Wrench.Pro

2020 Audi A5 Recalls, Issues & Maintenance

The 2020 Audi A5 carries 4 open NHTSA recalls — most recently covering tires and tail lights. Owners report 2 recurring issue clusters, led by “SOS/telematics control module failure.” Audi follows the VW Group Longlife service rhythm: oil and minor service every 10,000 miles or 12 months, whichever comes first, using oil that meets VW 502 00 / 504 00 (or 508 00 for newer 0W-20 engines) — generic synthetic does not qualify. S tronic dual-clutch gearboxes need fluid service every 40,000 miles despite 'lifetime fill' claims. Fully electric models (e-tron, e-tron GT) skip oil service entirely but keep brake-fluid, cabin-filter, and coolant-circuit intervals.

4 Open Recalls

Source: NHTSA

TIRES

Campaign #22V034000 · Jan 26, 2022

Issue: Volkswagen Group of America, Inc. (Audi) is recalling certain 2019-2021 Audi A5 Sportback, RS5 Coupe, RS5 Sportback, S5 Sportback, 2020-2021 A4 Allroad, A4 Sedan, A5 Cabriolet, A5 Coupe, A6 Allroad, A6 Sedan, A7, A8, Q5, S4 Sedan, S5 Coupe, S5 Cabriolet, S6 Sedan, S7, S8, SQ5, 2021 Q5 Sportback, Q7, Q8, RS6 Avant, RS7, RSQ8, SQ5 Sportback, SQ7, and SQ8 vehicles. The rear axle alignment may not have been inspected after the repairs for Recall 21V-295 (42L1) were performed.

Risk: Rear axle misalignment may cause premature or uneven tire wear, increasing the risk of a crash.

Fix: Dealers will inspect the rear axle, adjust the alignment as necessary, and replace any prematurely or unevenly worn tires, free of charge. Owner notification letters were mailed March 3, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 42L5.

EXTERIOR LIGHTING:TAIL LIGHTS

Campaign #20V737000 · Nov 25, 2020

Issue: Volkswagen Group of America, Inc. (Audi) is recalling certain 2021 Audi RS5 Sportback, 2020-2021 Audi A5 Sportback, and S5 Sportback vehicles. The wiring harness for the rear lights could be missing the anti-abrasion protection in the area of the spare wheel well.

Risk: Without the scuff protection, the wires may become damaged during a rear crash, disabling the doors from being opened from the outside, causing a loss of hazard lights, and increasing the risk of injury.

Fix: Audi will notify owners, and dealers will apply scuff protection, free of charge. The recall began January 21, 2021. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 97EU.

SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY

Campaign #21V295000 · Apr 26, 2021

Issue: Volkswagen Group of America, Inc. (Audi) is recalling certain 2021 Q7, Q8, Q5 Sportback, SQ5 Sportback, RS6 Avant, RS7, RS Q8, 2020-2021 Audi S6 sedan, Q5, A8, S8, A7, A6 Allroad, A5 Cabriolet, A4 sedan, A4 Allroad, SQ5, S7, A6 sedan, S5 coupe, S4 sedan, S5 Cabriolet, A5 coupe, 2019-2021 RS5 coupe, A5 Sportback, S5 Sportback, RS5 Sportback vehicles. The lock nut on the trailing arm of the rear axle may break due to stress corrosion.

Risk: A broken lock nut may misalign the rear axle, causing a loss of control and increasing the risk of a crash.

Fix: Dealers will replace the lock nuts and, if necessary, the associated bolts, free of charge. Owner notification letters were mailed June 4, 2021. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 42L1.

SEATS

Campaign #21V874000 · Oct 11, 2021

Issue: Volkswagen Group of America, Inc. (Audi) is recalling certain 2017-2020 A4 Allroad, A4 Sedan, 2018-2019 RS5 Coupe, 2019 RS5 Sportback, 2018-2020 A5 Cabriolet, A5 Coupe, A5 Sportback, S4 Sedan, S5 Cabriolet, S5 Coupe, and Audi S5 Sportback vehicles. The cable connecting the seat heater to the Passenger Occupant Detection System (PODS) may have a contact fault, causing the software to misdiagnose a malfunction and disable the passenger air bag.

Risk: A disabled passenger air bag increases the risk of injury in the event of a crash.

Fix: Dealers will replace the connecting cable and either the heating mat or entire seat cover, free of charge. Owner notification letters were mailed January 7, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 74E3. This recall is an expansion of Recall 19V-547 (74D9). Vehicles previously repaired under 19V-547 will need to return for the new remedy.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2020 Audi A5.

Reported to NHTSA

SOS/telematics control module failure

ELECTRICAL SYSTEM

4 NHTSA complaints · 2022-07 → 2023-12

“Our 2020 Audi A5 experienced a module failure affecting SOS (Loud) audible alarm that sounds every 2-4 minutes when driving and also affects bluetooth connection for hands free phone”
— Owner report, NHTSA ODI #11475875
“Audi issued a service bulletin 90T2 in regards to the telematics control module failure. With this failure the Bluetooth feature in this car no longer works”
— Owner report, NHTSA ODI #11561023
“2020 Audi A5 sportback SOS module malfunctioned in May 2021 and was replaced. Recall for 90t2 SOS module initiated. In June 2022, the malfunctioned occurred again. There has since been no fixes or estimated time of delivery”
— Owner report, NHTSA ODI #11500317

Read all complaints on NHTSA →

MMI infotainment system spontaneous reboot

ELECTRICAL SYSTEM

51 NHTSA complaints · 2025-05 → 2025-10

“The Multi-Media Interface (MMI) randomly reboots and poses a safety hazard. Several times while reversing using my backup camera, the MMI has rebooted which causes the camera to go blank. This poses a risk to back up into an object or a person during this time”
— Owner report, NHTSA ODI #11678628
“MMI constantly shuts off, often in the process of moving into or out of a parking spot. This suddenly and unexpectedly disables the parking collision warning system, the rear cross traffic warning system, and frontal collision warnings. Very frustrating and unsafe”
— Owner report, NHTSA ODI #11674776
“Everytime I am driving around my MMI system keeps rebooting. It disconnects my navigation and back up camera and it takes 10-30 seconds to restart. It does this about once every 2 minutes”
— Owner report, NHTSA ODI #11674094

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Longlife Service)

Every 10,000 mi

Replace oil and filter every 10,000 miles or 12 months with VW 502 00 / 504 00 / 508 00 spec oil. S and RS models driven hard: many owners shorten to 5,000-7,500 miles. Wrong-spec oil is the leading cause of TFSI timing-chain tensioner and PCV problems.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 10,000 mi

Rotate every 10,000 miles with the oil service. quattro models: keep all four tires within 4/32" of each other — mismatched wear stresses the center differential.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect pads, rotors, and wear sensors every 10,000 miles. Audi uses electronic pad-wear sensors on most models — replace the sensor with the pads.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 24,000 mi

Replace DOT 4 brake fluid every 2 years regardless of mileage — Audi's published schedule is time-based because the fluid absorbs moisture.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

S tronic Dual-Clutch Fluid

Every 40,000 mi

S tronic (DSG) gearboxes on A3/S3/RS 3, Q3, TT, and many A5/Q5 models: replace fluid and filter every 40,000 miles with the VW Group-spec fluid for your gearbox code. Skipping this service is the most common cause of mechatronic failure.

Estimated cost — typical U.S. ranges

Dealer

~$470–$640

Shop

~$330–$450

DIY

Pro only

VW/Audi DSG service needs a fluid-fill procedure at a specific temperature — shop equipment territory.

Important maintenance

Keeps your vehicle running smoothly and efficiently

quattro Coupling Fluid (Transverse Models)

Every 40,000 mi

A3/S3/RS 3, Q3, and TT use a Haldex-style rear coupling: replace its fluid roughly every 40,000 miles (some model years specify sooner — check your manual). Longitudinal quattro (A5-A8, Q5, Q8) has no coupling service; see differential fluid instead.

Estimated cost — typical U.S. ranges

Dealer

~$220–$290

Shop

~$155–$205

DIY

~$40–$90

VW/Audi/Volvo AWD coupling — specific fluid required. Filter usually swapped at the same time.

Spark Plugs

Every 40,000 mi

TFSI turbo engines: new plugs every 40,000 miles. RS models with the 2.5 TFSI five-cylinder: consider 30,000 miles under track or hard street use.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 40,000 mi

Replace every 40,000 miles; inspect at 20,000 on turbocharged engines — a clogged filter shows up as sluggish boost response first.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Timing Chain (EA888 — Inspect Tensioner)

On condition / lifetime

2.0 TFSI (EA888) engines before roughly 2013 had timing-chain tensioner failures — have the tensioner revision checked by 80,000 miles on earlier cars. Later engines carry the updated design with no scheduled service.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Differential Fluid (Longitudinal quattro)

Every 60,000 mi

Q5, Q8, and A5-A8 quattro: independent Audi specialists recommend front/rear differential fluid service around 60,000 miles even where Audi lists it as lifetime fill.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Dust & Pollen Filter

Every 20,000 mi

Replace the cabin air filter every 20,000 miles or 2 years. Audi specifies an activated-carbon filter on most models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

G12evo / G13 Coolant

On condition / lifetime

Audi coolant is labeled lifetime fill. Independent VW/Audi specialists recommend a refresh around 5 years or 100,000 miles to protect the water pump and thermostat housing — and only with the correct pink/lilac VW Group coolant.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

1 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

1

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2020 Audi A5 reflects Audi's published service intervals and the Audi Service Interval Display system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →