional ATF.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake every 7,500 miles. Rogue and Pathfinder front pads typically last 35,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 2 years. Dark or amber fluid indicates moisture contamination.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles, sooner if driving on dusty unpaved roads.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs

Every 105,000 mi

Iridium-tipped spark plugs are rated 105,000 miles on QR25, MR20, and VQ35 engines. VR30DDTT: 60,000 miles due to higher cylinder pressures.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Long-Life Coolant

Every 75,000 mi

Nissan Long-Life Antifreeze/Coolant (blue/green): first change at 105,000 miles, then every 75,000. Do not mix with other coolant chemistries.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Transfer Case / Rear Diff (AWD models)

Every 60,000 mi

On AWD and 4WD models, replace transfer case fluid and rear differential fluid every 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace cabin air filter every 15,000 miles. Located behind the glove box on Altima, Rogue, and Sentra.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

3 crashes 1990–2024

How the 3 occupant deaths break down

driver deaths

passenger deaths

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2021 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

complaints mentioning a crash

complaints mentioning a fire

Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2016 Nissan Titan reflects Nissan's published service intervals and the Maintenance Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →