Manufacturer-recommended service intervals and open recall alerts for your 2025 Rivian R1t.
ZIP unlocks trusted shops near you. Mileage unlocks personalized service due dates. Either or both — your call.
Your ZIP stays with us. We share your city with shops, never your ZIP. Read our Promise →
SEAT BELTS:FRONT:ANCHORAGE
Campaign #25V370000 · Mar 6, 2025
Issue: Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and R1S vehicles. The D-ring bolts for one or both front seat belt anchorage assemblies may not have been properly installed.
Risk: An improperly secured seat belt may not restrain an occupant as intended, increasing the risk of injury during a crash.
Fix: Rivian will inspect and properly secure the seat belt anchorage assemblies as necessary, free of charge. Owner notification letters were mailed July 8, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1681.
EXTERIOR LIGHTING:TURN SIGNAL
Campaign #25V387000 · Nov 6, 2025
Issue: Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1S and R1t vehicles. One or both front turn signals may fail to illuminate and flash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Turn signals that do not function properly, failing to indicate the driver's intention to change direction, increase the risk of a crash.
Fix: Rivian will inspect and replace the front turn signals as necessary, free of charge. Owner notification letters were mailed September 22, 2025. Owners will receive a second notice once the remedy becomes available. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1693.
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY
Campaign #25V537000 · Aug 21, 2025
Issue: Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1S and R1T vehicles. An improperly grounded connection inside the High Voltage Distribution Box (HVDB) may cause a loss of drive power.
Risk: A loss of drive power increases the risk of a crash.
Fix: Rivian will inspect and repair the HVDB ground strap joint or replace the high voltage battery pack as necessary, free of charge. Owner notification letters were mailed October 17, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1723.
ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING:SOFTWARE
Campaign #25V585000 · Aug 9, 2025
Issue: Rivian Automotive, LLC (Rivian) is recalling certain 2025 R1S and R1T vehicles operating a software version prior to 2025.18.30. The Hands-Free Highway Assist (HWA) software may fail to correctly identify a lead vehicle.
Risk: Failure to detect another vehicle increases the risk of a crash.
Fix: Rivian has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed October 17, 2025. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1744.
SUSPENSION:CRITICAL FASTENERS
Campaign #26V003000 · May 1, 2026
Issue: Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1S and R1T vehicles that previously had service performed. The toe link may have been reassembled incorrectly during service procedures performed before March 10, 2025.
Risk: The toe link joint may separate, increasing the risk of a crash.
Fix: Rivian will replace the rear toe link bolts, free of charge. Owner notification letters were mailed February 17, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1794. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 24, 2026.
SEAT BELTS:CRITICAL FASTENERS
Campaign #26V009000 · Jan 15, 2026
Issue: Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.
Risk: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.
Fix: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.
Critical for safety and preventing major damage
Replace engine oil and oil filter. Modern synthetic oil lasts 7,500–10,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires to ensure even wear and extend tire life.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and fluid. Replace pads if worn below minimum thickness.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Replace timing belt (if applicable). Critical failure can cause major engine damage.
Estimated cost — typical U.S. ranges
Dealer
~$935–$1175
Shop
~$655–$825
DIY
Pro only
On interference engines, a snapped belt destroys valves. Worth doing on schedule. Bundle water pump + tensioner — labor is already there.
Keeps your vehicle running smoothly and efficiently
Replace the engine air filter to maintain fuel efficiency and engine performance.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Flush and replace engine coolant to prevent overheating and corrosion.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Replace transmission fluid to keep shifts smooth and prevent wear.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Replace spark plugs for optimal combustion, fuel economy, and performance.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Inspect and replace the serpentine belt to avoid unexpected breakdowns.
Estimated cost — typical U.S. ranges
Dealer
~$195–$235
Shop
~$135–$165
DIY
~$20–$50
DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.
Extends the life of your vehicle and improves comfort
Replace the cabin air filter for clean air inside the vehicle.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Test battery health and clean terminals. Average battery life is 3–5 years.
Estimated cost — typical U.S. ranges
Dealer
~$225–$390
Shop
~$160–$280
DIY
~$130–$250
Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.
Check and replace power steering fluid to maintain steering responsiveness.
Estimated cost — typical U.S. ranges
Dealer
~$185–$220
Shop
~$130–$155
DIY
~$15–$40
Most cars built after ~2012 use electric power steering and have no fluid to service.
What drivers and federal regulators have officially reported about the 2025 Rivian R1t.
Rear Toe Link May Separate
Action #PE26004 · opened May 26, 2026
The Office of Defects Investigation (ODI) has received two Vehicle Owner Questionnaires (VOQs) reporting left rear toe link separation in certain Model Year (MY) 2023-2024 Rivian R1S vehicles. Both VOQs report component separation while driving, causing the vehicles to swerve acr…
NHTSA has 10 complaints on file for the 2025 Rivian R1t (2025-02 → 2026-06). We haven't reviewed and grouped them yet for this specific vehicle — for now, the full list lives on NHTSA.
Top reported components: SUSPENSION (3) · ELECTRICAL SYSTEM (2) · UNKNOWN OR OTHER (2)
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Jul 31, 2026. Investigation data refreshed Jul 31, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2025 Rivian R1t reflects general industry intervals for modern vehicles. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.