Wrench.Pro

2024 Chevrolet Silverado 3500 Recalls, Issues & Maintenance

The 2024 Chevrolet Silverado 3500 carries 3 open NHTSA recalls — most recently covering steering and latch. Owners report 5 recurring issue clusters, led by “Transmission valve body failure and hard shifting.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

3 Open Recalls

Source: NHTSA

STEERING

Campaign #23V549000 · Mar 8, 2023

Issue: General Motors, LLC (GM) is recalling certain 2024 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles. The steering gear shaft may fracture and disconnect from the steering arm.

Risk: A steering arm that disconnects may result in a total loss of steering control, increasing the risk of a crash.

Fix: Dealers will inspect and replace the steering gear, if necessary, free of charge. Owner notification letters were mailed September 22, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232414720.

LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

Campaign #24V060000 · Jan 2, 2024

Issue: General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.

Risk: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

Fix: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232426400.

LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

Campaign #24V894000 · Nov 26, 2024

Issue: General Motors, LLC (GM) is recalling certain 2024 Chevrolet Silverado HD 2500, 3500, and GMC Sierra HD 2500, 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in Park.

Risk: An unlatched tailgate may open and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

Fix: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed December 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N242469160. This recall is an expansion of NHTSA Recall 24V-060.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2024 Chevrolet Silverado 3500.

Reported to NHTSA

Transmission valve body failure and hard shifting

POWER TRAIN

8 NHTSA complaints · 2024-12 → 2026-07

“10-speed automatic transmission valve body failure at 41k Parts are unavailable nor are replacement transmissions. Dealership says 3 months”
— Owner report, NHTSA ODI #11673108
“Vehicle and many like it with the 10 Speed transmission are having failing valve bodys which de-rates the vehicle to stay in 5th gear by GM coding and limits speed to 50 MPH”
— Owner report, NHTSA ODI #11628394
“The valve body failed on my transmission. My safety was impacted because as I was towing my 40 foot camper and my vehicle went into limp mode on the freeway at 70 miles an hour and I could only go 45 with four children in the vehicle”
— Owner report, NHTSA ODI #11640471

Read all complaints on NHTSA →

Oil cooler failure allowing oil into coolant

POWER TRAIN, ENGINE

2 NHTSA complaints · 2025-10 → 2026-03

“At approximately 35,126 miles the oil cooler cracked and flooded my engine cooling system with over 2.5 gallons of oil causing catastrophic engine failure”
— Owner report, NHTSA ODI #11695918
“The engine oil cooler failed causing engine oil to leak into the coolant system on my 2024 Chevy Silverado 3500HD. This requires a full replacement of the coolant system”
— Owner report, NHTSA ODI #11722446

Read all complaints on NHTSA →

Spongy brake pedal requiring full travel to stop

SERVICE BRAKES

2 NHTSA complaints · 2025-03 → 2026-04

“Leaking break fluid on my feet with sponge breaks dealer absolutely no help”
— Owner report, NHTSA ODI #11733461
“The brakes on this vehicle are very spongy, they have to be pushed all the way to the floor to get the vehicle to stop. When pulling a trailer you are on pins and needles wondering if you can get the truck to stop”
— Owner report, NHTSA ODI #11651568

Read all complaints on NHTSA →

Infotainment module failure disabling cameras and audio

ELECTRICAL SYSTEM

2 NHTSA complaints · 2025-03 → 2026-08

“The infotainment/control module in my 2024 Silverado 3500HD failed unexpectedly while I was traveling cross-country. The module is available for inspection upon request”
— Owner report, NHTSA ODI #11756996
“The contact owns a 2024 Chevrolet Silverado 3500. The contact stated that while operating the vehicle, no audible sound was coming from the infotainment center”
— Owner report, NHTSA ODI #11647463

Read all complaints on NHTSA →

Trailer brake controller disconnection warnings

ELECTRICAL SYSTEM, SERVICE BRAKES

17 NHTSA complaints · 2023-05 → 2026-03

“While driving along pulling a trailer, you unexpectedly lose you trailer brakes. Someone is going to get seriously injured or killed if GM doesn't fix this”
— Owner report, NHTSA ODI #11619801
“The contact owns a 2024 Chevrolet Silverado 3500. The contact stated that while driving 30 MPH and attempting to depress the brake pedal, the message “Trailer Brakes Disabled” was displayed”
— Owner report, NHTSA ODI #11681573
“While traveling with a 5th wheel camper, that has solar panels the brake controller stops providing a connection to the trailer brakes. This is a know problem of the 2024 Chevrolets and so far there is not a fix”
— Owner report, NHTSA ODI #11544666

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 17, 2026. Investigation data refreshed Sep 17, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

12 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

2

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2024 Chevrolet Silverado 3500 reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →