Wrench.Pro

2019 Toyota Yaris Ia Recalls, Issues & Maintenance

The 2019 Toyota Yaris Ia has no open NHTSA recalls. Owners report 3 recurring issue clusters, led by “Fuel pump failure with stalling or no-start.” Toyota's owner's manual splits service into Schedule 1 (severe) and Schedule 2 (normal). Most US drivers fall under Schedule 1 because it covers short trips, extreme temperatures, dusty roads, or heavy idling. The intervals below reflect Schedule 1 — the schedule Toyota recommends for typical real-world use.

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2019 Toyota Yaris Ia.

Reported to NHTSA

Fuel pump failure with stalling or no-start

FUEL/PROPULSION SYSTEM

8 NHTSA complaints · 2020-09 → 2024-07

“Recall for dangerous issue (risk of crash due to faulty fuel pump) has been unresolved since mid 2021. Have contacted several Toyota dealerships who have said they aren’t able to repair fuel pump since a solution for recall hasn’t been issued yet”
— Owner report, NHTSA ODI #11446982
“After shopping I tried to start my car. It did a lot of shuttering and the check engine and battery lights came on. It would not run”
— Owner report, NHTSA ODI #11431894
“THE CONSUMER STATED THE VEHICLE SHUT OFF WHILE BEING DRIVEN. THE VEHICLE DROVE ROUGH, ENGINE NOISES, AND EXPERIENCED ACCELERATION DELAYS. THE DEALER STATED THAT ALL THE LINES AND GDI ASSOCIATED WITH THE FUEL PUMP HAD CARBON BUILD UP”
— Owner report, NHTSA ODI #11480722

Read all complaints on NHTSA →

Electrical system malfunction with dashboard warning lights

ELECTRICAL SYSTEM

7 NHTSA complaints · 2019-01 → 2023-09

“Car driving with no one in front and brake assist went off on own. Also car driving and electrical system in car shut down and lost control of car. Then all dashboard lights came on, was able to regain control and pull in parking lot”
— Owner report, NHTSA ODI #11547238
“SUDDENLY THE CAR STARTED MAKING A PULLING OR STRAINING NOISE. I WAS SHOCKED SINCE THE CAR WAS BRAND NEW AND I HAD RECENTLY JUST PURCHASED THE CAR. SUDDENLY THE CAR LOCKED AND I HAD NO CONTROL OF IT”
— Owner report, NHTSA ODI #11241985
“THE SAME THING HAPPENED 1/11/19 AND 1/25/19 IN TRAFFIC ON LAKESHORE DRIVE AND THE VEHICLE STOPPED WHILE IN DRIVE MODE AND ALL LIGHTS CAME ON AGAIN WINDOWS WERE STUCK DOORS WERE NOT UNLOCKING AND THE KEY WAS IN THE VEHICLE AS WELL”
— Owner report, NHTSA ODI #11172589

Read all complaints on NHTSA →

Steering alignment drift at highway speed

STEERING

3 NHTSA complaints · 2019-06 → 2022-04

“WITH ONLY 500 MILES ON IT I HAD ALIGNMENT ISSUE WITH THIS BRAND NEW CAR TOYOTA YARIS 2019 WHICH WAS PURCHASED ON APR 2019”
— Owner report, NHTSA ODI #11218385
“AFTER FIX THAT I STILL HAD SAFETY PROBLEM THAT IS EITHER RELATED TO STEERING,TIER, SUSPENSION, BEAM TORSION OR ANYTHING ELSE THAT CAUSE MY CAR FEELING LIKE DRIFTING OR SLIDING TO RIGHT OR LEFT WHILE DRIVING AROUND 60 OR ABOVE”
— Owner report, NHTSA ODI #11218380
“I am constantly having to slightly correct my steering wheel. One to three degrees to the left and right at any speed the entire time I am driving”
— Owner report, NHTSA ODI #11462368

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 5,000 mi

Replace 0W-20 full-synthetic oil and filter every 5,000 miles under Schedule 1, or 10,000 miles under Schedule 2. Toyota covers the first 2 oil changes through ToyotaCare.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 5,000 mi

Rotate tires every 5,000 miles. Toyota recommends rotation at every oil change to maximize tire life on FWD and AWD models.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 5,000 mi

Inspect brake pads, rotors, and parking brake every 5,000 miles. Toyota recommends measuring pad thickness at each service.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 36 months. Critical for the integrity of the ABS, VSC, and brake assist systems.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. Earlier under Schedule 1 if driven on unpaved roads.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 60,000 mi

Toyota labels ATF as 'lifetime fill' on most automatics, but recommends inspection and replacement every 60,000 miles under severe service. Use Toyota WS or Type-IV — no substitutes.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 120,000 mi

Toyota iridium-tipped spark plugs are rated for 120,000 miles. Earlier replacement reduces fuel economy and can cause misfires on direct-injection engines.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Super Long Life Coolant (SLLC)

Every 50,000 mi

Toyota SLLC (pink): first change at 100,000 miles, then every 50,000 miles. Do not substitute green or orange coolant — it will damage the cooling system seals.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 30,000 mi

Replace the cabin air filter every 30,000 miles, sooner in dusty climates. Located behind the glove box on most Toyota and Lexus models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Serpentine / Drive Belt Inspection

Every 60,000 mi

Inspect the serpentine belt and tensioner every 60,000 miles. Toyota uses long-life EPDM belts that rarely fail before 100,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Timing Chain — No Replacement

On condition / lifetime

Toyota's 2AR-FE, 2GR-FKS, A25A-FKS, and most Toyota engines built since 2010 use a timing chain rated for the life of the engine. No scheduled replacement.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2019 Toyota Yaris Ia reflects Toyota's published service intervals and the Maintenance Required Light system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →