Wrench.Pro

2019 GMC Yukon Recalls, Problems & Maintenance

The 2019 GMC Yukon carries 2 open NHTSA recalls — most recently covering wheel speed sensor/tone ring and transfer case (4-wheel drive). Owners report 4 recurring issue clusters, led by “Engine lifter and camshaft failure.” GMC trucks and SUVs use the GM Oil Life System (OLS) — the same algorithm as Chevrolet. Because GMC's lineup is exclusively trucks and SUVs, severe-service intervals apply to most owners (towing, hauling, off-roading). The schedule below surfaces the items most relevant to GMC's truck-focused buyer.

Save this car as:

2 Open Recalls

Source: NHTSA

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING

Campaign #19V761000 · Oct 24, 2019

Issue: General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.

Risk: Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.

Fix: GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

Campaign #26V289000 · Jul 5, 2026

Issue: General Motors, LLC (GM) is recalling certain 2026 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, and GMC Sierra 1500, Yukon, and Yukon XL vehicles with four-wheel (4WD) or all-wheel drive (AWD), and certain 2015-2020 Suburban, Escalade, Escalade ESV, Yukon, Yukon XL, and Tahoe vehicles. A component missing from the drivetrain transfer case may cause the front and/or rear wheels to lock up without warning to the driver.

Risk: Front or rear wheel lockup increases the risk of a crash.

Fix: Owners are advised not to drive their vehicle until the remedy is completed. Dealers will inspect and, if necessary, replace the transfer case assembly, free of charge. Owner notification letters were mailed May 18, 2026. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-333-4223. GM's number for this recall is N262557620. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 7, 2026.

Recall data refreshed Sep 20, 2026.

Known issues & problems for this vehicle

What drivers and federal regulators have officially reported about the 2019 GMC Yukon.

Reported to NHTSA

Engine lifter and camshaft failure

ENGINE

24 NHTSA complaints · 2022-08 → 2026-08

“I am reporting a serious and recurring safety defect involving my 2019 GMC Yukon Denali equipped with the 6.2L V8 L87 engine and GM’s AFM/DFM system”
— Owner report, NHTSA ODI #11700050
“Engine lifter spring failure followed by bent valve push rod experienced on or about 11/6/2025. Engine repaired/re-built at independent auto mechanic for a total of $6,450”
— Owner report, NHTSA ODI #11710111
“Engine lights and all other warning lights came on, and lost total power in engine while driving. Engine knocked bad and had to limp to a repair center to check out engine problem”
— Owner report, NHTSA ODI #11663172

Read all complaints on NHTSA →

Transmission failure while driving

POWER TRAIN

10 NHTSA complaints · 2023-05 → 2026-08

“The vehicle experienced a sudden and rapid mechanical failure of the 6-speed automatic transmission (6L80 model) within a span of less than two weeks”
— Owner report, NHTSA ODI #11748498
“The contact owns a 2019 GMC Yukon. The contact stated that while driving at slow speeds in a parking lot, the transmission unexpectedly downshifted and the vehicle jerked abnormally”
— Owner report, NHTSA ODI #11729010
“Transmission failed at 90,100 miles. Left me stranded in middle of a busy intersection as I was making a left turn, it was like it was in neutral no matter how much I tried to accelerate”
— Owner report, NHTSA ODI #11642849

Read all complaints on NHTSA →

Trailer brake system warning without a trailer attached

ELECTRICAL SYSTEM, SERVICE BRAKES

4 NHTSA complaints · 2022-05 → 2025-08

“We received an alert/warning that is nearly constantly beeping and servicing the trailer brake system. We have never used the wiring or towed anything, and the trailer brake system is unused”
— Owner report, NHTSA ODI #11635425
“The contact owns a 2019 GMC Yukon. The contact stated that while driving at an undisclosed speed, the service trailer brake system warning light illuminated and alerted the contact. The contact stated that there was no trailer brake”
— Owner report, NHTSA ODI #11501008
“Received a message on driver information system that states service trailer brake system. When towing a trailer, the trailer brakes are inoperable and pose a safety risk in the event of a sudden brake event”
— Owner report, NHTSA ODI #11464220

Read all complaints on NHTSA →

Loss of power steering assist

STEERING

5 NHTSA complaints · 2019-07 → 2025-04

“DRIVING DOWN THE HIGHWAY AT NORMAL SPEED A WARNING APPEARS THAT SAYS SERVICE POWER STEERING. IMMEDIATELY LOST POWER STEERING ON THE VEHICLE AND BY THE TIME WE GOT IT TO THE OFF RAMP THE STEERING WAS COMPLETELY LOCKED IN THE STRAIGHT POSITION”
— Owner report, NHTSA ODI #11240377
“the steering gear box became disassemble, steering wheel when to twelve o'clock, gears in steering gear box jump gear insurance inspector said a bolt back out”
— Owner report, NHTSA ODI #11511545
“Power steering going in and out while driving”
— Owner report, NHTSA ODI #11653365

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 20, 2026. Investigation data refreshed Sep 20, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Raw data + downloads for this vehicle →

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when OLS reaches 0% or every 12 months. dexos1-approved synthetic required on Sierra 1500 5.3L/6.2L; dexos2 specified on Duramax diesel.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Sierra and Yukon owners running 4x4 should rotate every 5,000-7,500 miles to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, and parking brake every 7,500 miles. Towing accelerates pad wear by 30-50%; check more often if towing regularly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

DOT 3 brake fluid: test annually, replace when moisture exceeds 3% or fluid is darker than copper.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

Long-life cellulose filter rated 45,000 miles. Trucks driven on unpaved roads or construction sites should inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (towing 5,000+ lbs regularly, heavy stop-and-go): every 45,000 miles. Normal: 97,500 miles. Use Dexron-VI for 6L80/6L90, Mobil 1 LV ATF HP for 10L80/10L1000.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

On 4WD models, replace every 45,000 miles. Use GM Auto-Trak II for active 4WD; GM 9986115 for selectable 4WD.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Differential Fluid (front + rear)

Every 50,000 mi

Replace front and rear axle fluid every 50,000 miles, or 25,000 miles if towing. G80 limited-slip rear axles require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on the L83/L84 5.3L and L86/L87 6.2L V8 are rated 100,000 miles. AFM/DFM cylinder deactivation can cause uneven plug wear — check at 75,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000. Duramax diesel uses ELC (red) — different chemistry, do not mix.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace cabin air filter every 22,500 miles. Sierra HD and Yukon XL owners in dusty work environments should replace at 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

5 crashes 1990–2024

How the 5 occupant deaths break down

4

driver deaths

1

passenger deaths

5

occupant deaths

Crash years covered: 1990–2024 This model year first appears in 2019 crashes. Older models have had more years on the road to appear in these crashes, so a higher count here does not by itself mean a vehicle is less safe.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

FARS 2024 data is an annual report file. NHTSA revises these records when the final file is published, so this count can change.

Why we show driver deaths too

Every vehicle has exactly one driver seat, so driver deaths line up fairly when you compare one model to another. Occupant deaths include passengers, so a three row SUV can show a higher number than a two seat car simply because it carries more people.

Both figures are plain counts, not rates. A rate would need to know how many of each vehicle are on the road, and that registration data is not public, so we do not publish rates or scores of any kind.

IIHS publishes driver death rates using this same driver only idea, paired with a registered vehicle years denominator we do not have. Their rates and these counts answer different questions, so do not read either number here as a safety rating.

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

1

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2019 GMC Yukon reflects GMC's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →