Wrench.Pro

2022 Ford Ranger Recalls, Issues & Maintenance

The 2022 Ford Ranger carries 5 open NHTSA recalls — most recently covering windshield and hoses, lines/piping, and fittings. Owners report 7 recurring issue clusters, led by “10R80 transmission failure and shifting faults.” Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.

5 Open Recalls

Source: NHTSA

VISIBILITY:WINDSHIELD

Campaign #22V451000 · Jun 24, 2022

Issue: Ford Motor Company (Ford) is recalling certain 2022 Bronco and Ranger vehicles. The windshield may not have been properly bonded to the vehicle, which could allow it to detach during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 212, "Windshield Mounting."

Risk: A windshield that separates from a vehicle during a crash can increase the risk of injury.

Fix: Dealers will remove and reinstall the windshield, free of charge. Owner notification letters were mailed July 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C12.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Campaign #22V685000 · Sep 14, 2022

Issue: Ford Motor Company (Ford) is recalling certain 2022 Explorer and Ranger vehicles equipped with 2.3L engines. The fuel line may be loose due to improper tightening of the fuel line connection.

Risk: An improperly tightened fuel line connection may result in a fuel leak, increasing the risk of fire.

Fix: Ford will inspect and replace the fuel line assembly, if needed, free of charge. Owner notification letters were mailed September 29, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S60.

EQUIPMENT:OTHER:LABELS

Campaign #23V379000 · May 26, 2023

Issue: Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Risk: An overloaded vehicle increases the risk of a crash.

Fix: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.

BACK OVER PREVENTION:SOFTWARE

Campaign #25V442000 · Jun 27, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Fix: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER

Campaign #25V685000 · Oct 10, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Risk: An electrical short circuit can increase the risk of a fire.

Fix: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2022 Ford Ranger.

Reported to NHTSA

10R80 transmission failure and shifting faults

POWER TRAIN

13 NHTSA complaints · 2022-04 → 2026-07

“The contact stated while driving approximately 40 MPH, the vehicle was losing motive power. The contact depressed the accelerator pedal and the vehicle revved but failed to respond as needed. The contact stated that there were no warning lights illuminated. The contact came to a…”
— Owner report, NHTSA ODI #11587499
“The transmission and or converter on the vehicle continue to have harsh vibrations in all gears. The unit has a difficult time finding the right gear for the traveling speed. Some times accelerates slightly from a stopped position which requires excessive force on the brake”
— Owner report, NHTSA ODI #11505415
“Started having issues with 10R80 transmission at 40k then a complete replacement at 53k, nothing but continued problems, now back at shop a week later for knocking and transmission”
— Owner report, NHTSA ODI #11702894

Read all complaints on NHTSA →

Neutral Tow mode and transmission overheating during flat tow

POWER TRAIN

1 NHTSA complaint · 2026-07 → 2026-07

“Vehicle was placed into Ford’s Neutral Tow mode according to the owner’s manual before being recreationally towed behind a motorhome. The instrument cluster displayed Ford’s confirmation that Neutral Tow was enabled and the vehicle was ready for four-wheel-down towing. The…”
— Owner report, NHTSA ODI #11753520

Read all complaints on NHTSA →

Electrical system no-start and module faults

ELECTRICAL SYSTEM

4 NHTSA complaints · 2023-06 → 2024-12

“Truck cut off at an intersection without warning and would not turn back over. After multiple attempts and AAA service members checking batter car would not start. Has power but will not turn over dealership is saying there is a module issue but is not sure”
— Owner report, NHTSA ODI #11630642
“Had someone driving behind me flag me over. I had no tail lights, brake lights, turn signals front or rear or hazzard lights in the front or back. There is only 15,000kms on this truck. Head light low beam and high beam work. trying to get in contact…”
— Owner report, NHTSA ODI #11529833

Read all complaints on NHTSA →

Audio Control Module failure disabling CAN bus systems

ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

1 NHTSA complaint · 2025-12 → 2025-12

“The ACM (Audio Control Module) failed, causing a network failure in the CAN system. This caused a condition of no speedometer reading, no automatic braking, no adaptive cruise control, no fuel gauge reading, no blind spot monitoring, no forward collision, no rear cross traffic…”
— Owner report, NHTSA ODI #11705968

Read all complaints on NHTSA →

Unintended engine RPM surge to 4500 RPM

POWER TRAIN

2 NHTSA complaints · 2023-08 → 2024-08

“Engine revolutions increased to 4500 rpm while waiting for a school bus to unload. Engine revolutions increased to 4500 rpm while waiting at intersection Engine increased to 4500 rpm’s while driving down road slowly in front of school”
— Owner report, NHTSA ODI #11537510
“Five separate incidents where the truck suddenly accelerated to 4500 rpm while in drive. Usually at low speeds. Last incident occurred in driveway where the truck left skid marks on the pavers”
— Owner report, NHTSA ODI #11607226

Read all complaints on NHTSA →

Fuel dilution of engine oil

ENGINE, FUEL/PROPULSION SYSTEM

1 NHTSA complaint · 2024-04 → 2024-04

“Came out the next day and the Garage smelled like a gas can. Looked all around could not find signs of the gas. Got in the truck and was overwhelmed by gas smell. Moved the vehicle out of the garage. Googled the issue and found 170 pages of people with the same issue. The engine…”
— Owner report, NHTSA ODI #11582507

Read all complaints on NHTSA →

Rear windshield spontaneous fracture

VISIBILITY

2 NHTSA complaints · 2022-02 → 2024-06

“The contact stated while driving 2 MPH and exiting the driveway, the contact heard a loud bang coming from the vehicle. The contact stopped the vehicle and noticed that the rear windshield had fractured without impact”
— Owner report, NHTSA ODI #11592254
“I was stopped at a red light, not moving, and the rear window completely shattered, the entire window, except the small center slider”
— Owner report, NHTSA ODI #11449739

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 7,500 mi

Replace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 10,000 mi

Rotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

Ford specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 150,000 mi

Ford 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD models)

Every 60,000 mi

F-150 4x4 and Bronco 4x4: replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Rear Differential Fluid

Every 100,000 mi

F-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Coolant

Every 50,000 mi

Motorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

8 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2022 Ford Ranger reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →