Wrench.Pro

2022 Kia Niro Recalls, Issues & Maintenance

The 2022 Kia Niro carries 1 open NHTSA recall — most recently covering actuators/solenoids. Owners report 4 recurring issue clusters, led by “Recall 23V534 parts unavailability and repair delays.” Kia uses Hyundai Motor Group's powertrains, so service intervals mirror Hyundai's. Kia Promise covers the first 3 years / 36,000 miles of complimentary maintenance. Kia owners with the Theta II 2.0L/2.4L (Optima, Sorento, Sportage 2011-2019) should adhere strictly to oil intervals due to known oil-consumption issues in Kia TSBs.

1 Open Recall

Source: NHTSA

POWER TRAIN:AUTOMATIC TRANSMISSION:INTERNAL:CLUTCHES/BANDS:ACTUATORS/SOLENOIDS

Campaign #23V534000 · Jul 31, 2023

Issue: Kia America, Inc. (Kia) is recalling certain 2017-2022 Niro and 2018-2022 Niro Plug-in Hybrid vehicles. Fluid may leak into the printed circuit board inside the hydraulic clutch actuator, which can result in an engine compartment fire.

Risk: A fire increases the risk of injury.

Fix: Dealers will inspect and replace the hydraulic clutch actuator as necessary and install a new fuse, free of charge. Owner notification letters were mailed December 29, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC276.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2022 Kia Niro.

Reported to NHTSA

Recall 23V534 parts unavailability and repair delays

POWER TRAIN

10 NHTSA complaints · 2023-10 → 2026-11

“The contact owns a 2022 Kia Niro. The contact received notification of NHTSA Campaign Number: 23V534000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall…”
— Owner report, NHTSA ODI #11561195
“The contact owns a 2022 Kia Niro. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. The check engine and Hybrid System…”
— Owner report, NHTSA ODI #11558404
“Vehicle has been submitted for repair under recall RCRIT-23V534-0846. DTC P17ED - Engine clutch system EOL fault, is set and has never gone away. Initially the dealership did the recall in the spring of 2024. It was taken to the dealership after an accident and returned with the…”
— Owner report, NHTSA ODI #11626261

Read all complaints on NHTSA →

12V battery drain and electrical system shutdown

ELECTRICAL SYSTEM

5 NHTSA complaints · 2025-06 → 2026-01

“When I got to work one day I turned off my vehicle and went about my regular day until I went to go home and my car was dead. The entire electrical system wasn’t working. No lights on the dashboard or in the vehicle when I opened the door”
— Owner report, NHTSA ODI #11685917
“express my concern regarding a persistent and unresolved defect in the 12-volt battery of my 2022 Kia Niro, which I purchased from Hanlees Kia in 2022. In 2023, I brought my vehicle back to Hanlees Kia due to the battery dying prematurely”
— Owner report, NHTSA ODI #11666923
“Within a month (Nov 2024), the electrical system would die overnight and we would require a jump start. This seemed to align with colder temperatures. After the first or second jump start, a headlight blew out. We replaced it. Then a tail light blew out and we replaced that one…”
— Owner report, NHTSA ODI #11699174

Read all complaints on NHTSA →

Brake pedal loss with unintended acceleration

SERVICE BRAKES

3 NHTSA complaints · 2022-04 → 2025-06

“The contact stated that the Hybrid Engine alarm activated and illuminated. The contact parked the vehicle for a few hours, and when restarting the vehicle, the alarm was no longer displayed. The contact continued to drive at approximately 5 mph. When pressing the brake pedal to…”
— Owner report, NHTSA ODI #11663050
“Just over 2 weeks after purchase of new Kia Niro the brakes failed completely. The regenerative brake light appeared in red along with the ABS light and several others. I was driving in a major highway and had no pressure in the brake pedal, leaving me completely unable to…”
— Owner report, NHTSA ODI #11462521
“I was turning into a parking spot when my brakes suddenly felt loose, as if they had lost hydraulic pressure, and my vehicle accelerated into a wall. I had my vehicle serviced 3 weeks ago, and my brakes were fine”
— Owner report, NHTSA ODI #11688712

Read all complaints on NHTSA →

Intermittent brake light warning and bulb failure

EXTERIOR LIGHTING, SERVICE BRAKES

3 NHTSA complaints · 2023-07 → 2025-12

“I have received a "Check Brake Light" warning several times now, even after replacing the bulbs. I have replaced them twice now in the past 6 months and the issue persists. I believe it to be a faulty sensor or something similar. Yes, it is available to inspect upon request”
— Owner report, NHTSA ODI #11703967
“Car keeps notifying me of an issue with my left break lights, it has been inspected twice to which both times, Kia services said it just needed a new light but yet this problem keeps happening. Nothing pops up on diagnostics and there are no recalls, this is a brand new car less…”
— Owner report, NHTSA ODI #11531915
“My right brake light keeps going out and it was “fix” before my the Kia dealership and they said it was just a lose harness but months later it has happened again, the warning light constantly comes on and the power to the light is intermittent”
— Owner report, NHTSA ODI #11590360

Read all complaints on NHTSA →

Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 3,750 mi

Severe service: every 3,750 miles. Normal: 7,500 miles. Theta II 2.0L/2.4L on Optima, Sorento, Sportage (2011-2019): full synthetic only, never extend.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Telluride and Sorento AWD owners benefit from rotation every 5,000 miles to prevent uneven wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads and rotors every 7,500 miles. Forte and Soul front pads typically last 40,000-55,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 24 months. Required for ABS and ESC pump longevity.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles. Severe or dusty conditions: 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 30,000 mi

Severe service: every 30,000 miles. Normal: 60,000 miles. Use Kia SP-IV — same as Hyundai.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 105,000 mi

Iridium-tipped plugs rated 105,000 miles on most Kia engines. 1.6T (Forte GT, Soul Turbo): 60,000 miles. 3.5L Lambda II V6 (Telluride, Sorento): 105,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Long-Life Coolant

Every 30,000 mi

Kia Long-Life Coolant (pink, same as Hyundai): first change at 60,000 miles, then every 30,000. Do not mix with green or orange coolant.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Transfer Case / Rear Diff (AWD)

Every 60,000 mi

Sportage AWD, Sorento AWD, Telluride AWD: replace transfer case fluid and rear diff fluid every 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace cabin air filter every 15,000 miles. Located behind the glove box on Optima, Forte, and Sportage; behind the dashboard panel on Telluride.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

3 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

5

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2022 Kia Niro reflects Kia's published service intervals and the Service Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →