The 2002 Oldsmobile Silhouette carries 5 open NHTSA recalls — most recently covering steering and headlights. Owners report 8 recurring issue clusters, led by “Power sliding door operation and entrapment.” Oldsmobile closed in 2004, so every one of these is at least two decades old. That flips the maintenance question from mileage to age. Rubber, coolant, and brake fluid time out even on a car that barely gets driven. Models from about 1996 on use GM's Oil Life System and Dex-Cool coolant. Older ones run on fixed intervals and green coolant, and the two must never be mixed. Mechanically most of the lineup is shared GM hardware, so parts stay cheap and easy to find. The 3800 V6 in the Eighty-Eight and Ninety-Eight is one of the most durable engines GM ever built. The 3.1 and 3.4 V6 family has a well-documented lower intake manifold gasket weakness, and the Aurora's V8 needs a shop that knows Northstar-family cooling systems.
STEERING
Campaign #09E005000 · Feb 17, 2009
Issue: DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Risk: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.
EXTERIOR LIGHTING:HEADLIGHTS
Campaign #08E050000 · Nov 8, 2008
Issue: K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Campaign #04V597000 · Dec 22, 2004
Issue: ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Risk: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Fix: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES
Campaign #07E021000 · Dec 3, 2007
Issue: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
AIR BAGS:FRONTAL
Campaign #02V222000 · Sep 8, 2002
Issue: CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Risk: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Fix: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
What drivers and federal regulators have officially reported about the 2002 Oldsmobile Silhouette.
LATCHES/LOCKS/LINKAGES
9 NHTSA complaints · 2002-10 → 2014-09
“MY DAUGHTER'S FINGERS WERE CRUSHED IN MY PARENTS AUTOMATIC SLIDING DOOR ON THEIR 2002 OLDSMOBILE SILOUTTE MINIVAN”
“THE CONTACT STATED THAT THE SLIDING DOORS ON BOTH THE DRIVER AND PASSENGER SIDE FAILED TO UNLOCK”
“SOMETIMES THE SLIDING DOOR WILL NOT OPEN AND NOW HAS OPENED WHILE DRIVING DOWN THE ROAD”
SUSPENSION
8 NHTSA complaints · 2004-07 → 2005-11
“AWD DISABLE AND ABS LIGHTS ILLUMINATED. LEFT FRONT WHEEL BEARING AND HUB ASSEMBLY FAILED AND WAS REPLACED”
“WHILE THE VEHICLE WAS GETTING THE TIRES ROTATED MECHANIC INFORMED THE CONSUMER THAT BOTH REAR WHEEL BEARINGS NEEDED TO BE REPLACED”
TIRES
4 NHTSA complaints · 2003-08 → 2005-01
“THERE WAS UNEVEN TIRE WEAR. THE TREAD SURFACE LIFTED OFF OF THE CAP”
“WHILE DRIVING ON HIGHWAY, THE LEFT FRONT TIRE EXPERIENCED A BLOWOUT AT THE SIDEWALL WHICH RESULTED IN THE TREAD SEPARATION”
“TREAD IS GOOD BUT SEPARATING FROM THE SIDEWALL, STEEL BELTS VISIBLE”
EXTERIOR LIGHTING
3 NHTSA complaints · 2004-12 → 2005-08
“THE FRONT LIGHT AND TURN SIGNAL ASSEMBLY OF THIS VAN AND SISTER VEHICLES PONTIAC MONTANAS AND CHEVROLET VENTURES FILL WITH MOISTURE AND KEEP THE FULL LIGHT FROM SHINING ON THE ROADWAY AND BEING FULLY VISIBLE TO OTHER VEHICLES”
“STOP LAMP BULBS ARE SHORTING OUT AT CONNECTOR TO SOCKETS”
“REAR TAIL LIGHTS MALFUNCTION INTERMITTENTLY. USUALLY AFTER HEAVY RAIN”
POWER TRAIN
3 NHTSA complaints · 2002-01 → 2002-02
“AUTOMATIC TRANSMISSION; VEHICLE DRIFTS BACKWARDS DOWN A HILL IN WHEN IN DRIVE”
“TRANSMISSION DOES NOT HOLD THE VAN WHILE IN DRIVE, EVEN ON A SLIGHT INCLINE”
SERVICE BRAKES, HYDRAULIC, FUEL SYSTEM, GASOLINE
3 NHTSA complaints · 2007-04 → 2014-10
“GAS GAUGE NOT WORKING, REGISTERS FULL EVEN WHEN NOT FULL”
“THE GAUGE SHOWS FULL UNTIL IT IS EMPTY THEN DROPS TO EMPTY AND ALARM SOUNDS”
ENGINE AND ENGINE COOLING
3 NHTSA complaints · 2006-11 → 2007-11
“INTAKE MANIFOLD GASKET LEAKING COOLANT EXTERNALY.AND ENGINE OIL LEAKING INTO COOLANT INTERNALY”
“I HAVE A 2002 OLDS SILHOUETTE MINIVAN WHICH HAD TO HAVE THE INTAKE MANIFOLD GASKET REPLACED”
SEATS
3 NHTSA complaints · 2005-08 → 2010-11
“DRIVERS SIDE SEAT HEATER FAILED”
“HEATERS BURNED OUT 3 TIMES IN THE LAST 3 WINTERS”
“I HAD THE HEAT ELEMENT FAIL ON MY 2002 OLDS SILHOUETTE”
Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 1, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
On 1996 and later cars, change when the Oil Life System asks and at least once a year. Earlier cars used a fixed 3,000 mile interval. At this age a 5,000 mile ceiling is the safer read, because worn seals and a tired PCV system dirty the oil faster than the computer assumes.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate every 7,500 miles. Check the DOT date code on the sidewall while you are under there. On a low-mileage car of this age, tires usually age out years before the tread wears out.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect pads and rotors at every service, and ask specifically about the rubber hoses and steel lines. Line corrosion is a common failure on twenty-year-old cars that lived through road salt.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Replace every 2 years regardless of mileage. Brake fluid absorbs water from the air, and decades-old fluid is the quiet cause of soft pedals and stuck calipers on cars this old.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Drain and fill every 45,000 miles using Dexron VI. If the fluid has never been changed on a high-mileage car, ask for two or three drain-and-fills spaced out rather than a high-pressure flush.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Platinum or iridium plugs run to 100,000 miles. On the 3800 and 3.4 V6, replace the plug wires and coil boots at the same time. After this many years the insulation is brittle and a failing wire reads like a bad coil.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Replace the belt and the tensioner together once either shows cracking, glazing, or noise. A weak tensioner chews through a new belt in short order.
Estimated cost — typical U.S. ranges
Dealer
~$195–$235
Shop
~$135–$165
DIY
~$20–$50
DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.
Replace every 30,000 miles. On most of the lineup this is a five minute job with a screwdriver.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Extends the life of your vehicle and improves comfort
Treat this as a 5 year job, not a mileage job. Cars from about 1996 on use orange Dex-Cool, earlier ones use green. Never mix them. While the system is drained, have the shop look for seepage at the intake manifold and water pump, which is where these engines usually start weeping.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Test the battery and alternator once a year. Aging body control modules on this era of GM can pull a small current after shutdown, and a strong battery hides that problem until the day it does not.
Estimated cost — typical U.S. ranges
Dealer
~$225–$390
Shop
~$160–$280
DIY
~$130–$250
Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.
Occupant deaths in fatal crashes (FARS)
45 crashes 1990–2024
How the 45 occupant deaths break down
32
driver deaths
13
passenger deaths
45
occupant deaths
Crash years covered: 1990–2024 This model year first appears in 2001 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.
Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.
Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.
IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
1
complaints mentioning a crash
0
complaints mentioning a fire
Reviewed known issues for this vehicle·Open recalls for this vehicle
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2002 Oldsmobile Silhouette reflects Oldsmobile's published service intervals and the GM Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.