Wrench.Pro

2025 Jeep Wrangler Recalls, Issues & Maintenance

The 2025 Jeep Wrangler carries 4 open NHTSA recalls — most recently covering pressure monitoring and regulating systems and traction battery. Owners report 7 recurring issue clusters, led by “OTA software update causing powertrain loss of power.” Jeep vehicles use the Oil Change Indicator system to signal when oil is due. Wrangler and Gladiator owners who actually use 4WD off-road should treat the schedule below as Schedule A (severe) — water crossings, sand, and rock crawling demand differential and transfer case service at half the published intervals. Grand Cherokee and Cherokee follow the standard Mopar schedule.

4 Open Recalls

Source: NHTSA

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

Campaign #25V527000 · Aug 14, 2025

Issue: Chrysler (FCA US, LLC) is recalling certain 2024-2025 Jeep Wrangler vehicles. The remote start antenna cable may be pinched, which can cause the tire pressure monitoring system (TPMS) warning light not to illuminate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."

Risk: A TPMS warning light that fails to notify the driver of a problem increases the risk of a crash.

Fix: Dealers will inspect and replace the remote start antenna cable as necessary, free of charge. Owner notification letters were mailed September 2, 2025. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 56C.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Campaign #25V741000 · Oct 30, 2025

Issue: Chrysler (FCA US, LLC) is recalling certain 2020-2025 Jeep Wrangler 4Xe and 2022-2026 Grand Cherokee 4Xe vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.

Risk: A vehicle fire can increase the risk of injury.

Fix: Owners are advised to park outside and away from structures and not to charge their vehicles until the remedy is completed. Dealers will update the high voltage battery software, and replace the high voltage battery, as necessary, free of charge. Some owner notification letters were mailed beginning December 17, 2025. The remaining owner notification letters will be mailed at a later date. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 68C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 6, 2025. Vehicles that were previously recalled for the same issue under NHTSA Recalls 24V720 and 23V787 will need to have the new remedy performed.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Campaign #26V327000 · May 21, 2026

Issue: Chrysler (FCA US, LLC) is recalling certain 2019 and 2023 Chrysler Pacifica, 2024 Ram 1500, Ram 2500, and 2024-2025 Jeep Wrangler vehicles. Contamination in the central vision processing module or improper programming may cause the rearview camera image not to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Risk: A rearview image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.

Fix: Dealers will update the central vision processing module software or replace the module, as necessary, free of charge. Owner notification letters are expected to be mailed beginning July 16, 2026. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 46D. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov on May 28, 2026.

STEERING:HYDRAULIC POWER ASSIST:PUMP

Campaign #26V363000 · Apr 6, 2026

Issue: Chrysler (FCA US, LLC) is recalling certain 2021-2025 Jeep Wrangler, Wrangler 4XE, and Jeep Gladiator vehicles. The electric hydraulic power steering pump wiring may overheat and cause a vehicle fire, even when the vehicle is parked with the ignition in the "Off" position.

Risk: A vehicle fire increases the risk of injury.

Fix: Owners are advised to park outside and away from structures, until their vehicle is repaired. Dealers will inspect and replace the wiring and electric hydraulic power steering pump, as necessary, free of charge. Owner notification letters are expected to be mailed July 9, 2026. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 21D. The Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on June 11, 2026.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2025 Jeep Wrangler.

Reported to NHTSA

OTA software update causing powertrain loss of power

ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, ENGINE

13 NHTSA complaints · 2025-10-11 → 2025-10-20

“On 10/10/25, my 2025 Jeep received an over-the-air (OTA) software update intended for the Uconnect infotainment system. Following the update, the vehicle experienced a complete powertrain failure. It became undrivable, shut off entirely, and refused to shift out of park. This…”
— Owner report, NHTSA ODI #11693487
“After jeep released an OTA update on Friday, I started my vehicle on Saturday and started to drive and in about 2-3 minutes all lights on dash started flashing and lost all power to vehicle and was luck enough to coast to the side of the road. The vehicle message said place car…”
— Owner report, NHTSA ODI #11693001

Read all complaints on NHTSA →

4xe high-voltage battery fire recall with no remedy available

ELECTRICAL SYSTEM

12 NHTSA complaints · 2025-11-07 → 2026-07-17

“My 2025 Jeep Wrangler 4xe is under Safety Recall 68C / 25V-741. The recall instructs owners to stop charging the vehicle and to park away from structures due to fire risk. There is no remedy available. As a result, I cannot safely use the vehicle as intended”
— Owner report, NHTSA ODI #11704545
“My 2025 Jeep Wrangler 4xe (VIN [XXX] ) is included in NHTSA Recall 25V-741 (FCA 68C) for a high-voltage battery defect that can cause a fire while parked. Jeep instructed owners not to recharge the vehicle and to park outside, away from structures, because the defect may lead to…”
— Owner report, NHTSA ODI #11698358

Read all complaints on NHTSA →

4xe intermittent loss of electric drive power while driving

POWER TRAIN, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM

9 NHTSA complaints · 2026-03-23 → 2026-08-09

“While driving my 2025 Jeep Wrangler 4xe in normal conditions, the vehicle unexpectedly loses electric drive power. Power is reduced in stages — to approximately 50%, then 25% — then electric mode is disabled and the dash displays "Electric Mode Temporarily Unavailable," after…”
— Owner report, NHTSA ODI #11747685
“Subsequent to the 68C recall software update, my vehicle is suffering from intermittent loss of acceleration. Even with a full charge of battery, when driving the 2025 jeep wrangler 4xe in EV mode, occasionally the car will shut of EV mode and transition to gas/hybrid mode.…”
— Owner report, NHTSA ODI #11737621

Read all complaints on NHTSA →

4xe 12-volt auxiliary battery repeated discharge and failure

POWER TRAIN, ELECTRICAL SYSTEM, ENGINE

4 NHTSA complaints · 2025-12-11 → 2026-07-09

“The 12-volt auxiliary battery and related electrical system in my 2025 Jeep Wrangler 4XE plug-in hybrid (leased new 8/25/2025) repeatedly fail. The battery completely discharges after the vehicle sits plugged into a standard home charger, undisturbed, for several consecutive…”
— Owner report, NHTSA ODI #11749280
“The contact owns a 2025 Jeep Wrangler 4XE. The contact received notifications of NHTSA Campaign Numbers: 25V710000 (Electrical System) and 25V741000 (Electrical System); however, the parts to do the recall repairs were not yet available. The contact stated that while driving…”
— Owner report, NHTSA ODI #11704488

Read all complaints on NHTSA →

Complete electrical and power loss while driving

ELECTRICAL SYSTEM

5 NHTSA complaints · 2025-09-08 → 2026-05-18

“This is an unmodified 2025 Jeep Wrangler with less than 3000 miles. While driving between 20 and 30 miles per hour, the vehicle went completely dead in traffic. No power, no lights, no dashboard, no blinkers, no brake lights. It stalled and was stuck in drive”
— Owner report, NHTSA ODI #11685715
“I was driving vehicle on interstate when sudden loss of power took place. I immediately pulled off the road and we smelled smoke. Fire was coming out of engine compartment near passenger wheel. We immediately exited the vehicle and assisted our young children out of the back seat”
— Owner report, NHTSA ODI #11738566

Read all complaints on NHTSA →

Windshield spontaneous cracking without impact

VISIBILITY:WINDSHIELD

2 NHTSA complaints · 2025-11-23 → 2026-07-17

“Windshield spontaneously cracked from lower edge in an arc back to lower edge. No impact. No debris. Gorilla glass with electronics”
— Owner report, NHTSA ODI #11751092
“Driving home from dealership and window cracked. Thees Jeeps have Coring Gorilla Glass. There is definitely a defect in the glass with only 42 miles on the jeep and the windshield cracks”
— Owner report, NHTSA ODI #11701068

Read all complaints on NHTSA →

Electronic throttle control failure and limp mode engagement

ELECTRICAL SYSTEM, POWER TRAIN, ENGINE

3 NHTSA complaints · 2025-11-16 → 2026-08-09

“While driving, the vehicle would suddenly go into "limp mode" and rapidly decrease speed. Several check engine lights would appear to include: Service Electronic Throttle Control, Service Electronic Stability Control, Traction Control and the standard CEL. When this does happen…”
— Owner report, NHTSA ODI #11755722

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 8,000 mi

Pentastar 3.6L: SAE 0W-20 every 8,000 miles. Wrangler 392 6.4L HEMI: SAE 5W-20 every 8,000 miles. EcoDiesel 3.0L: 10,000 miles. 4xe plug-in hybrid: 8,000 miles or annually.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 8,000 mi

Rotate tires every 8,000 miles. Wrangler with 33+ inch off-road tires: rotate every 5,000 miles to prevent uneven wear from solid axles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 8,000 mi

Inspect pads, rotors, and parking brake every 8,000 miles. Wrangler and Gladiator pads wear faster than Grand Cherokee due to higher curb weight per axle.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Front Differential Fluid

Every 60,000 mi

Replace front differential fluid every 60,000 miles. Wrangler off-road use (water crossings, sand): inspect every 30,000 miles for water contamination.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Rear Differential Fluid

Every 60,000 mi

Rear axle fluid every 60,000 miles. Limited-slip differentials require Mopar friction modifier. Wrangler Rubicon with locking differentials: same schedule.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Transfer Case Fluid (4WD)

Every 60,000 mi

Replace transfer case fluid every 60,000 miles. Use Mopar ATF+4 for NV3500 and NV245. Wrangler Rock-Trac: 60,000 mi normal, 30,000 mi with regular off-road use.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Brake Fluid

Every 24,000 mi

Replace DOT 3 brake fluid every 2 years regardless of mileage. Wrangler off-road use accelerates moisture intake — annual fluid testing recommended.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Automatic Transmission Fluid (ZF 8HP)

Every 60,000 mi

Severe service: ZF 8HP fluid every 60,000 miles. Normal: 120,000 miles. Use Mopar ATF+4 — never substitute.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Engine Air Filter

Every 30,000 mi

Replace engine air filter every 30,000 miles. Wrangler driven in dust or sand: inspect at every oil change and replace early.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs

Every 100,000 mi

Pentastar 3.6L: 16 spark plugs total, replace at 100,000 miles. Wrangler 392 6.4L HEMI: 16 plugs at 100,000 miles. EcoDiesel: glow plug inspection only.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Mopar HOAT Coolant

Every 50,000 mi

Mopar HOAT (purple) for gas engines: first change at 100,000 miles, then every 50,000. Do not mix with green or orange coolants.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace cabin air filter every 20,000 miles. Grand Cherokee, Cherokee, and Compass: behind the glove box. Wrangler/Gladiator: optional cabin filter on later models only.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2025 Jeep Wrangler reflects Jeep's published service intervals and the Oil Change Indicator system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →