Wrench.Pro

2011 Toyota Highlander Recalls, Issues & Maintenance

The 2011 Toyota Highlander carries 5 open NHTSA recalls — most recently covering seat heater/cooler. Owners report 7 recurring issue clusters, led by “Engine oil cooler pipe/hose leak leading to oil loss.” Toyota's owner's manual splits service into Schedule 1 (severe) and Schedule 2 (normal). Most US drivers fall under Schedule 1 because it covers short trips, extreme temperatures, dusty roads, or heavy idling. The intervals below reflect Schedule 1 — the schedule Toyota recommends for typical real-world use.

5 Open Recalls

Source: NHTSA

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Campaign #16V396000 · Feb 6, 2016

Issue: Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Fix: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER

Campaign #14V743000 · Nov 19, 2014

Issue: Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Fix: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Campaign #15V689000 · Oct 22, 2015

Issue: Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Risk: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Fix: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE

Campaign #13V014000 · Jan 16, 2013

Issue: Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Risk: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Fix: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

EQUIPMENT:OTHER:LABELS

Campaign #13V123000 · Sep 4, 2013

Issue: Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."

Risk: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

Fix: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2011 Toyota Highlander.

Reported to NHTSA

Engine oil cooler pipe/hose leak leading to oil loss

ENGINE

14 NHTSA complaints · 2015-01 → 2025-11

“As my family was driving down Interstate 85 in Atlanta going around 80 MPH a dash notification came on that said "Low Oil Pressure pull over" the notification came on then went away then came back on (car never ran hot)”
— Owner report, NHTSA ODI #11513598
“While driving on the parkway, an oil pressure warning light came on and said to turn off the car. The car immediately started making noise so we pulled onto the shoulder and turned the car off”
— Owner report, NHTSA ODI #11461440
“THE OIL COOLER HOSE LEAKED...LOST ALL OIL AND OIL PRESSURE IN LESS THAN A FEW MINUTES...LUCKY THE ENGINE DIDN;T BLOW. THERE SHOULD BE A RECALL ON THIS AS IT APPEARS IT HAS HAPPENED TO THOUSANDS OF PEOPLE”
— Owner report, NHTSA ODI #11098843

Read all complaints on NHTSA →

Intermediate steering shaft clunking noise when turning

STEERING

23 NHTSA complaints · 2015-05 → 2022-12

“STEERING SHAFT U JOINT MAKES CLUNKING NOISE. DEALER ADVISED IMMEDIATE REPLACEMENT AS THIS IS A SAFETY CONCERN”
— Owner report, NHTSA ODI #11270223
“I STARTED EXPERIENCING A CLUNK IN THE STEERING WHEEL COLUMN WHEN TURNING THE WHEEL TO THE LEFT FOR PARKING . IT HAPPENED A COUPLE OF TIMES SO I TOOK IT TO MY REGULAR TOYOTA DEALERSHIP FOR SERVICE”
— Owner report, NHTSA ODI #11244037
“CLUNKING OR TAPPING NOISE WHEN TURNING LEFT OR RIGHT THAT CAN BE FELT IN THE STEERING WHEEL. DIAGNOSED BY TOYOTA AS "STEERING INTERMEDIATE SHAFT BINDING." THIS IS A KNOWN ISSUE WITH THE 2008-2013 HIGHLANDER”
— Owner report, NHTSA ODI #11155844

Read all complaints on NHTSA →

Driver's side sun visor fails to stay in position

VISIBILITY/WIPER

29 NHTSA complaints · 2012-12 → 2022-09

“DRIVER SIDE SUN VISOR STUCK IN DOWN POSITION, AND WILL NOT MOVE UPWARD OUT OF THE WAY, OBSTRUCTING DRIVER'S VIEW”
— Owner report, NHTSA ODI #11190287
“THE SUN VISOR IN THE DRIVER SIDE IS STUCK IN HALF WAY DOWN POSITION, HIT MY FOREHEAD TWICE ALREADY ON THIS”
— Owner report, NHTSA ODI #10716154
“DRIVER SIDE VISOR WILL NOT STAY UP. BLOCKS DRIVERS VISION. APPEARS TO BE WIDESPREAD FAILURE SINCE 2002. TOYOTA WILL NOT COVER OUT OF WARRANT, WANTS $650 FOR REPLACEMENT PART!!”
— Owner report, NHTSA ODI #10565431

Read all complaints on NHTSA →

Power liftgate arm and hinge failure

STRUCTURE

19 NHTSA complaints · 2012-07 → 2017-04

“REAR LIFTGATE WILL NOT STAY OPEN AND HAS FALLEN ON MY WIFE. TOYOTA HAS ISSUED A SERVICE BULLETIN BUT WILL NOT FIX THERE PROBLEM EST. COST TO REPAIR $3000”
— Owner report, NHTSA ODI #10822783
“THE OPEN REAR AUTOMATIC DOOR FAILED, IMMEDIATELY CLOSING ON MY WIFE'S BACK AS SHE WAS REMOVING A BAG FROM THE REAR CARGO AREA. THE FAILURE HAPPENED WITHOUT WARNING AND CAME DOWN HARD”
— Owner report, NHTSA ODI #10664397
“POWER LIFTGATE MOTOR ARM DETACHED FROM THE UPPER PORTION OF THE REAR DOOR. UPON REPEATED USE AND TIGHTENING IT BECOMES STRIPPED”
— Owner report, NHTSA ODI #10971817

Read all complaints on NHTSA →

Brake system malfunction and ABS actuator failure

SERVICE BRAKES

12 NHTSA complaints · 2011-04 → 2022-03

“ABS BRAKE ACTUATOR FAILED ON TOYOTA HIGHLANDER. SPENT $1905 ON REPAIRS FROM TOYOTA. THERE WAS A RELATE RECALL ON TOYOTA CAMERY HYBRID WITH THE SAME PROBLEM. THE ABS FUNCTION WON'T ACTIVATE WHILE DRIVING”
— Owner report, NHTSA ODI #11063948
“ON FEB 13, I WAS DRIVING AN ANN ARBOR, MI, STREET THAT WAS DOWNHILL AND ICY. I PRESSED THE BRAKE PEDAL UNTIL THE ABS CAME ON, AND HELD IT ON FOR 15 TO 30 SECONDS”
— Owner report, NHTSA ODI #11309478
“PURCHASED MY 2011 HIGHLANDER IN MARCH, & IT HAD 7000 MILES ON IT AT THE TIME OF THE INCIDENT. I STARTED THE VEHICLE IN MY DRIVEWAY, PUT IT IN DRIVE, AND STARTED DOWN MY DRIVEWAY. PRESSED THE BRAKE PEDAL, AND THERE WERE NO BRAKES AND SEEMED NOT TO HAVE POWER STEERING”
— Owner report, NHTSA ODI #10435145

Read all complaints on NHTSA →

Sudden unintended acceleration

VEHICLE SPEED CONTROL

11 NHTSA complaints · 2011-02 → 2019-02

“TL* THE CONTACT OWNS A 2011 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. THE FAILURE OCCURRED WHILE ATTEMPTING TO PARK WITH THE BRAKE DEPRESSED. THE VEHICLE CRASHED INTO THE CEMENT WALL OF A GARAGE”
— Owner report, NHTSA ODI #10454681
“TL* THE CONTACT OWNS A 2011 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE VEHICLE ABNORMALLY ACCELERATED WITHOUT HER DEPRESSING THE ACCELERATOR PEDAL. THE VEHICLE CRASHED INTO A BARN”
— Owner report, NHTSA ODI #10439767
“TL* THE CONTACT OWNS A 2011 TOYOTA HIGHLANDER. WHEN THE BRAKE PEDAL WAS DEPRESSED AT 20 MPH, THE VEHICLE UNINTENTIONALLY ACCELERATED WITHOUT WARNING. THE VEHICLE EVENTUALLY STOPPED AFTER THE BRAKE PEDAL WAS DEPRESSED WITH EXTREME FORCE”
— Owner report, NHTSA ODI #10944240

Read all complaints on NHTSA →

Air bags fail to deploy in a crash

AIR BAGS

5 NHTSA complaints · 2019-06 → 2024-10

“I HIT A CONCRETE POST AT ROUGHLY 30 MPH, DEAD CENTER FRONT OF VEHICLE. THE CAR WAS TOTALLED, AND NONE OF THE AIRBAGS DEPLOYED”
— Owner report, NHTSA ODI #11405618
“TL* THE CONTACT OWNED A 2011 TOYOTA HIGHLANDER. WHILE DRIVING ON THE HIGHWAY, THE VEHICLE HYDROPLANED AROUND A CORNER AND WENT INTO A SMALL EMBANKMENT. THE VEHICLE T-BONED THE CENTER BARRIER OF THE FREEWAY. NONE OF THE AIR BAGS DEPLOYED”
— Owner report, NHTSA ODI #11288500
“TL* THE CONTACT COMPLAINED ABOUT A 2011 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING ABOUT 60 MPH, THE VEHICLE CRASHED INTO THE VEHICLE IN FRONT WHICH STOPPED ABRUPTLY. THE AIR BAGS DID NOT DEPLOY AND THE SEAT BELT DID NOT LOCK IN PLACE (STAYED LOOSE)”
— Owner report, NHTSA ODI #11218881

Read all complaints on NHTSA →

Note: NHTSA also opened 2 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 5,000 mi

Replace 0W-20 full-synthetic oil and filter every 5,000 miles under Schedule 1, or 10,000 miles under Schedule 2. Toyota covers the first 2 oil changes through ToyotaCare.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 5,000 mi

Rotate tires every 5,000 miles. Toyota recommends rotation at every oil change to maximize tire life on FWD and AWD models.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 5,000 mi

Inspect brake pads, rotors, and parking brake every 5,000 miles. Toyota recommends measuring pad thickness at each service.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 36 months. Critical for the integrity of the ABS, VSC, and brake assist systems.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. Earlier under Schedule 1 if driven on unpaved roads.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 60,000 mi

Toyota labels ATF as 'lifetime fill' on most automatics, but recommends inspection and replacement every 60,000 miles under severe service. Use Toyota WS or Type-IV — no substitutes.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 120,000 mi

Toyota iridium-tipped spark plugs are rated for 120,000 miles. Earlier replacement reduces fuel economy and can cause misfires on direct-injection engines.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Super Long Life Coolant (SLLC)

Every 50,000 mi

Toyota SLLC (pink): first change at 100,000 miles, then every 50,000 miles. Do not substitute green or orange coolant — it will damage the cooling system seals.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 30,000 mi

Replace the cabin air filter every 30,000 miles, sooner in dusty climates. Located behind the glove box on most Toyota and Lexus models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Serpentine / Drive Belt Inspection

Every 60,000 mi

Inspect the serpentine belt and tensioner every 60,000 miles. Toyota uses long-life EPDM belts that rarely fail before 100,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Timing Chain — No Replacement

On condition / lifetime

Toyota's 2AR-FE, 2GR-FKS, A25A-FKS, and most Toyota engines built since 2010 use a timing chain rated for the life of the engine. No scheduled replacement.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

30 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

14

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2011 Toyota Highlander reflects Toyota's published service intervals and the Maintenance Required Light system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →