The 2025 Kia Ev6 has no open NHTSA recalls. Owners report 3 recurring issue clusters, led by “Gear selector fails to engage intended gear.” Kia uses Hyundai Motor Group's powertrains, so service intervals mirror Hyundai's. Kia Promise covers the first 3 years / 36,000 miles of complimentary maintenance. Kia owners with the Theta II 2.0L/2.4L (Optima, Sorento, Sportage 2011-2019) should adhere strictly to oil intervals due to known oil-consumption issues in Kia TSBs.
No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.
What drivers and federal regulators have officially reported about the 2025 Kia Ev6.
POWER TRAIN
2 NHTSA complaints · 2025-10 → 2026-04
“When parking facing downhill, I put the car in reverse but the car rolls forward. Feels like the car is either in drive or neutral. Concern is intermittent, and I confirmed each time it happens, gear selector is in reverse”
“I START VEHICLE AND TRY TO PUT TRANSMISSION TO DRIVE ITS NOT WORKING AFTER I TRY TO PUT VEHICLE TO REVERSE TRANSMISSION ITS NOT WORKING”
ELECTRICAL SYSTEM
38 NHTSA complaints · 2025-08 → 2026-06
“Driving on three lane highway at 60 mph the car abruptly lost power. Was able to get off the highway. Called Kia roadside assistance. Tow truck picked up car and delivered it to Kia dealership. Service dept diagnosed and is replacing the ICCU”
“When shifting from reverse to drive there was a loud pop towards the back up the car. A check electrical system warning popped up, and then eventually a Check Power Supply stop now warning came up”
“While driving on a busy road at night, my vehicle displayed battery warning lights and went into "limp mode" which slowed me down to 25 mph before stopping completely. I was then stranded until a tow truck could be dispatched”
ELECTRICAL SYSTEM, SERVICE BRAKES, FORWARD COLLISION AVOIDANCE
3 NHTSA complaints · 2025-09 → 2026-05
“While driving car began to decelerate and the dash lit up with a number of ABS/Brake system failure symbols. I was on the highway traveling at abt 70 mph when the issue happened. Got car to coast off hwy onto an upward sloping exit”
“While maneuvering my Kia EV6 into my garage, the vehicle accelerated unexpectedly and struck the garage wall. I believe the acceleration may have been unintentional or due to a malfunction. I request review of any vehicle event data”
“I was driving over to walk my friends dog and I was pulling into the overflow parking area and my car just speed up and it would not stop”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 14, 2026. Investigation data refreshed Sep 14, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Severe service: every 3,750 miles. Normal: 7,500 miles. Theta II 2.0L/2.4L on Optima, Sorento, Sportage (2011-2019): full synthetic only, never extend.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 7,500 miles. Telluride and Sorento AWD owners benefit from rotation every 5,000 miles to prevent uneven wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads and rotors every 7,500 miles. Forte and Soul front pads typically last 40,000-55,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Replace DOT 3 brake fluid every 30,000 miles or 24 months. Required for ABS and ESC pump longevity.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Replace engine air filter every 30,000 miles. Severe or dusty conditions: 15,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Severe service: every 30,000 miles. Normal: 60,000 miles. Use Kia SP-IV — same as Hyundai.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Iridium-tipped plugs rated 105,000 miles on most Kia engines. 1.6T (Forte GT, Soul Turbo): 60,000 miles. 3.5L Lambda II V6 (Telluride, Sorento): 105,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Kia Long-Life Coolant (pink, same as Hyundai): first change at 60,000 miles, then every 30,000. Do not mix with green or orange coolant.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Sportage AWD, Sorento AWD, Telluride AWD: replace transfer case fluid and rear diff fluid every 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Extends the life of your vehicle and improves comfort
Replace cabin air filter every 15,000 miles. Located behind the glove box on Optima, Forte, and Sportage; behind the dashboard panel on Telluride.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
1
complaints mentioning a crash
0
complaints mentioning a fire
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2025 Kia Ev6 reflects Kia's published service intervals and the Service Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.