The 2000 Oldsmobile Silhouette carries 8 open NHTSA recalls — most recently covering steering and headlights. Owners report 8 recurring issue clusters, led by “Intake manifold gasket coolant leak.” Oldsmobile closed in 2004, so every one of these is at least two decades old. That flips the maintenance question from mileage to age. Rubber, coolant, and brake fluid time out even on a car that barely gets driven. Models from about 1996 on use GM's Oil Life System and Dex-Cool coolant. Older ones run on fixed intervals and green coolant, and the two must never be mixed. Mechanically most of the lineup is shared GM hardware, so parts stay cheap and easy to find. The 3800 V6 in the Eighty-Eight and Ninety-Eight is one of the most durable engines GM ever built. The 3.1 and 3.4 V6 family has a well-documented lower intake manifold gasket weakness, and the Aurora's V8 needs a shop that knows Northstar-family cooling systems.
STEERING
Campaign #09E005000 · Feb 17, 2009
Issue: DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Risk: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.
EXTERIOR LIGHTING:HEADLIGHTS
Campaign #08E050000 · Nov 8, 2008
Issue: K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Campaign #04V597000 · Dec 22, 2004
Issue: ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Risk: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Fix: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Campaign #01V264000 · Aug 21, 2001
Issue: VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Risk: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Fix: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Campaign #07E021000 · Dec 3, 2007
Issue: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Campaign #99V268000 · Sep 29, 1999
Issue: VEHICLE DESCRIPTION: MINI VANS WITH EXTENDED WHEELBASE. SOME OF THESE VEHICLES HAVE INOPERATIVE FUEL TANK ROLLOVER VALVES AND FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN A ROLLOVER TEST. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."
Risk: IN A VEHICLE ROLLOVER ACCIDENT, IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Fix: DEALERS WILL INSPECT THE VEHICLES TO LOCATE AND REPLACE THOSE FUEL TANKS THAT COULD HAVE INOPERATIVE ROLLOVER VALVES.
SEAT BELTS
Campaign #00V228003 · Jul 8, 2000
Issue: VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Fix: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Campaign #01V067000 · Aug 3, 2001
Issue: VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Risk: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Fix: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
What drivers and federal regulators have officially reported about the 2000 Oldsmobile Silhouette.
ENGINE AND ENGINE COOLING
18 NHTSA complaints · 2003-03 → 2010-11
“INTAKE MANIFOLD GASKET FAILED APRIL 2004. GM REPLACED GASKET WITH NEW IMPROVED GASKET. GASKET FAILS AGAIN AFTER ONLY 22000 MILES”
“INTAKE MANIFOLD GASKET LEAKING AT 38,000 MILES. REPLACE BY GM UNDER WARRANTY. INTAKE MANIFOLD LEAKING AGAIN AT 70,000 MILES. NEEDS TO BE REPLACED AGAIN”
“INTAKE MANIFOLD MALFUNCTIONED. AS A RESULT, OIL AND COOLANT LEAKED INTO THE ENGINE COMPARTMENT”
STRUCTURE
17 NHTSA complaints · 2000-05 → 2011-12
“POWER SLIDING DOOR ON MY 2000 OLDSMOBILE SILHOUETTE MINIVAN CLOSES ON ITS OWN. IT TAKES A GREAT DEAL OF EFFORT TO STOP IT WHEN IT DOES THIS”
“AFTER CONSUMER HAD RECALL 01V067000 WORK FOR POWER SLIDING DOOR PERFORMED SLIDING DOOR FAILED TO OPEN COMPLETELY BY ONLY OPENING APPROXIMATELY 6 INCHES, AND THEN IMMEDIATELY MOVING BACK INTO CLOSED POSITION”
“PASSENGER'S SIDE SLIDING DOOR DOES NOT PROPERLY SHUT AND IS VERY LOOSE. WHEN DRIVING, THERE IS MOVEMENT IN THE DOOR”
TIRES
5 NHTSA complaints · 2000-08 → 2007-08
“TREAD SEPARATION. TIRE REPLACED BY DEALER = FERMAN OLDS ON 07/27/00”
“SINCE PURCHASING THIS VEHICLE ON MARCH 2, 2001, WE HAVE HAD THREE BLOWOUTS WITH THESE FIRESTONE ORIGINAL EQUIPMENT TIRES”
“WHILE DRIVING BETWEEN 30-35 MPH, THE STEEL BELT DETACHED FROM ONE OF THE TIRES”
EQUIPMENT
4 NHTSA complaints · 2002-08 → 2002-10
“AIR CONDITIONER HAS MOLD BUILDING UP INSIDE IT, AND IS CAUSING BAD FUMES TO COME OUT, CAUSING HEALTH PROBLEMS TO THE CONSUMER”
“CONSUMER HAD NOTICED A FOUL ODOR INSIDE VEHICLE. DURING RECENT SERVICE, THE DEALER CLEANED AIR CONDITIONER VENT SYSTEM AND FOUND MOLD”
“THERE ARE MOLD SPORES COMING FROM AIR CONDITIONING UNIT,MAKING PASSENGERS IN VEHICLE VERY SICK”
ELECTRICAL SYSTEM
12 NHTSA complaints · 2001-04 → 2006-10
“2000 OLDSMOBILE SILHOUETTE OCCASIONALLY DIES WHILE DRIVING. DOESN'T MATTER WHETHER IT IS AT 20 MPH OR 70 MPH”
“AT ANY SPEED THE VEHICLE WILL SHUT OFF AND WILL LOSE ALL POWER UNTIL THE VEHICLE IS TOWED TO A SHOP. CONTACTED DEALER SEVEN TIMES, BUT DEALER COULD NOT FIND A CAUSE OF THE PROBLEM”
“WHILE DRIVING AT 55 MPH AND WITHOUT WARNING ENGINE WOULD STALL, CAUSING THE CONSUMER TO PULL OVER”
SERVICE BRAKES, HYDRAULIC
5 NHTSA complaints · 2001-05 → 2004-06
“INTERMITTENT AND ONGOING BRAKE PROBLEM. WHEN APPLYING THE BRAKES BRAKE PEDAL WENT TO THE FLOOR, CAUSES PULSATION AND EXTENDED STOPPING DISTANCE”
“WHEN I APPLIED BRAKES, NOTHING HAPPENED. I APPLIED BRAKES WITH 2 FEET TO THE FLOOR AND NO RESPONSE”
“WHEN DRIVING ON WET PAVEMENT AND WHEN ATTEMPTING TO STOP, CONSUMER APPLIED BRAKE PEDAL AND BRAKES FAILED TO RESPOND, CAUSING EXTENDED STOPPING DISTANCE”
VEHICLE SPEED CONTROL
4 NHTSA complaints · 2000-08 → 2012-04
“THE CONTACT STATED THAT WHILE DRIVING 10 MPH THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING”
“THROTTLE STICKS? ENGINE WILL REV HIGHER THAN NORMAL (1500 - 3500 RPMS)”
“SUDDENLY, THE ENGINE SPEED WENT UP AND THE VEHICLE STARTED TO MOVE WHILE MY RIGHT FOOT WAS STILL ON THE BRAKE PEDAL”
AIR BAGS
4 NHTSA complaints · 2002-12 → 2003-12
“THE AIRBAG WARNING LIGHT STAYED LIT. I TOOK THE VEHICLE TO THE DEALER AND THEY SAID THAT THE AIRBAG WAS BAD AND NEEDED TO BE REPLACED, BUT THEY WOULD NOT COVER THE COST FOR REPLACEMENT”
“THE AIR BAG LIGHT ILLUMINATED ON THE DASHBOARD, THE DEALER REPLACED THE COMPUTER MODULE, HOWEVER THE PROBLEM RECURRED”
“DRIVER'S SEAT BELT BROKE. ALSO HAD AN ELECTRICAL SHORT WHICH TURNED AIR BAG LIGHT ON”
Note: NHTSA also opened 3 defect investigation(s) on this vehicle that closed without action.
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 1, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
On 1996 and later cars, change when the Oil Life System asks and at least once a year. Earlier cars used a fixed 3,000 mile interval. At this age a 5,000 mile ceiling is the safer read, because worn seals and a tired PCV system dirty the oil faster than the computer assumes.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate every 7,500 miles. Check the DOT date code on the sidewall while you are under there. On a low-mileage car of this age, tires usually age out years before the tread wears out.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect pads and rotors at every service, and ask specifically about the rubber hoses and steel lines. Line corrosion is a common failure on twenty-year-old cars that lived through road salt.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Replace every 2 years regardless of mileage. Brake fluid absorbs water from the air, and decades-old fluid is the quiet cause of soft pedals and stuck calipers on cars this old.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Drain and fill every 45,000 miles using Dexron VI. If the fluid has never been changed on a high-mileage car, ask for two or three drain-and-fills spaced out rather than a high-pressure flush.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Platinum or iridium plugs run to 100,000 miles. On the 3800 and 3.4 V6, replace the plug wires and coil boots at the same time. After this many years the insulation is brittle and a failing wire reads like a bad coil.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Replace the belt and the tensioner together once either shows cracking, glazing, or noise. A weak tensioner chews through a new belt in short order.
Estimated cost — typical U.S. ranges
Dealer
~$195–$235
Shop
~$135–$165
DIY
~$20–$50
DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.
Replace every 30,000 miles. On most of the lineup this is a five minute job with a screwdriver.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Extends the life of your vehicle and improves comfort
Treat this as a 5 year job, not a mileage job. Cars from about 1996 on use orange Dex-Cool, earlier ones use green. Never mix them. While the system is drained, have the shop look for seepage at the intake manifold and water pump, which is where these engines usually start weeping.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Test the battery and alternator once a year. Aging body control modules on this era of GM can pull a small current after shutdown, and a strong battery hides that problem until the day it does not.
Estimated cost — typical U.S. ranges
Dealer
~$225–$390
Shop
~$160–$280
DIY
~$130–$250
Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.
Occupant deaths in fatal crashes (FARS)
74 crashes 1990–2024
How the 74 occupant deaths break down
44
driver deaths
30
passenger deaths
74
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 2000 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
3
complaints mentioning a crash
2
complaints mentioning a fire
Reviewed known issues for this vehicle·Open recalls for this vehicle
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2000 Oldsmobile Silhouette reflects Oldsmobile's published service intervals and the GM Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.