Wrench.Pro

2008 Ford Explorer Sport Trac Recalls, Problems & Maintenance

The 2008 Ford Explorer Sport Trac has no open NHTSA recalls. Owners report 5 recurring issue clusters, led by “Unexpected vehicle movement while in park.” Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2008 Ford Explorer Sport Trac.

Reported to NHTSA

Unexpected vehicle movement while in park

POWER TRAIN, ELECTRICAL SYSTEM, SERVICE BRAKES

2 NHTSA complaints · 2011-03 → 2013-05

“PARKED VEHICLE. TURNED OFF IGNITION. KEY WOULD NOT RELEASE FROM THE IGNITION. CYCLED THE AUTO SHIFT LEVER TO MAKE SURE IN PARK. AT THIS POINT NOTED THAT I COULD SHIFT OUT OF PARK WITHOUT MY FOOT BEING ON THE BRAKE. VERY DANGEROUS”
— Owner report, NHTSA ODI #10512492
“BRAKE OR TRANSMISSION IS MALFUNCTIONING, TRUCK WAS PARKED ON A FLAT SURFACE IN THE DRIVEWAY AND NOT RUNNING, IN PARK, LOCKED AND AFTER A BOUT AN HOUR THE TRUCK BEGAN ROLLING, AN WAS STOPPED MY A PIECE OF WROUGHT IRON FENCE, DAMAGING THE FRONT BUMPER”
— Owner report, NHTSA ODI #10392184

Read all complaints on NHTSA →

Radiator leaks and coolant loss

ENGINE

3 NHTSA complaints · 2011-10 → 2017-08

“BROKE DOWN ON A VERY HIGH TRAFFIC BRIDGE, THAT HAD NO SAFETY LANE TO PULL OVER. VERY DANGEROUS, WITH NO TIME TO PULL OVER WHEN ENGINE LIGHT CAME ON. REPEAT, THIS HAPPENS TO ALL FORD SPORT TRACS WITH PLASTIC RADIATOR HOUSING. THERE ARE SOME CLASS ACTION LAWSUITS ACROSS THE USA”
— Owner report, NHTSA ODI #11012735
“TL* THE CONTACT OWNS A 2008 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE RADIATOR BEGAN TO LEAK ABNORMALLY. THE CONTACT ATTEMPTED TO LOCATE THE PARTS NEEDED TO MAKE REPAIRS TO THE VEHICLE FROM AN INDEPENDENT PARTS DEALER, BUT WAS UNABLE TO LOCATE THE PART”
— Owner report, NHTSA ODI #10486449
“RADIATOR STARTED LEAKING AT BOTTOM GASKET /O RING SEAL OF TANK. ALSO INTERIOR LIGHT GOES OFF AND ON WHEN HIT BUMPS. FOUND IT IS TIED INTO THE IGNITION SWITCH. IF LIGHT COMES ON AFTER HITTING BUMP ALL I HAVE TO DO IS GIGGLE THE IGNITION SWITCH TO GET IT TO GO BACK OFF. *TR”
— Owner report, NHTSA ODI #10428943

Read all complaints on NHTSA →

Unintended acceleration with brake applied

VEHICLE SPEED CONTROL, ENGINE

2 NHTSA complaints · 2016-08 → 2023-05

“The contact owns a 2008 Ford Explorer Sport Trac. The contact stated that on three occasions while the vehicle was in drive but stationary, the brake pedal was depressed, and the vehicle accelerated unintendedly. The vehicle was not diagnosed or repaired”
— Owner report, NHTSA ODI #11521402
“TL* THE CONTACT OWNS A 2008 FORD EXPLORER SPORT TRAC. WHILE AT A STOP LIGHT WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE ACCELERATED INDEPENDENTLY. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY AND MOTOR ASSEMBLY NEEDED TO BE REPLACED”
— Owner report, NHTSA ODI #10893946

Read all complaints on NHTSA →

Automatic transmission shifting and engagement failure

POWER TRAIN

5 NHTSA complaints · 2008-11 → 2014-05

“2008 FORD EXPLORER SPORT TRAC, 5 SPEED AUTOMATIC, V6. TRANSMISSION FAILS TO ENGAGE; TRUCK HAS DIFFICULTY ACCELERATING FROM A STOP AND WILL ROLL BACKWARDS FROM A STOP IF ON AN INCLINE. TRANSMISSION ALSO 'SLAMS' GEARS AND FEELS LIKE THE VEHICLE HAS BEEN HIT FROM BEHIND”
— Owner report, NHTSA ODI #10347441
“TL* THE CONTACT OWNS A 2008 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE VEHICLE WOULD LUNGE FORWARD WHEN ATTEMPTING TO SHIFT GEARS. THE VEHICLE WOULD ALSO STALL, SHIFT OUT OF NEUTRAL, SHIFT OUT OF OVER DRIVE OR WOULD SHIFT INTO VARIOUS GEARS ERRATICALLY”
— Owner report, NHTSA ODI #10451602
“TL* THE CONTACT OWNS A 2008 FORD EXPLORER. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT AND WRENCH ICON ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST, WHO STATED THAT THE TORQUE CONVERTER WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED”
— Owner report, NHTSA ODI #10586866

Read all complaints on NHTSA →

Engine stalling and loss of power while driving

ENGINE

4 NHTSA complaints · 2014-04 → 2017-03

“AFTER TURNING ONTO THE MAIN ROAD OUT OF OUR SUBDIVISION THE VEHICLE SHUT DOWN AND WOULD NOT START. THE CAR BEHIND US NEARLY RAN INTO THE BACK OF THE VEHICLE. IT APPEARS THERE IS A DESIGN FLAW IN THE TENSIONERS USED FOR THE TIMING CHAINS ON THE MOTOR IN THIS VEHICLE”
— Owner report, NHTSA ODI #10682121
“DRIVING THE CAR IT BEGAN TO LOSE POWER, THEN GET POWER, THEN IT SHUT OFF. RESTARTED THE CAR, STARTED DRIVING AND IT SURGED UNEXPECTEDLY THEN BEGAN TO LOSE POWER AGAIN, THEN IT SHUT OFF. THIS SCARED MY WIFE BECAUSE SHE DIDN'T KNOW IF IT WAS GOING TO SURGE OR LOSE POWER”
— Owner report, NHTSA ODI #10730273
“TRUCK CUT OFF 4 TIMES IN MIDDLE TRAFFIC WOULD NOT STAY ON. NO WARNING LIGHT CHANGE TRIED TO PULL OFF TRUCK JUST KEPT CUTTING OFF. *TR”
— Owner report, NHTSA ODI #10578114

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 7,500 mi

Replace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 10,000 mi

Rotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

Ford specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 150,000 mi

Ford 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD models)

Every 60,000 mi

On 4x4 models, replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Rear Differential Fluid

Every 100,000 mi

F-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Coolant

Every 50,000 mi

Motorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

14 crashes 1990–2024

How the 14 occupant deaths break down

12

driver deaths

2

passenger deaths

14

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2008 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

1

complaints mentioning a crash

1

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2008 Ford Explorer Sport Trac reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →