Wrench.Pro

2023 Hyundai Kona Recalls, Issues & Maintenance

The 2023 Hyundai Kona carries 1 open NHTSA recall — most recently covering pump. Owners report 2 recurring issue clusters, led by “Horn inoperability and recurring failure.” Hyundai's owner's manual splits service into Normal and Severe schedules. Most US drivers qualify as Severe due to short trips, extreme temperatures, or stop-and-go traffic. Hyundai Assurance covers the first 3 years / 36,000 miles of complimentary maintenance on new vehicles. The Theta II 2.0L and 2.4L engines (2011-2019) are subject to TSBs around oil consumption — strict adherence to oil intervals matters.

1 Open Recall

Source: NHTSA

POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT:PUMP

Campaign #23V526000 · Jul 27, 2023

Issue: Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Palisade Tucson, 2023 Sonata, Elantra, and Kona vehicles. The electronic controller for the Idle Stop & Go oil pump assembly may contain damaged electrical components that can cause the pump controller to overheat.

Risk: An electric oil pump assembly that overheats increases the risk of a vehicle fire.

Fix: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect and replace the electric oil pump controller, as necessary, free of charge. Owner notification letters were mailed starting September 7, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 246.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2023 Hyundai Kona.

Reported to NHTSA

Horn inoperability and recurring failure

ELECTRICAL SYSTEM:HORN

16 NHTSA complaints · 2023-07 → 2026-08

“The contact stated that while pressing the horn pad, the horn failed to produce a sound. The vehicle was taken to the dealer, and the horn was replaced; however, the failure persisted. The contact stated that the horn had been replaced four times and was scheduled for a fifth horn replacement.”
— Owner report, NHTSA ODI #11683578
“The issue is the horn. On three different occasions, I've attempted to use the horn and it wasn't working. I've taken it to Hallmark Hyundai in Flowood and they've repaired and/or replaced the horn on four separate occasions. The new horn is always working when I leave the dealership, but it eventually goes out.”
— Owner report, NHTSA ODI #11687843

Read all complaints on NHTSA →

Rear liftgate latch unintended release and access failure

UNKNOWN OR OTHER

4 NHTSA complaints · 2023-11 → 2026-02

“Rear latch unlocks while vehicle is running or not running up to 30 times at once. Rear latch unlocks without key being in vehicle. This has been reported to Hyundai Motor America since August 2025.”
— Owner report, NHTSA ODI #11715395
“I was trapped inside the liftgate of my 2023 Hyundai Kona and was unable to operate the emergency release. I had the key fob with me and the car was unlocked, but the trunk would not open from the inside. I tried sliding a standard key and a flat card into the release, but it would not engage.”
— Owner report, NHTSA ODI #11688737

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 3,750 mi

Severe service: every 3,750 miles. Normal service: 7,500 miles. Theta II 2.0L/2.4L (Sonata, Santa Fe, Tucson 2011-2019): never extend — oil consumption issues are documented in Hyundai TSBs.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. AWD Tucson and Santa Fe owners benefit from rotation at 5,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, calipers, and parking brake every 7,500 miles. Elantra and Sonata front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 24 months. Required to maintain ABS and ESC pump life.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles. Severe service or dusty conditions: 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 30,000 mi

Severe service: every 30,000 miles. Normal: 60,000 miles. Use Hyundai SP-IV or SPH-IV — substitutes can cause harsh shifting and torque converter damage.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 105,000 mi

Iridium spark plugs are rated 105,000 miles on Theta II, Lambda II, and Smartstream engines. 1.6T (Veloster N, Kona N): 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Long-Life Coolant

Every 30,000 mi

Hyundai Long-Life Coolant (pink): first change at 60,000 miles, then every 30,000. Do not substitute green or orange coolant — it damages the cylinder head gasket on GDI engines.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace cabin air filter every 15,000 miles. Located behind the glove box on most Hyundai models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Drive Belt Inspection

Every 60,000 mi

Inspect serpentine belt and tensioner every 60,000 miles. Replace at 90,000 miles on most models.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

8 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

4

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2023 Hyundai Kona reflects Hyundai's published service intervals and the Service Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →