Wrench.Pro

2011 Bmw 135i Recalls, Issues & Maintenance

The 2011 Bmw 135i carries 6 open NHTSA recalls — most recently covering wiring and inflator module. Owners report 5 recurring issue clusters, led by “Takata airbag recall parts delay.” BMW vehicles use Condition-Based Service (CBS) — the dashboard shows each service item with its own remaining mileage and time, calculated by sensors. The schedule below shows BMW's underlying targets. BMW Ultimate Care covers the first 3 years / 36,000 miles of factory-scheduled maintenance on most new vehicles.

6 Open Recalls

Source: NHTSA

ELECTRICAL SYSTEM:WIRING

Campaign #19V579000 · Jun 8, 2019

Issue: BMW of North America, LLC (BMW) is recalling certain 2008-2012 BMW 128i, 135i, 135is Coupes and 128i, 135i Convertible vehicles. The wiring and electrical connectors in the blower-regulator wiring harness may overheat.

Risk: Wiring that overheats could cause the electrical connectors to melt, and increase the risk of a fire, even when the vehicle is unattended.

Fix: BMW will notify owners, and dealers will inspect the blower-regulator wiring harness, and replace it with a new part, free of charge. The recall began October 4, 2019. Owners may contact BMW customer service at 1-800-525-7417. Note: This recall is an expansion of an earlier recall number 17V-676.

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Campaign #20V017000 · Jan 15, 2020

Issue: BMW of North America, LLC (BMW) is recalling certain 2008-2013 128i and 135i Convertibles, 128i, 135i, and M Coupes, 2007-2010 X3 30si and X3 xDrive30i, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i, 2007-2013 328i, 328i xDrive, 335i, 335is, 335i xDrive and M3 Coupes, 2006-2011 328i, 328xi, 328i xDrive, 325i, 325xi, 330i, 330xi, 335i, 335xi, 335i xDrive and M3, 2009-2011 335D, 2006-2012 325xi, 328i, 328xi and 328i xDrive, 2010-2011 X6 ActiveHybrid, 2007-2013 328i, 335i, 335is, M3 Coupes, X5 30si, X5 xDrive30i, X5 xDrive35i, X5 48i, X5 xDrive48i, X5 xDrive50i and X5 M, 2009-2013 X5 xDrive35d and 2008-2014 X6 xDrive35i, X6 xDrive50i and X6M vehicles equipped with non-desiccated driver frontal air bag inflators containing phase stabilized ammonium nitrate (PSAN) that were used as interim remedy parts for previous Takata recalls. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Fix: BMW will notify owners, and dealers will replace the driver air bag. On X5 and X6 vehicles, only the inflator will be replaced. All repairs will be performed free of charge. The recall began March 11, 2020. Owners may contact BMW customer service at 1-800-525-7417.

POWER TRAIN:DRIVELINE:CONSTANT VELOCITY JOINT

Campaign #17V067000 · Feb 2, 2017

Issue: BMW of North America, LLC (BMW) is recalling certain 2011-2012 135i Coupe, 1 Series M Coupe and 135i Convertible vehicles, 2011 Z4 sDrive 35i, 335i, 335d, 335i Coupe, 335is Coupe, 335i Convertible, 335is Convertible, 535i, 535i xDrive, 535i Gran Turismo and 550i xDrive Gran Turismo vehicles and 2012 740i and 740Li vehicles. The rear driveshaft constant velocity (CV) joint on the affected vehicles may fatigue and break.

Risk: If the CV joint breaks, the vehicle may have a loss of propulsion, increasing the risk of a crash.

Fix: BMW will notify owners, and dealers will inspect the rear driveshaft CV joint and, based on its production date, will replace it, free of charge. The recall began April 21, 2017. Owners may contact BMW customer service at 1-800-525-7417.

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Campaign #16V071000 · May 2, 2016

Issue: BMW of North America, LLC (BMW) is recalling certain model year 2008-2013 128i and 135i coupes and convertibles and 1 Series M coupes, 2006-2011 325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi, 335i, 335xi, 335i xDrive Sedans, 2009-2011 335d sedans, 2006-2012 325xiT, 328i and 328xi sports wagons, 2007-2013 328i, 328xi, 328i xDrive, 335i, 335xi, 335i xDrive, 335is and M3 Coupes and Convertibles, 2013-2015 X1 sDrive28i, X1 xDrive28i and X1 xDrive35i SAVs, 2007-2010 X3 xDrive30i SAVs, 2007-2013 X5 xDrive30i, X5 xDrive35i, X5 xDrive48i, X5 xDrive50i and X5 M SAVs, 2009-2013 BMW X5 xDrive35d SAVs, 2008-2014 X6 xDrive35i, X6 xDrive50i, and X6 M SACs, 2010-2011 BMW X6 xDrive50i SACs and 2008-2011 M3 Sedan vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Fix: BMW will notify owners, and dealers will replace the driver's frontal air bag module or inflator depending on the vehicle model, free of charge. The recall began March 9, 2018. Owners may contact BMW customer service at 1-800-525-7417.

ENGINE AND ENGINE COOLING:ENGINE

Campaign #14V176000 · Oct 4, 2014

Issue: BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.

Risk: If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.

Fix: BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1-800-525-7417.

ELECTRICAL SYSTEM

Campaign #13V044000 · Jul 2, 2013

Issue: BMW is recalling certain model year 2008-2012 1-Series coupes and convertibles manufactured December 2007 through September 2011; and 2007-2011 3-Series coupes and convertibles manufactured March 2007 through October 2011; 2007-2011 3-Series sedans manufactured March 2007 through October 2011; 2007-2011 3-Series sports wagons manufactured March 2007 through June 2011; and 2009-2011 Z4 vehicles manufactured March 2009 through June 2011. In February 2013, BMW recalled 504,545 vehicles. In July 2013, BMW informed the agency that it was adding 1-Series, 3-Series, and Z4 vehicles, representing an additional 12,094 vehicles. The total number of vehicles being recalled is now 516,791. The connector for the positive battery cable connector and the corresponding terminal on the fuse box may degrade over time. Over time, the high current flow and heat from electrical resistance may lead to a breakage of the connection, and a loss of electrical power to the vehicle.

Risk: If there is a loss of electrical power to the vehicle, the vehicle may unexpectedly stall, increasing the risk of a crash.

Fix: BMW will notify owners, and dealers will replace the positive battery cable connector and secure it with an improved method, free of charge. The recall began on March 13, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at CustomerRelations@bmwusa.com.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2011 Bmw 135i.

1 active NHTSA investigation

Source: NHTSA

  • Desiccated Air Bag Inflator Rupture

    Action #EA21002 · opened Sep 17, 2021

    From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 200…

    View on NHTSA →

Reported to NHTSA

Takata airbag recall parts delay

AIR BAGS

16 NHTSA complaints · 2016-03 → 2017-11

“I'VE BEEN WAITING FOR NEARLY TEN MONTHS TO BE NOTIFIED ABOUT WHEN REPLACEMENT PARTS WOULD BE AVAILABLE FOR MY CAR'S RECALLED DRIVER-SIDE AIRBAG MODULE (RECALL CAMPAIGN NO. 16V-071)”
— Owner report, NHTSA ODI #10937668
“RECALL CAMPAIGN NO. 16V-071: DRIVER'S FRONT AIR BAG MODULE, THIS IS A DANGEROUS SITUATION, NOT RESOLVED BY BMW”
— Owner report, NHTSA ODI #10911379
“TAKATA RECALL NOTICE FROM BMW IS DATED AND WAS RECEIVED IN MARCH 2016. CALLED BMW CUSTOMER RELATIONS NUMBER 800-525-7417 SEVERAL TIMES SINCE MARCH WITH THE SAME REPLY THAT BMW HAS NO PARTS AND DOESN'T KNOW ANY MORE”
— Owner report, NHTSA ODI #10908304
“TL* THE CONTACT OWNS A 2011 BMW 135I. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V071000 (AIR BAGS) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR”
— Owner report, NHTSA ODI #10892455

Read all complaints on NHTSA →

Blower motor wiring smoke and fire

ELECTRICAL SYSTEM

7 NHTSA complaints · 2018-06 → 2026-03

“THE VEHICLE WAS IN MOTION AND THE BLOWER MOTOR RESISTOR HARNESS BEGAN TO SMOKE HEAVILY. THE A/C STOPPED WORKING. I PULLED OVER AND DISCONNECTED THE WIRING HARNESS AND PULLED THE FUSE. THE WIRES MELTED, THE CONNECTOR MELTED, AND THE RESISTOR IS BROKEN”
— Owner report, NHTSA ODI #11153013
“BLOWER MOWER WIRING OVERHEATING AND BURNING/CORRODING WHILE FAN WAS ON LOW SPEED”
— Owner report, NHTSA ODI #11112733
“FAN BLOWER WIRE CAN CATCH FIRE, BMW 3 SERIES E90 2006 TO 2013 ALREADY GOT THE RECALL DONE, PLEASE RECALL THIS”
— Owner report, NHTSA ODI #11112792
“The contact owns a 2011 BMW 135I. The contact stated that the A/C system and the blower motor were intermittently inoperable. The vehicle was taken to an independent mechanic, where the blower motor was replaced; however, the failure persisted”
— Owner report, NHTSA ODI #11727086

Read all complaints on NHTSA →

High-pressure fuel pump failure

FUEL/PROPULSION SYSTEM

7 NHTSA complaints · 2010-10 → 2019-10

“HIGH PRESSURE FUEL PUMP FAILURE - CAR WENT INTO LIMP MODE WHILE DRIVING ON A CITY STREET”
— Owner report, NHTSA ODI #11268125
“THE HIGH PRESSURE FUEL PUMP HAS FAILED AND BEEN REPLACED MULTIPLE TIMES. IT BEGINS WITH THE CAR TAKING MUCH LONGER TO CRANK AND START. THEN IT COMPLETELY FAILS POTENTIALLY WHILE DRIVING, CREATING A SAFETY ISSUE, OR WILL NO LONGER START”
— Owner report, NHTSA ODI #11112223
“TWO TIMES WITHIN A YEAR THE VEHICLE HAS EXPERIENCED A REDUCTION OF POWER AND THE CHECK ENGINE LIGHT CAME ON”
— Owner report, NHTSA ODI #11165487
“BMW 2011 52I , FUEL PUMP WIRE PLUG IS GET HOT BURN HOLD AT TOP OF PUMP HOUSING , WHEN TANK IS FULL IT LEAK OUT UNDER REAR SEAT”
— Owner report, NHTSA ODI #10854451

Read all complaints on NHTSA →

DCT hesitation and lurch at low speed

POWER TRAIN

10 NHTSA complaints · 2012-11 → 2022-04

“I had two situations in which my car would unexpectedly lurch forward after coming to a complete stop with my foot on the brake pedal, and another case in which I could not place the vehicle in park with the DCT Shift lever malfunctioning and making the car undrivable”
— Owner report, NHTSA ODI #11460025
“UNINTENDED ACCELERATION BECAUSE OF DUAL-CLUTCH TRANSMISSION (DCT); CAR WAS IN DRIVE SLOWING TO STOP SIGN. ALMOST AT STOP CAR LURCHED 2 TO 3 FEET INTO THE INTERSECTION BEFORE I COULD SLAM ON BRAKES”
— Owner report, NHTSA ODI #10607508
“CROSSING THE STREET---I HAD THE GAS PEDDLE ALL THE WAY TO THE FLOOR (TWICE YESTERDAY) AND THE CAR LITERALLY DID NOT MOVE AND TRAFFIC WAS APPROACHING”
— Owner report, NHTSA ODI #10497673
“THE VEHICLE HESITATED WHEN THE LIGHT TURNED GREEN AND I WAS HIT IN THE REAR”
— Owner report, NHTSA ODI #10505289

Read all complaints on NHTSA →

Engine stall and power loss while driving

ENGINE

9 NHTSA complaints · 2013-08 → 2024-09

“ROD BEARINGS FAILURE WHICH COULD CAUSE ENGINE SEIZING WHILE DRIVING”
— Owner report, NHTSA ODI #11321309
“Sudden catastrophic engine shutdown After 3weeks of investigation came back as bad crank posisition sensor”
— Owner report, NHTSA ODI #11453558
“TL* THE CONTACT OWNS A 2011 BMW 135I. WHILE DRIVING 60 MPH, THE VEHICLE OVERHEATED AND LOST POWER”
— Owner report, NHTSA ODI #10783391
“BMW Series 135I2011 - Engine/Vanos bolts failed/failing! When it's started, you can total tell there is an issue with it...Car is basically NON-Drivable due to this condition due to safety concerns”
— Owner report, NHTSA ODI #11616579

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil Service (CBS)

Every 10,000 mi

Replace BMW Longlife-04 (LL-04) full-synthetic oil and filter every 10,000 miles or annually — whichever the CBS system signals first. M-series engines may require shorter intervals; check the vehicle-specific iDrive screen.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Brake Fluid Service (CBS)

Every 24,000 mi

Replace DOT 4 LV brake fluid every 2 years regardless of mileage. CBS triggers based on time, not miles, due to moisture absorption.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Vehicle Check / Inspection (CBS)

Every 30,000 mi

Multi-point inspection covering brakes, suspension, steering, exhaust, fluids, lighting, and underbody. CBS signals every 30,000 miles or 2 years.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free with any paid service. A flashlight and 10 minutes covers the basics yourself.

Engine Air Filter

Every 40,000 mi

Replace engine air filter every 40,000 miles. Higher-performance N55, B58, and S58 engines should be inspected at every oil service.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs

Every 60,000 mi

B48 (2.0L turbo) and B58 (3.0L turbo) require new spark plugs every 60,000 miles. N20/N55 engines often spec 45,000 miles. M-series typically 30,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Automatic Transmission Fluid (ZF 8HP)

Every 60,000 mi

BMW labels the ZF 8HP automatic as 'lifetime fill,' but independent transmission specialists strongly recommend replacement every 60,000 miles. Use BMW-spec ZF Lifeguard 8 — no substitutes.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Rear Differential Fluid

Every 60,000 mi

RWD and xDrive AWD: replace rear diff fluid every 60,000 miles, sooner with M-Sport or active differential. M-cars require BMW SAF-XO synthetic.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

xDrive Transfer Case Fluid

Every 60,000 mi

BMW xDrive AWD: replace transfer case fluid every 60,000 miles. Skipping this causes the most common xDrive failure — actuator stuck in 100/0 split.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Microfilter (Cabin Air Filter)

Every 30,000 mi

Replace the activated-carbon microfilter every 30,000 miles. Most BMWs have a single combined cabin/charcoal filter behind the engine bay firewall.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Engine Coolant (G48 / HT-12)

On condition / lifetime

BMW labels coolant as lifetime fill on most modern vehicles. Independent BMW specialists recommend replacement every 4-5 years to prevent water-pump and thermostat housing degradation.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

9 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

1

complaints mentioning a crash

4

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2011 Bmw 135i reflects BMW's published service intervals and the Condition-Based Service system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →