Wrench.Pro

2018 Gmc Sierra 2500 Recalls, Issues & Maintenance

The 2018 Gmc Sierra 2500 carries 5 open NHTSA recalls — most recently covering retractor and engine. Owners report 6 recurring issue clusters, led by “Diesel exhaust fluid recall repair delayed by parts.” GMC trucks and SUVs use the GM Oil Life System (OLS) — the same algorithm as Chevrolet. Because GMC's lineup is exclusively trucks and SUVs, severe-service intervals apply to most owners (towing, hauling, off-roading). The schedule below surfaces the items most relevant to GMC's truck-focused buyer.

5 Open Recalls

Source: NHTSA

SEAT BELTS:FRONT:RETRACTOR

Campaign #17V567000 · Sep 14, 2017

Issue: General Motors (GM) is recalling certain 2017-2018 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 trucks. The front seat belt retractor assemblies were built with the incorrect torsion bar. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."

Risk: The seat belt retractors may not perform as intended during a crash, increasing the risk of injury.

Fix: GM will notify owners, and dealers will replace both front seat belt retractor assemblies, free of charge. The recall began March 24, 2021. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's numbers for this recall are 17368, 17375, and 17376.

ENGINE

Campaign #19V328000 · Apr 25, 2019

Issue: General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.

Risk: A short-circuit may damage the engine components and increase the risk of fire.

Fix: GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.

EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER

Campaign #21V496000 · Jan 7, 2021

Issue: General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500 and 2017-2019 GMC Sierra 2500 and 3500 vehicles equipped with a Duramax diesel 6.6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.

Risk: An electrical short-circuit can increase the risk of a fire.

Fix: Dealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heaters and cords under a separate customer satisfaction campaign. For vehicles previously included in recall 19V-328, the heater cord will be replaced and rerouted, free of charge. Interim owner notifications were mailed on August 13, 2021. Owner notification letters are expected to be mailed on April 4, 2022. Customers may call GMC customer service at 1-800-462-8782. GM's number for this recall is 212329840.

FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

Campaign #23V047000 · Feb 2, 2023

Issue: General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.

Risk: An engine stall increases the risk of a crash.

Fix: Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030.

AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR

Campaign #24V756000 · Oct 10, 2024

Issue: General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2018-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 Crew Cab trucks. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

Risk: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Fix: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC Customer Service at 888-988-7267. GM's number for this recall is N242474500.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2018 Gmc Sierra 2500.

Reported to NHTSA

Diesel exhaust fluid recall repair delayed by parts

EQUIPMENT

4 NHTSA complaints · 2021-09 → 2022-02

“The contact owns a 2018 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 21V496000 (Equipment) however, the part to do the recall repair was not yet available. The local dealer was contacted and it was confirmed that parts were not yet available. The”
— Owner report, NHTSA ODI #11451143
“The contact owns a 2018 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 21V496000 (Equipment) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact”
— Owner report, NHTSA ODI #11440272
“The contact owns a 2018 GMC Sierra 2500. The contact received a notification for NHTSA Campaign Number: 21V496000 (Equipment) however, the part to do the recall repair was unavailable. The dealer had been notified about the recall; however, the contact was informed that the part”
— Owner report, NHTSA ODI #11435349

Read all complaints on NHTSA →

Tire tread separates or sidewall bubbles

TIRES

4 NHTSA complaints · 2019-09 → 2023-09

“LT265 60 R20 Goodyear Wrangler SR-A tire experienced a tread separation while traveling at 68 MPH. This resulted in significant vibration in the steering. This tire was inspected at a tire shop and the tread separation was confirmed. The tire still had 7/32 of tread left at the”
— Owner report, NHTSA ODI #11430187
“TL* THE CONTACT OWNS A 2018 GMC SIERRA 2500 EQUIPPED WITH ORIGINAL FIRESTONE TRANSFORCE H/T TIRES, SIZE: 245/75/R17 (NA). UPON INSPECTION, THE CONTACT DISCOVERED THAT ALL FOUR TIRES HAD EXPERIENCED SIDEWALL BUBBLING. THE UNUSED SPARE TIRE ALSO EXPERIENCED THE FAILURE. THE”
— Owner report, NHTSA ODI #11252971
“driving at 70mph, thread from tire blew.. That was in July, I went and purchased another tire from Bob King GMC Wilmington, NC. The first tire that blew was now discontinued so I purchased another Good Year . On Friday I noticed that another tire on my truck had a bubble along”
— Owner report, NHTSA ODI #11544060

Read all complaints on NHTSA →

Headlight shakes and flickers over bumps

EXTERIOR LIGHTING

3 NHTSA complaints · 2018-10 → 2020-04

“HEADLIGHT SHAKES AND FLICKERS WHILE DRIVING OVER BUMPS IN THE ROAD. HAPPENS ON CITY STREETS AND HIGHWAYS. FLICKERING IS VERY DISTRACTING AND DRAWS ATTENTION AWAY FROM YOUR SURROUNDINGS”
— Owner report, NHTSA ODI #11320881
“HID HEADLIGHTS SHAKE WHEN HITTING THE SLIGHTEST BUMP IN THE ROAD. GM SAYS IT'S NORMAL AND REFUSES TO TRY TO FIX”
— Owner report, NHTSA ODI #11204045
“HEADLIGHTS SHAKE WHEN GOING OVER BUMPS IN HIGHWAY. ITS DISTRACTING AND IRRITATING AND TAKES YOUR ATTENTION FROM THE ROAD WHEN IT HAPPENS”
— Owner report, NHTSA ODI #11140670

Read all complaints on NHTSA →

Service Trailer Brake System warning chimes falsely

ELECTRICAL SYSTEM

2 NHTSA complaints · 2023-02 → 2024-11

“Service Trailer Brake System Warning From time to time, this warning goes off in the vehicle and when it does, it does it constantly. When the warning is dismissed, it does it again seconds later. If it is not dismissed, it does it again seconds later. It is a persistent three”
— Owner report, NHTSA ODI #11624405
“I have a 2018 GMC Sierra Duramax Quad-Cab and when it is connected to either my boat, stock trailer, or cargo trailer the lights and electric trailer brakes on the trailers do not work. and the chime from the "Service Trailer Brake" indicator sounds and doesn't stop until I”
— Owner report, NHTSA ODI #11508714

Read all complaints on NHTSA →

Fuel injector or delivery failure causes shutdown

ENGINE, FUEL/PROPULSION SYSTEM

8 NHTSA complaints · 2018-07 → 2026-05

“Faulty pigtail connector for fule injectors. Cause The vehicle to shut down even while going down the highway possibly causing injury by immediate deceleration wich could cause an accident. For me on this vehicle I’ve had this happen three times and it has cost me anywhere from”
— Owner report, NHTSA ODI #11460968
“MY HUSBAND WAS DRIVING OUR BRAND NEW DENALI WHICH HAS ONLY 3500 MILES ON IT. THE ENGINE COMPLETELY SHUT DOWN CROSSING A HIGHWAY WITH 55 MILES PER HOUR POSTING AND MY DAUGTHER OF 8 YEARS OLD WAS IN THE BACK SEAT. THE ENGINE AS I SAID COMPLETELY SHUT DOWN WITH NO INDICATOR LIGHTS”
— Owner report, NHTSA ODI #11112033
“Constant issues with glow plug failures, fuel rail failure, fuel pressure failure. Truck has been in the Gmc service regarding these issues constantly for the last year with a total of five repairs and replacement of glow plugs with releaning learning new plugs and now the 6th”
— Owner report, NHTSA ODI #11553304

Read all complaints on NHTSA →

Rear defroster circuit overheats and smokes

ELECTRICAL SYSTEM

3 NHTSA complaints · 2018-08 → 2022-11

“MY 2018 GMC SIERRA HD EXPERIENCED AN ELECTRICAL SHORT OR OVERLOAD, CAUSING A THERMAL EVENT THAT MELTED AREAS AROUND THE REAR DEFROST CIRCUIT. LOTS OF SMOKE AND BURNING SMELL, BUT LUCKILY, I DID NOT SEE FLAMES. THE EXACT ISSUE IS CURRENTLY BEING ADDRESSED UNDER GM RECALL#”
— Owner report, NHTSA ODI #11318830
“WHILE THE TRUCK WAS UNATTENDED, SMOKE WAS OBSERVED BY A PASSER-BY WHO CALLED THE LOCAL FIRE DEPARTMENT. FIRE DEPT BROKE A WINDOW FOR ACCESS, EXTINGUISHED FIRE. HAULED VEHICLE AWAY FOR SAFEKEEPING. HAPPENED WHILE WE WERE AT A CONDO COMPLEX, VEHICLE PARKED FOR THE EVENING. HEAT”
— Owner report, NHTSA ODI #11119531
“Water leak, known in other years of the same model vehicle, caused the rear defrost to fail and smoke when in operation nearly causing a fire in the vehicle as it was being operated”
— Owner report, NHTSA ODI #11491986

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when OLS reaches 0% or every 12 months. dexos1-approved synthetic required on Sierra 1500 5.3L/6.2L; dexos2 specified on Duramax diesel.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Sierra and Yukon owners running 4x4 should rotate every 5,000-7,500 miles to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, and parking brake every 7,500 miles. Towing accelerates pad wear by 30-50%; check more often if towing regularly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

DOT 3 brake fluid: test annually, replace when moisture exceeds 3% or fluid is darker than copper.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

Long-life cellulose filter rated 45,000 miles. Trucks driven on unpaved roads or construction sites should inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (towing 5,000+ lbs regularly, heavy stop-and-go): every 45,000 miles. Normal: 97,500 miles. Use Dexron-VI for 6L80/6L90, Mobil 1 LV ATF HP for 10L80/10L1000.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Sierra and Yukon 4WD: replace every 45,000 miles. Use GM Auto-Trak II for active 4WD; GM 9986115 for selectable 4WD.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Differential Fluid (front + rear)

Every 50,000 mi

Replace front and rear axle fluid every 50,000 miles, or 25,000 miles if towing. G80 limited-slip rear axles require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on the L83/L84 5.3L and L86/L87 6.2L V8 are rated 100,000 miles. AFM/DFM cylinder deactivation can cause uneven plug wear — check at 75,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000. Duramax diesel uses ELC (red) — different chemistry, do not mix.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace cabin air filter every 22,500 miles. Sierra HD and Yukon XL owners in dusty work environments should replace at 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

63 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

2

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2018 Gmc Sierra 2500 reflects GMC's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →