Wrench.Pro

2019 Hyundai Veloster N Recalls, Issues & Maintenance

The 2019 Hyundai Veloster N carries 1 open NHTSA recall — most recently covering control/drive module. Owners report 4 recurring issue clusters, led by “Driver door will not open from outside in cold.” Hyundai's owner's manual splits service into Normal and Severe schedules. Most US drivers qualify as Severe due to short trips, extreme temperatures, or stop-and-go traffic. Hyundai Assurance covers the first 3 years / 36,000 miles of complimentary maintenance on new vehicles. The Theta II 2.0L and 2.4L engines (2011-2019) are subject to TSBs around oil consumption — strict adherence to oil intervals matters.

1 Open Recall

Source: NHTSA

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP:CONTROL/DRIVE MODULE

Campaign #24V528000 · Dec 7, 2024

Issue: Hyundai Motor America (Hyundai) is recalling certain 2019-2022 Veloster N, 2019-2023 Genesis G70, 2022-2023 Elantra N, and Kona N vehicles. The fuel pump may fail, which can result in a loss of drive power.

Risk: A loss of drive power can increase the risk of a crash.

Fix: Dealers will update engine control module software. In addition, dealers will inspect and replace the fuel pump assembly, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed beginning September 9, 2024. Some interim notification letters, notifying owners of the safety risk, were mailed September 3, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's numbers for this recall are 262 and 023G.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2019 Hyundai Veloster N.

Reported to NHTSA

Driver door will not open from outside in cold

STRUCTURE

7 NHTSA complaints · 2019-12 → 2025-01

“DRIVER'S SIDE DOOR HANDLE DOES NOT WORK ON THE OUTSIDE IN COLD WEATHER, THE CAR HAS TO BE ENTERED FROM THE PASSENGER SIDE DOOR AND OPENED FROM THE INSIDE”
— Owner report, NHTSA ODI #11437519
“IN TEMPERATURES BELOW 35 DEGREES, THE DRIVERS DOOR DOES NOT OPEN. IT CLEARLY MAKES AN UNLOCKING SOUND WHEN UNLOCK IS ACTIVATED, BUT THE HANDLE ACTS AS IF IT IS LOCKED. I HAVE TO CRAWL THROUGH ANOTHER DOOR TO OPEN IT FROM THE INSIDE. ONLY THE DRIVER SIDE DOOR IS EFFECTED, AND IT”
— Owner report, NHTSA ODI #11310315
“The contact owns a 2019 Hyundai Veloster. The contact stated that on several occasions while the vehicle was parked in extremely cold weather, the driver’s side door failed to open or close as needed. The vehicle was taken to a dealer where it was diagnosed and determined that”
— Owner report, NHTSA ODI #11633614

Read all complaints on NHTSA →

Rear hatch glass shatters spontaneously

STRUCTURE, VISIBILITY/WIPER

2 NHTSA complaints · 2019-09 → 2019-09

“THE REAR HATCH WINDOW SHATTERED SUDDENLY WHEN CLOSING THE DRIVER'S DOOR. VEHICLE WAS STATIONARY IN DRIVEWAY. THERE WAS NO PREVIOUS DAMAGE TO THE REAR HATCH WINDOW”
— Owner report, NHTSA ODI #11255775
“THE REAR HATCH WINDOW SHATTERED SUDDENLY WHEN CLOSING THE DRIVER'S DOOR. VEHICLE WAS STATIONARY IN DRIVEWAY. THERE WAS NO PREVIOUS DAMAGE TO THE REAR HATCH WINDOW”
— Owner report, NHTSA ODI #11255776

Read all complaints on NHTSA →

Clutch pack failure disables power and brakes

POWER TRAIN

2 NHTSA complaints · 2020-08 → 2024-02

“THE VEHICLE CLUTCH DISC DELAMINATED AND EXPLODED WHILE DRIVING THE VEHICLE. THE PRESSURE PLATE, CLUTCH CYLINDER AND SEVERAL HYDRAULIC PARTS WERE ALSO DAMAGED. THIS ALSO CAUSED THE BRAKES TO STOP WORKING SINCE THE CLUTCH AND BRAKES SHARE A RESERVOIR”
— Owner report, NHTSA ODI #11349587
“The contact owns a 2019 Hyundai Veloster. The contact stated while driving at approximately 65 MPH, there was an abnormal sound coming from the engine. The contact stated that it sounded as if the engine was revving without the accelerator pedal being depressed. The contact”
— Owner report, NHTSA ODI #11574427

Read all complaints on NHTSA →

Rod bearing or piston ring failure seizes engine

ENGINE

17 NHTSA complaints · 2019-05 → 2025-06

“While driving the vehicle the engine stalled in the middle of a turn. We were able to safely move the vehicle to the side of the road immediately out of harms way. The engine would not restart despite adding oil. Prior to the engine stalling there was a light knocking noise but”
— Owner report, NHTSA ODI #11567830
“Defective connecting rod bearings that wore out early, which can lead to engine failure and stalling which almost led to a car crash. The connecting-rod bearings in the engine that could wore out prematurely and damage the engine resulting in engine failure. This created”
— Owner report, NHTSA ODI #11506275
“The contact's daughter owns a 2019 Hyundai Veloster. The contact stated that while her daughter was driving at an undisclosed speed, the check engine warning light illuminated and the engine seized. The vehicle was towed to the dealer where it was diagnosed that a faulty oil”
— Owner report, NHTSA ODI #11460907

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 3,750 mi

Severe service: every 3,750 miles. Normal service: 7,500 miles. Theta II 2.0L/2.4L (Sonata, Santa Fe, Tucson 2011-2019): never extend — oil consumption issues are documented in Hyundai TSBs.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. AWD Tucson and Santa Fe owners benefit from rotation at 5,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, calipers, and parking brake every 7,500 miles. Elantra and Sonata front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 24 months. Required to maintain ABS and ESC pump life.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles. Severe service or dusty conditions: 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 30,000 mi

Severe service: every 30,000 miles. Normal: 60,000 miles. Use Hyundai SP-IV or SPH-IV — substitutes can cause harsh shifting and torque converter damage.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 105,000 mi

Iridium spark plugs are rated 105,000 miles on Theta II, Lambda II, and Smartstream engines. 1.6T (Veloster N, Kona N): 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Long-Life Coolant

Every 30,000 mi

Hyundai Long-Life Coolant (pink): first change at 60,000 miles, then every 30,000. Do not substitute green or orange coolant — it damages the cylinder head gasket on GDI engines.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace cabin air filter every 15,000 miles. Located behind the glove box on most Hyundai models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Drive Belt Inspection

Every 60,000 mi

Inspect serpentine belt and tensioner every 60,000 miles. Replace at 90,000 miles on most models.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2019 Hyundai Veloster N reflects Hyundai's published service intervals and the Service Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →