Wrench.Pro

2016 Gmc Yukon Recalls, Issues & Maintenance

The 2016 Gmc Yukon carries 5 open NHTSA recalls — most recently covering vacuum and wheel speed sensor/tone ring. Owners report 6 recurring issue clusters, led by “Tail/brake light LED assembly failure.” GMC trucks and SUVs use the GM Oil Life System (OLS) — the same algorithm as Chevrolet. Because GMC's lineup is exclusively trucks and SUVs, severe-service intervals apply to most owners (towing, hauling, off-roading). The schedule below surfaces the items most relevant to GMC's truck-focused buyer.

5 Open Recalls

Source: NHTSA

SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM

Campaign #19V645000 · Jun 9, 2019

Issue: General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.

Risk: As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.

Fix: GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING

Campaign #19V761000 · Oct 24, 2019

Issue: General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.

Risk: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.

Fix: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.

AIR BAGS:FRONTAL

Campaign #16V651000 · Aug 9, 2016

Issue: General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

Fix: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.

AIR BAGS:FRONTAL

Campaign #17V437000 · Oct 7, 2017

Issue: General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

Fix: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.

SUSPENSION:FRONT:CONTROL ARM

Campaign #16V256000 · Apr 28, 2016

Issue: General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Silverado 1500 and 2016 Cadillac Escalade, Cadillac Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Sierra, GMC Yukon and GMC Yukon XL vehicles. The front upper control arms may have inadequate welds near the control arm bushing.

Risk: Inadequate welds may allow the control arm to separate from the bushing, compromising steering and increasing the risk of a crash.

Fix: GM will notify owners, and dealers will replace the left and right front upper control arms and realign the vehicle, free of charge. The recall began on May 18, 2016. Until the repairs have been made, owners are advised not to drive their vehicles. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, or GMC customer service at 1-800-462-8782. GM's number for this recall is 42190.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2016 Gmc Yukon.

Reported to NHTSA

Tail/brake light LED assembly failure

EXTERIOR LIGHTING

89 NHTSA complaints · 2019-05 → 2025-10

“THE BRAKE LIGHTS IN THE 2016 GMC YUKON VEHICLE FAILED. THE DESIGN REQUIRES A WHOLE LIGHT ASSEMBLY REPLACEMENT. THE DEALER QUOTED $750 PER LIGHT. THE PROBLEM SEEMS TO BE WIDESPREAD AND CAUSED BY FAULTY LIGHT ASSEMBLY”
— Owner report, NHTSA ODI #11210137
“REAR LED TAILLIGHT WENT OUT OUR ONLY 3 YEAR OLD 2016 GMC DENALI. THIS EFFECTS THE STOP, TAIL, AND TURN LIGHTS. THESE LED LIGHTS ARE NOT REPAIRABLE AND THE WHOLE ASSEMBLY HAS TO BE REPLACED. GM CHARGES AN ASTRONOMICAL PRICE OF AROUND $700 FOR EACH SIDE”
— Owner report, NHTSA ODI #11297087
“The LED left turn signal and blind spot detection ( safety feature) on the left outside rear view mirror suddenly stopped working”
— Owner report, NHTSA ODI #11692277

Read all complaints on NHTSA →

Transmission shudder and torque converter failure

POWER TRAIN

31 NHTSA complaints · 2019-09 → 2026-06

“The contact owns a 2016 GMC Yukon. The contact stated that while the vehicle was at the inspection station for an inspection, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended”
— Owner report, NHTSA ODI #11747485
“TL* THE CONTACT OWNS A 2016 GMC YUKON. AFTER STARTING THE ENGINE, THE VEHICLE WOULD NOT OPERATE WHILE IN THE DRIVE OR REVERSE POSITIONS”
— Owner report, NHTSA ODI #11255883
“VEHICLE BEGAN TO SHUDDER AND JERK UPON ACCELERATION AT 30K. DEALERSHIP CHANGED FLUID. AT 60K VEHICLE CONTINUED TO SHUDDER AND JERK UPON ACCELERATION AND LURCH FORWARD OR BACKWARD ALTHOUGH BRAKE WAS DEPRESSED. INITIAL, BRIEF DIAGNOSES REVEALS A BAD TORQUE CONVERTER”
— Owner report, NHTSA ODI #11362418

Read all complaints on NHTSA →

Air conditioning condenser refrigerant leak

UNKNOWN OR OTHER

5 NHTSA complaints · 2019-05 → 2021-07

“A/C Condensing Unit leaking. Appears to Leak from small tack weld on the top area of the condensing unit. All of the R134 went out and left with no A/C. Seems to be a common problem and ignored by GMC”
— Owner report, NHTSA ODI #11423518
“ANOTHER MESS WITH MY 2016 YUKON SLE. THE A/C CONDENSER WENT OUT AT JUST OVER 60K MILES -- $1600 TOTAL IN REPAIR COST”
— Owner report, NHTSA ODI #11218876
“I HAVE 3 YEAR OLD GMC YUKON XL AND THE CONDENSER HAS GONE OUT ON IT. THIS IS ABOUT A $1,600 REPAIR DUE TO GMC'S POOR DESIGN OF THE LOCATION OF THE CONDENSER”
— Owner report, NHTSA ODI #11209792

Read all complaints on NHTSA →

Brake pedal hard or unresponsive, vacuum pump failure

SERVICE BRAKES

27 NHTSA complaints · 2019-06 → 2026-05

“The contact owns a 2016 GMC Yukon. The contact stated that while driving at an undisclosed speed, the brake pedal became inoperable and failed to engage properly, with no warning lights illuminated”
— Owner report, NHTSA ODI #11740130
“The contact owns a 2016 GMC Yukon. The contact stated that while driving at approximately 70 mph, the brake pedal was hard to depress and the brake pedal traveled to the floorboard”
— Owner report, NHTSA ODI #11445404
“LOW SPEEDS THE BRAKES FAIL , WHEN PRESSING ON BRAKES YOU GET A HARD BRAKE PEDAL WITH NO BRAKES”
— Owner report, NHTSA ODI #11220355

Read all complaints on NHTSA →

Engine lifter and push rod failure

ENGINE

10 NHTSA complaints · 2022-09 → 2026-04

“Ticking sound coming from engine, possible damaged camshaft lobe due to lifter roller failure. It can cause sudden engine failure, significant power loss, and unexpected stalling while driving, increasing crash risks”
— Owner report, NHTSA ODI #11730883
“The contact owns a 2016 GMC Yukon. The contact stated that the vehicle was initially repaired under warranty for a bent push rod in cylinder #4; however, the failure recurred”
— Owner report, NHTSA ODI #11719970
“Engine lifter failure causing complete engine failure at 70,000 miles without any warning. All vehicle maintenance done and serviced at dealer 30 days prior. Left our family stranded on a busy 2 lane highway and were lucky to even get off the road”
— Owner report, NHTSA ODI #11498900

Read all complaints on NHTSA →

Power steering assist loss or lockup

STEERING

7 NHTSA complaints · 2019-06 → 2026-07

“Power steering intermittently and unexpectedly stops working”
— Owner report, NHTSA ODI #11751501
“When making a slow turn in drive or reverse the park assist screen shows it’s not working. Then all screens in the car turn black and the steering locks while driving. Making it impossible to turn or move. This is happening while driving, while parking”
— Owner report, NHTSA ODI #11714221
“On [XXX], I was driving my 2016 Yukon Denali on a trip to Maryland. While in Maryland, I was driving my vehicle. As I approached a street to make a right turn, I braked to make the turn. I slowed down to make the turn”
— Owner report, NHTSA ODI #11575208

Read all complaints on NHTSA →

Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when OLS reaches 0% or every 12 months. dexos1-approved synthetic required on Sierra 1500 5.3L/6.2L; dexos2 specified on Duramax diesel.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Sierra and Yukon owners running 4x4 should rotate every 5,000-7,500 miles to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, and parking brake every 7,500 miles. Towing accelerates pad wear by 30-50%; check more often if towing regularly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

DOT 3 brake fluid: test annually, replace when moisture exceeds 3% or fluid is darker than copper.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

Long-life cellulose filter rated 45,000 miles. Trucks driven on unpaved roads or construction sites should inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (towing 5,000+ lbs regularly, heavy stop-and-go): every 45,000 miles. Normal: 97,500 miles. Use Dexron-VI for 6L80/6L90, Mobil 1 LV ATF HP for 10L80/10L1000.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Sierra and Yukon 4WD: replace every 45,000 miles. Use GM Auto-Trak II for active 4WD; GM 9986115 for selectable 4WD.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Differential Fluid (front + rear)

Every 50,000 mi

Replace front and rear axle fluid every 50,000 miles, or 25,000 miles if towing. G80 limited-slip rear axles require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on the L83/L84 5.3L and L86/L87 6.2L V8 are rated 100,000 miles. AFM/DFM cylinder deactivation can cause uneven plug wear — check at 75,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000. Duramax diesel uses ELC (red) — different chemistry, do not mix.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace cabin air filter every 22,500 miles. Sierra HD and Yukon XL owners in dusty work environments should replace at 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

17 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

4

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2016 Gmc Yukon reflects GMC's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →