Wrench.Pro

2025 Hyundai Ioniq 6 Recalls, Issues & Maintenance

The 2025 Hyundai Ioniq 6 carries 3 open NHTSA recalls — most recently covering 12v/24v/48v battery and port. Owners report 3 recurring issue clusters, led by “Wiper-induced windshield scratching.” Hyundai's owner's manual splits service into Normal and Severe schedules. Most US drivers qualify as Severe due to short trips, extreme temperatures, or stop-and-go traffic. Hyundai Assurance covers the first 3 years / 36,000 miles of complimentary maintenance on new vehicles. The Theta II 2.0L and 2.4L engines (2011-2019) are subject to TSBs around oil consumption — strict adherence to oil intervals matters.

3 Open Recalls

Source: NHTSA

ELECTRICAL SYSTEM:12V/24V/48V BATTERY

Campaign #24V868000 · Nov 18, 2024

Issue: Hyundai Motor America (Hyundai) is recalling certain 2022-2024 IONIQ 5, 2023-2025 IONIQ 6, Genesis GV60, Genesis GV70 "Electrified," and Genesis G80 "Electrified" vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.

Risk: A loss of drive power increases the risk of a crash.

Fix: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Hyundai customer service at 1-855-371-9460 or Genesis customer service at 1-844-340-9741. Hyundai's numbers for this recall are 272 (Hyundai) and 025G (Genesis). This recall expands and replaces previous recall number 24V-204. Vehicles previously repaired under recall 24V-204 will need to have the new remedy completed.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:CHARGING:PORT

Campaign #25V606000 · Dec 9, 2025

Issue: Hyundai Motor America (Hyundai) is recalling certain 2023-2025 IONIQ 6 electric vehicles. The charging port door panel may detach.

Risk: A detached charging port door panel can create a road hazard for other vehicles, increasing the risk of a crash.

Fix: Dealers will apply an adhesive on the charging port door assembly, free of charge. Owner notification letters were mailed beginning October 10, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 282. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 13, 2025.

SEAT BELTS:FRONT:ANCHORAGE

Campaign #26V218000 · Jun 4, 2026

Issue: Hyundai Motor America (Hyundai) is recalling certain 2023-2025 Hyundai Ioniq 6, 2023-2026 Genesis G90, 2024-2026 Hyundai Santa Fe, and Hyundai Santa Fe Hybrid vehicles. The driver and passenger seat belt anchors may detach.

Risk: A detached seat belt anchor will not adequately restrain the seat occupant, increasing the risk of injury in a crash.

Fix: Dealers will inspect and reinforce or replace the seat belt anchors, as necessary, free of charge. Owner notification letters were mailed beginning May 29, 2026. Owners may contact Hyundai customer service at 1-855-371-9460 and Genesis customer service at 844-340-9741. Hyundai's numbers for this recall are 298 and 032G. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov April 8, 2026.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2025 Hyundai Ioniq 6.

Reported to NHTSA

Wiper-induced windshield scratching

VISIBILITY/WIPER

2 NHTSA complaints · 2026-01 → 2026-02

“THIS CAR WAS PREPPED BY COCONUT CREEK HYUNDAI AND I AM BEING TOLD BY YOUR CUSTOMER SERVICE DEPARTNEMTN THAT THERE MIGHT HAVE BEEN SOME DEBRIS ON THE WIPERS THAT CAUSED THE SCRATCHES / HOW IS THAT MY FAULT HYUANDI HAS WALKED AWAY FROM ANY RESPONSIBILITY”
— Owner report, NHTSA ODI #11717724
“this vehicle was delivered to me on Sept 1, 2025 / i have been back to the dealership a few times regarding the front windshield is totally scratched up this had to happen from the windshield wipers the issue is that when i drive into the sun the glare from all the scratches”
— Owner report, NHTSA ODI #11714275

Read all complaints on NHTSA →

Tire tread separation and sidewall failure

TIRES

2 NHTSA complaints · 2025-02 → 2025-03

“The driver rear tire had blown out on me as I was merging onto a highway. I heard a heard a loud pop sound and the car shook and I had to swerve back into my lane”
— Owner report, NHTSA ODI #11640496
“My car was parked and I noticed that there was a bump in the sidewall of my vehicles driver front tire. This is the 2nd time this has happened in a month with factory installed tires that came with the vehicle when purchased brand new”
— Owner report, NHTSA ODI #11646609

Read all complaints on NHTSA →

ICCU failure with sudden loss of propulsion power

ELECTRICAL SYSTEM

22 NHTSA complaints · 2025-11 → 2026-06

“The ICCU died and the fuse on my traction battery blew. Both had to be replaced. I realized I had the problem when I started my car and it showed "Check Electric Vehicle System"”
— Owner report, NHTSA ODI #11714010
“My car is less than a year and a half old with only about 10k miles and last night I had the ICCU failure. I already had the software update to "fix" this safety recall 272 but it obviously didn't work”
— Owner report, NHTSA ODI #11713739
“The ICCU had a failure and fuse also blew; vehicle needs those parts replaced. After reading about ICCU recalls, my vehicle was not in the last recall”
— Owner report, NHTSA ODI #11700722

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 3,750 mi

Severe service: every 3,750 miles. Normal service: 7,500 miles. Theta II 2.0L/2.4L (Sonata, Santa Fe, Tucson 2011-2019): never extend — oil consumption issues are documented in Hyundai TSBs.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. AWD Tucson and Santa Fe owners benefit from rotation at 5,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, calipers, and parking brake every 7,500 miles. Elantra and Sonata front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 24 months. Required to maintain ABS and ESC pump life.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles. Severe service or dusty conditions: 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 30,000 mi

Severe service: every 30,000 miles. Normal: 60,000 miles. Use Hyundai SP-IV or SPH-IV — substitutes can cause harsh shifting and torque converter damage.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 105,000 mi

Iridium spark plugs are rated 105,000 miles on Theta II, Lambda II, and Smartstream engines. 1.6T (Veloster N, Kona N): 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Long-Life Coolant

Every 30,000 mi

Hyundai Long-Life Coolant (pink): first change at 60,000 miles, then every 30,000. Do not substitute green or orange coolant — it damages the cylinder head gasket on GDI engines.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 15,000 mi

Replace cabin air filter every 15,000 miles. Located behind the glove box on most Hyundai models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Drive Belt Inspection

Every 60,000 mi

Inspect serpentine belt and tensioner every 60,000 miles. Replace at 90,000 miles on most models.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2025 Hyundai Ioniq 6 reflects Hyundai's published service intervals and the Service Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →