Wrench.Pro

2025 Chevrolet Traverse Recalls, Issues & Maintenance

The 2025 Chevrolet Traverse has no open NHTSA recalls. Owners report 4 recurring issue clusters, led by “Shark fin antenna cover detachment.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2025 Chevrolet Traverse.

1 active NHTSA investigation

Source: NHTSA

  • Electronic Brake Module Component Failure

    Action #EA26006 · opened Aug 21, 2026

    On April 11, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24011 after receiving complaints concerning a loss of brake assist in 2023 MY Cadillac Lyriq vehicles. These complaints allege a hard brake pedal, followed by a “Brake System Failure” mes…

    View on NHTSA →

Reported to NHTSA

Shark fin antenna cover detachment

STRUCTURE

9 NHTSA complaints · 2025-08 → 2026-04

“The shark fin antenna cover became loose. The antenna then fell off at some point while driving. This coming off while driving poses a risk to others on the road as it may have fallen off and hit someone else”
— Owner report, NHTSA ODI #11730298
“The component that failed was the "shark fin" antenna cover. This houses the radio signal and hands free driving signals. The shark fin can be a safety concern if the cover fall off at higher speeds”
— Owner report, NHTSA ODI #11710017
“The antenna fin became detached and flew off as I was driving posing a risk to other drivers on the road. I was on an open highway when this happened. There was no damage to the fin prior to this”
— Owner report, NHTSA ODI #11692644

Read all complaints on NHTSA →

Brake master cylinder failure and warning lights

SERVICE BRAKES

110 NHTSA complaints · 2025-04 → 2026-06

“I was driving down the road with my 4 year old son in the back and I went to stop at a stop sign and my car immediately lost brakes, the brakes went down to the floorboard with almost little to no stopping of my car”
— Owner report, NHTSA ODI #11697231
“2025 Traverse ABS brake system failed, and master cylinder broke at 12K. All of the safety features, Lane Departure, Forward Crash detection, blind spot, automatic braking system all stop working with no signs that it was failing!”
— Owner report, NHTSA ODI #11705982
“My vehicle experienced a brake system failure that rendered it unsafe to drive and required it to be towed to the dealership. I have been informed by the dealer that the issue involves a failure of the left rear brake caliper”
— Owner report, NHTSA ODI #11710987

Read all complaints on NHTSA →

OnStar telematics control module failure

UNKNOWN OR OTHER

8 NHTSA complaints · 2025-09 → 2026-06

“OnStar Telematic Control Module. Disables emergency crash capabilities. Problem confirmed By OnStar and dealer that unit is Bricked”
— Owner report, NHTSA ODI #11741865
“Onstar Telematics module failure. Zero connectivity with onstar in the event of theft or crash. Also causing loss of navigation, wifi, and supercruise”
— Owner report, NHTSA ODI #11689721
“Telematic control module failed. vehicle has 7k miles on it and brand new. Still under bumper to bumper warranty. Dealership diagnosed the emergency services /navigation system failure and ordered the part which is on significant backorder to due to nationwide shortage”
— Owner report, NHTSA ODI #11700514

Read all complaints on NHTSA →

Transmission fluid leak and power loss

POWER TRAIN

15 NHTSA complaints · 2025-01 → 2026-06

“1. Transmission leak. Car towed to dealer on 5/1/25 still there with no resolution. 2. Transmission fluid sprayed from under car which could get on the brake rotors and exhaust system”
— Owner report, NHTSA ODI #11665131
“Brand new Traverse with 3,600 miles on it started leaking transmission Fluid. Was told by dealership it was a slow leak and it was ok to drive while waiting for parts to come in”
— Owner report, NHTSA ODI #11643483
“Vehicle has 4k miles, sudden loss of power at highway speed, rolled to right lane and fortunately had an exit close by. Engine runs and revs fine, could not engage gear (neither D or R), stuck in P”
— Owner report, NHTSA ODI #11671070

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

4

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2025 Chevrolet Traverse reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →