Wrench.Pro

2023 Kia Carnival Recalls, Issues & Maintenance

The 2023 Kia Carnival carries 4 open NHTSA recalls — most recently covering trailer hitches and door. Owners report 5 recurring issue clusters, led by “Power sliding door obstruction detection failure.” Kia uses Hyundai Motor Group's powertrains, so service intervals mirror Hyundai's. Kia Promise covers the first 3 years / 36,000 miles of complimentary maintenance. Kia owners with the Theta II 2.0L/2.4L (Optima, Sorento, Sportage 2011-2019) should adhere strictly to oil intervals due to known oil-consumption issues in Kia TSBs.

4 Open Recalls

Source: NHTSA

TRAILER HITCHES

Campaign #23V179000 · Mar 17, 2023

Issue: Kia America, Inc. (Kia) is recalling certain 2022-2023 Carnival vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk: A fire while parked or driving can increase the risk of injury.

Fix: Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will inspect and verify whether the vehicle is equipped with a Genuine Kia accessory trailer tow hitch assembly. If equipped, dealers will install a new fuse and wire extension kit. Repairs will be performed free of charge. Owner notification letters were mailed May 16, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC265.

STRUCTURE:BODY:DOOR

Campaign #23V236000 · Mar 31, 2023

Issue: Kia America, Inc. (Kia) is recalling all 2022 and certain 2023 Carnival vehicles. The auto-reverse feature for the power sliding doors (PSD) may not activate in all situations.

Risk: A power sliding door that does not auto-reverse can close on an occupant, increasing the risk of injury.

Fix: Dealers will update the power sliding door control module software, free of charge. Owner notification letters were mailed April 28, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC266.

STRUCTURE:BODY:ROOF AND PILLARS

Campaign #24V025000 · Jan 18, 2024

Issue: Kia America, Inc. (Kia) is recalling certain 2023-2024 Sportage and 2022-2024 Carnival vehicles. The roof molding may loosen and detach.

Risk: A detached roof molding can create a road hazard for other vehicles, increasing the risk of a crash.

Fix: Dealers will inspect the roof molding and replace or secure it as necessary, free of charge. Owner notification letters were mailed March 15, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC292.

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Campaign #26V232000 · Oct 4, 2026

Issue: Kia America, Inc. (Kia) is recalling certain 2022-2026 Carnival vehicles. Fuel may leak at the pipe connection between the fuel pipe and fuel rail.

Risk: A fuel leak increases the risk of a fire.

Fix: Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed June 2, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC368. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on April 24, 2026.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2023 Kia Carnival.

Reported to NHTSA

Power sliding door obstruction detection failure

STRUCTURE:BODY:DOOR

14 NHTSA complaints · 2022-07 → 2026-05

“The door closing automation applies excessive force before the safety function engages to re-open. This poses a high risk to children and small adults with narrow limbs and/or the fingers of any aged person. On January 11, 2023, my 4 year old's hand was closed in the door without the door stopping…”
— Owner report, NHTSA ODI #11501451
“The sliding power doors do not reverse when hitting a person or object. You have to use excessive force to get them to reverse and only some of the time do they even reverse. I have taken this to the dealership and they said they would contact me within 48 hours with an update but it's been a month…”
— Owner report, NHTSA ODI #11516486

Read all complaints on NHTSA →

Middle-row floor rail excessive heat

UNKNOWN OR OTHER

4 NHTSA complaints · 2023-06 → 2024-06

“The metal rails where the middle seat of the middle row is located occasionally gets too hot to touch. My daughter who was sleep had her sandals off. She woke up because her foot was hot. Shortly after her toe blistered.”
— Owner report, NHTSA ODI #11529374
“I have an issue that involves the metal railings in the center of the vehicle (on the floor) to get hot enough to burn and blister you. I filed a complaint with Kia which opened a case. I also took my vehicle in and this issue was verified by their mechanic.”
— Owner report, NHTSA ODI #11538635

Read all complaints on NHTSA →

Windshield spontaneous cracking

VISIBILITY/WIPER

3 NHTSA complaints · 2022-10 → 2024-10

“My 2023 KIA Carnival has a windshield cracked even without hitting rock or anything. My vehicle was parked on the driveway overnight. I can prove that the damage occurred without the car moving. I have this issue on my dash cam too.”
— Owner report, NHTSA ODI #11608607
“The windshield started cracking while the car was parked and continued cracking over the next week. The crack now runs from the center top, 3/4 of the way across the driver's side”
— Owner report, NHTSA ODI #11622340

Read all complaints on NHTSA →

Fuel filler door actuator failure

STRUCTURE:BODY

3 NHTSA complaints · 2024-06 → 2025-10

“Gas/pump door actuator failed. Unable to open and put gas in car. This car is only 1.5 years old.”
— Owner report, NHTSA ODI #11693824

Read all complaints on NHTSA →

Vehicle power loss and electrical system failure while driving

ELECTRICAL SYSTEM

3 NHTSA complaints · 2023-05 → 2023-08

“The contact stated that while driving 65-70 MPH, within 48 hours of purchasing the vehicle brand new, the vehicle lost motive power. Additionally, the brakes and power steering became inoperable. Several unknown warning lights illuminated, and alarms sounded.”
— Owner report, NHTSA ODI #11521238
“My vehicle has cut off in the middle of traffic several times. Another incident was when my vehicle was shaking uncontrollably and couldn't go over 40. The check engine light never comes on. One dealership looked at it and said nothing was wrong even though one of the techs heard the vehicle.”
— Owner report, NHTSA ODI #11526804

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 3,750 mi

Severe service: every 3,750 miles. Normal: 7,500 miles. Theta II 2.0L/2.4L on Optima, Sorento, Sportage (2011-2019): full synthetic only, never extend.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Telluride and Sorento AWD owners benefit from rotation every 5,000 miles to prevent uneven wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads and rotors every 7,500 miles. Forte and Soul front pads typically last 40,000-55,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 24 months. Required for ABS and ESC pump longevity.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles. Severe or dusty conditions: 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 30,000 mi

Severe service: every 30,000 miles. Normal: 60,000 miles. Use Kia SP-IV — same as Hyundai.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 105,000 mi

Iridium-tipped plugs rated 105,000 miles on most Kia engines. 1.6T (Forte GT, Soul Turbo): 60,000 miles. 3.5L Lambda II V6 (Telluride, Sorento): 105,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Long-Life Coolant

Every 30,000 mi

Kia Long-Life Coolant (pink, same as Hyundai): first change at 60,000 miles, then every 30,000. Do not mix with green or orange coolant.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Transfer Case / Rear Diff (AWD)

Every 60,000 mi

Sportage AWD, Sorento AWD, Telluride AWD: replace transfer case fluid and rear diff fluid every 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace cabin air filter every 15,000 miles. Located behind the glove box on Optima, Forte, and Sportage; behind the dashboard panel on Telluride.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

1 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

1

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2023 Kia Carnival reflects Kia's published service intervals and the Service Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →