Wrench.Pro

2009 Toyota Highlander Recalls, Problems & Maintenance

The 2009 Toyota Highlander has no open NHTSA recalls. Owners report 8 recurring issue clusters, led by “ABS actuator and brake pump failure.” Toyota's owner's manual splits service into Schedule 1 (severe) and Schedule 2 (normal). Most US drivers fall under Schedule 1 because it covers short trips, extreme temperatures, dusty roads, or heavy idling. The intervals below reflect Schedule 1 — the schedule Toyota recommends for typical real-world use.

Save this car as:

No open recalls on file. NHTSA lists no unrepaired safety recalls for this year, make and model. A recall can be issued at any time, and a specific car can still have one open — check yours by VIN at nhtsa.gov/recalls.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2009 Toyota Highlander.

Reported to NHTSA

ABS actuator and brake pump failure

SERVICE BRAKES

23 NHTSA complaints · 2010-02 → 2025-07

“the ABS pump and actuator on this vehicle have failed. The warning lights on dash indicate ABS, BRAKE, TRACTION CONTROL, and (!). Toyota knows that the actuator on over one hundred thousand vehicles has an internal leakage (which can not be seen on visual inspection)”
— Owner report, NHTSA ODI #11581357
“THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 22 MPH AND ENGAGING THE BRAKE PEDAL IN ATTEMPT TO STOP THE VEHICLE, SHE WAS FORCED TO APPLY EXTREME PRESSURE. THE DEALER WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. A CLAIM WAS FILED WITH THE MANUFACTURER”
— Owner report, NHTSA ODI #10305488
“Braking system warning lights came on. Prior to that the vehicle was making several clunking noises from the front and rear mostly when braking. The stopping distance while braking has been reduced to nearly double the distance while much more force is needed to be applied to”
— Owner report, NHTSA ODI #11460850

Read all complaints on NHTSA →

Power liftgate motor and hinge failure

STRUCTURE

13 NHTSA complaints · 2012-11 → 2019-06

“THERE HAS BEEN A LATCHING ISSUE WITH THE REAR POWER HATCH SINCE WE HAVE OWNED THE CAR. TOYOTA ISSUED A REPAIR RECALL IN 2017 TO FIX THE ISSUE BUT IT IS BROKEN ONCE AGAIN. EITHER THEY ARE USING DEFECTIVE PARTS OR A DESIGN FLAW”
— Owner report, NHTSA ODI #11218311
“REAR DOOR HATCH MADE A LOUD POPPING NOISE WHEN DOOR WAS LOWERED. DOOR NO LONGER OPENS OR CLOSES. DEALER STATES COST TO REPAIR $4,700 TO $5,400. TOYOTA HAS A TECHNICAL SERVICE BULLETIN COVERING THIS PROBLEM BUT DENIES RESPONSIBILITY IF VEHICLE IS BEYOND 36/36,000 WARRANTY”
— Owner report, NHTSA ODI #10746084
“THE POWER ARM BROKE OFF OF THE REAR POWER LIFT GATE WHEN CLOSING. THE DRIVER SIDE HINGE ON THE REAR POWER LIFTGATE IS BOWED”
— Owner report, NHTSA ODI #10486305

Read all complaints on NHTSA →

Power door lock actuator failure

ELECTRICAL SYSTEM

5 NHTSA complaints · 2010-08 → 2018-10

“2009 TOYOTA HIGHLANDER LIMITED DOOR ACTUATORS HAVE ALL BROKE, BEEN REPLACED AND BROKE AGAIN. SOME ARE BEING REPLACED FOR THE 3RD TIME SINCE I OWED THE VEHICLE (MAKING IT THE 4TH LOCK ON THE CAR)”
— Owner report, NHTSA ODI #11141895
“MY VEHICLE HAS AN ISSUE WITH THE DOOR LOCKS WHICH IS A SAFETY CONCERN, THE POWER DOOR LOCK ACTUATORS HAVE REPEATEDLY FAILED ON MY VEHICLE. EACH OF THE FOUR DOOR LOCK ACTUATORS HAVE BEEN REPLACED AND SEVERAL MULTIPLE TIMES”
— Owner report, NHTSA ODI #10946865
“DOOR LOCK ON FRONT DRIVER DOOR DOES NOT LOCK WHEN REMOTE OR DOOR BUTTON INSIDE CAR PRESSED. GIVES IMPRESSION DOOR IS LOCKING WHEN IT IS NOT”
— Owner report, NHTSA ODI #10649905

Read all complaints on NHTSA →

Tire tread wear and separation

TIRES

6 NHTSA complaints · 2009-03 → 2024-02

“COMPLAINANT HAD TO REPLACE THE ORIGINAL BRIDGESTONE TIRES (245/55R19) ON A 2009 TOYOTA HIGHLANDER LTD AFTER 20,679 MILES. TREAD WEAR WAS BELOW 3/32'S. TOYOTA WOULD NOT WARRANT OR PARTICIPATE IN THE REPLACEMENT COSTS”
— Owner report, NHTSA ODI #10442078
“TOYOTA HIGHLANDER 19" RIMS WITH TOYO OPEN COUNTRY A20 TIRES ARE VERY UNSAFE. THIS TIRE/WHEEL COMBINATION WAS STANDARD ON 2008/09 LIMITED AND SPORT HIGHLANDERS. MY 2009 HIGHLANDER WOULD SLIP ALL OVER THE PLACE IN WINTER DRIVING”
— Owner report, NHTSA ODI #10380881
“245/55R19 is the tire size. I went to have my tires balanced and aligned on [XXX] at a local shop, Arrow. Alignment here in Eau Claire, WI. They advised me that the ply in all 4 tires was separating and that is why the ride was so rough”
— Owner report, NHTSA ODI #11571720

Read all complaints on NHTSA →

Engine oil cooler pipe leak

ENGINE

14 NHTSA complaints · 2013-03 → 2020-07

“OIL COOLER CONNECTED TO ENGINE BLOCK WITH A RUBBER HOSE. HOSE FAILED WITH OIL LEAK WHICH CAUSED LOSS OF ENGINE OIL. CAR TOWED AND REPAIRED BEFORE ENGINE SEIZED. IT APPEARS RUBBER HOSE WAS NOT PROTECTED FROM HEAT OF CATALYTIC CONVERTER AND RUBBER DEGRADED”
— Owner report, NHTSA ODI #11339363
“MASSIVE OIL LEAK FROM OIL COOLER LINE OF 2009 TOYOTA HIGHLANDER WITH TOW PACKAGE AT ~78,000 MILES. RUBBER HOSES BURST AND OIL LEAKED OUT FROM ENGINE”
— Owner report, NHTSA ODI #10680148
“WE WERE TRAVELING DOWN A STATE ROUTE HIGHWAY AT 50 MPH WHEN SUDDENLY WE LOST POWER TO THE CAR, WE WERE BETWEEN TWO MAC TRUCKS, AND THE OIL LIGHT STARTED FLASHING. WE HAD TO QUICKLY GET OFF THE ROADWAY (NO BREAKDOWN LANES) AND FIND A SAFE SPOT TO STOP ON SOME GRASS”
— Owner report, NHTSA ODI #10743458

Read all complaints on NHTSA →

Electric power steering failure

STEERING

10 NHTSA complaints · 2013-09 → 2020-04

“THE CONTACT STATED THAT WHILE REVERSING OUT OF THE DRIVEWAY, THE STEERING CEASED. THE CONTACT STATED THAT ADDED EFFORT WAS NEEDED TO TURN THE STEERING WHEEL. THE CONTACT STATED THAT THERE WAS NO EVIDENCE OF A POWER STEERING FLUID LEAK”
— Owner report, NHTSA ODI #11320422
“WHILE DRIVING, THE BATTERY LIGHT ON THE DASH ILLUMINATED, WHILE THE POWER ASSIST STEERING NO LONGER WORKED. THE CAR COULD STILL DRIVE AND STEER, BUT IT WAS VERY DIFFICULT TO TURN”
— Owner report, NHTSA ODI #11176148
“A CLUNKING OR THUMPING NOISE COMES FROM THE LOWER STEERING COLUMN AS YOU MAKE A LEFT OR RIGHT HAND TURN. THE THUMPING NOISE HAS BEEN STEADILY INCREASING OVER THE PAST WEEKS”
— Owner report, NHTSA ODI #11253498

Read all complaints on NHTSA →

Unintended acceleration and stuck accelerator pedal

VEHICLE SPEED CONTROL

12 NHTSA complaints · 2009-11 → 2019-08

“THE CONTACT WAS REVERSING FROM A PARKING SPACE AT 5 MPH WHEN THE ACCELERATOR PEDAL BECAME STUCK AND CAUSED THE VEHICLE TO ACCELERATE RAPIDLY. THE CONTACT MENTIONED THAT SHE WAS UNABLE TO STOP THE VEHICLE AND AS A RESULT, SHE CRASHED INTO A TREE”
— Owner report, NHTSA ODI #10457032
“ACCELERATOR STUCK ALL THE WAY TO FLOOR ON 2009 TOYOTA HIGHLANDER WHILE VACATIONING IN TENNESSEE ON I40. HAD TO WEAVE THRU TRAFFIC TO SHOULDER WHILE TRAVELING TOWARDS 100 MPH, MASHING FULL FORCE TO THE FLOOR ALL THE TIME DURING INCIDENT”
— Owner report, NHTSA ODI #10292349
“WHILE DRIVING 65 MPH HE ATTEMPTED TO ACCELERATE TO PASS A VEHICLE AND NOTICED THAT THE FLOOR MAT BECAME STUCK BEHIND THE ACCELERATOR PEDAL CAUSING THE VEHICLE TO CONTINUALLY ACCELERATE. THE CONTACT WAS ABLE TO RELEASE THE FLOOR MAT WHICH ALLOWED THE PEDAL TO RELEASE”
— Owner report, NHTSA ODI #10302943

Read all complaints on NHTSA →

Driver sun visor drop failure

VISIBILITY/WIPER

4 NHTSA complaints · 2014-01 → 2017-11

“THE SUN VISOR REPEATEDLY FLOPS DOWN OBSCURING THE DRIVER'S VIEW. THE VISOR WILL NOT STAY IN THE "UP" POSITION. ALSO WHEN ENTERING THE VEHICLE, IF THE VISOR IS IN THE VERTICAL POSITION, I.E. NOT UP WHERE IT SHOULD BE, THE DRIVER WILL HIT HIS/HER HEAD ON THE EDGE OF THE VISOR”
— Owner report, NHTSA ODI #11043283
“THE DRIVER SIDE SUN VISOR DROOPS DOWN. TOYOTA IS NOT TAKING RESPONSIBILITY FOR THIS ISSUE. IT SEEMS TO BE HAPPENING ALOT. IT FALLS WHILE I'M DRIVING, AND I'M AFRAID IT WILL CAUSE ME TO GET IN A WRECK”
— Owner report, NHTSA ODI #10677098
“THE DRIVER'S SIDE VISOR NO LONGER STAYS UP, SO IT HAS PROGRESSIVELY DROPPED DOWN TO ABOUT A 30-45 DEGREE ANGLE TOWARD THE DRIVER'S HEAD. THIS IS A LARGE SAFETY HAZARD BOTH FOR GENERAL VISIBILITY WHEN DRIVING AND POTENTIAL CAUSE OF INJURY TO THE HEAD IN THE CASE OF AN ACCIDENT”
— Owner report, NHTSA ODI #10559001

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 5,000 mi

Replace 0W-20 full-synthetic oil and filter every 5,000 miles under Schedule 1, or 10,000 miles under Schedule 2. Toyota covers the first 2 oil changes through ToyotaCare.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 5,000 mi

Rotate tires every 5,000 miles. Toyota recommends rotation at every oil change to maximize tire life on FWD and AWD models.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 5,000 mi

Inspect brake pads, rotors, and parking brake every 5,000 miles. Toyota recommends measuring pad thickness at each service.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 36 months. Critical for the integrity of the ABS, VSC, and brake assist systems.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. Earlier under Schedule 1 if driven on unpaved roads.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 60,000 mi

Toyota labels ATF as 'lifetime fill' on most automatics, but recommends inspection and replacement every 60,000 miles under severe service. Use Toyota WS or Type-IV — no substitutes.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 120,000 mi

Toyota iridium-tipped spark plugs are rated for 120,000 miles. Earlier replacement reduces fuel economy and can cause misfires on direct-injection engines.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Super Long Life Coolant (SLLC)

Every 50,000 mi

Toyota SLLC (pink): first change at 100,000 miles, then every 50,000 miles. Do not substitute green or orange coolant — it will damage the cooling system seals.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 30,000 mi

Replace the cabin air filter every 30,000 miles, sooner in dusty climates. Located behind the glove box on most Toyota and Lexus models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Serpentine / Drive Belt Inspection

Every 60,000 mi

Inspect the serpentine belt and tensioner every 60,000 miles. Toyota uses long-life EPDM belts that rarely fail before 100,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Timing Chain — No Replacement

On condition / lifetime

Toyota's 2AR-FE, 2GR-FKS, A25A-FKS, and most Toyota engines built since 2010 use a timing chain rated for the life of the engine. No scheduled replacement.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

15 crashes 1990–2024

How the 15 occupant deaths break down

10

driver deaths

5

passenger deaths

15

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2009 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

6

complaints mentioning a crash

5

complaints mentioning a fire

Reviewed known issues for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2009 Toyota Highlander reflects Toyota's published service intervals and the Maintenance Required Light system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →