Wrench.Pro

2019 Gmc Sierra 2500 Recalls, Issues & Maintenance

The 2019 Gmc Sierra 2500 carries 7 open NHTSA recalls — most recently covering engine block heater and engine. Owners report 5 recurring issue clusters, led by “Recall 21V496000 remedy part unavailability.” GMC trucks and SUVs use the GM Oil Life System (OLS) — the same algorithm as Chevrolet. Because GMC's lineup is exclusively trucks and SUVs, severe-service intervals apply to most owners (towing, hauling, off-roading). The schedule below surfaces the items most relevant to GMC's truck-focused buyer.

7 Open Recalls

Source: NHTSA

EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER

Campaign #21V496000 · Jan 7, 2021

Issue: General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500 and 2017-2019 GMC Sierra 2500 and 3500 vehicles equipped with a Duramax diesel 6.6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.

Risk: An electrical short-circuit can increase the risk of a fire.

Fix: Dealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heaters and cords under a separate customer satisfaction campaign. For vehicles previously included in recall 19V-328, the heater cord will be replaced and rerouted, free of charge. Interim owner notifications were mailed on August 13, 2021. Owner notification letters are expected to be mailed on April 4, 2022. Customers may call GMC customer service at 1-800-462-8782. GM's number for this recall is 212329840.

ENGINE

Campaign #19V328000 · Apr 25, 2019

Issue: General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.

Risk: A short-circuit may damage the engine components and increase the risk of fire.

Fix: GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.

FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

Campaign #23V047000 · Feb 2, 2023

Issue: General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.

Risk: An engine stall increases the risk of a crash.

Fix: Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030.

AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR

Campaign #24V756000 · Oct 10, 2024

Issue: General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2018-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 Crew Cab trucks. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

Risk: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Fix: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC Customer Service at 888-988-7267. GM's number for this recall is N242474500.

AIR BAGS

Campaign #25V432000 · Jun 26, 2025

Issue: General Motors (GM) is recalling certain 2018 GMC Sierra 1500, 2019 Sierra 2500, 3500, Chevrolet Silverado 3500, and Chevrolet Silverado 2500 and 2018 Chevrolet Silverado 1500 Crew Cab vehicles. The left or right-side roof-rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

Risk: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increases the risk of injury or crash.

Fix: Dealers will replace the left and right side RRAB modules, free of charge. Owner notification letters were mailed July 23, 2025. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252513060.

AIR BAGS

Campaign #26V166000 · Mar 19, 2026

Issue: General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2019 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 Crew Cab vehicles. The left or right-side roof rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

Risk: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increasing the risk of injury.

Fix: Dealers will replace the left and right-side RRAB modules, free of charge. Owner notification letters were mailed April 16, 2026. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262549710. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.

AIR BAGS

Campaign #26V325000 · May 21, 2026

Issue: General Motors, LLC (GM) is recalling certain 2018 Chevrolet Silverado 1500, GMC Sierra 1500, 2019 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500, and Sierra 3500 vehicles. The left-side or right-side roof rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

Risk: A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increasing the risk of injury.

Fix: Dealers will replace both RRAB modules, free of charge. Owner notification letters were mailed June 24, 2026. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262557310. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 21, 2026. This recall expands previous NHTSA recall number 26V166.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2019 Gmc Sierra 2500.

Reported to NHTSA

Recall 21V496000 remedy part unavailability

EQUIPMENT

4 NHTSA complaints · 2021-08 → 2023-03

“The contact owns a 2019 GMC Sierra 2500. The contact received notification of NHTSA Campaign Number: 21V496000 (Equipment); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a”
— Owner report, NHTSA ODI #11513282
“The contact owns a 2019 GMC Sierra 2500. The contact stated while stationary at a traffic light, he started to smell diesel fumes inside the cabin of the vehicle. The contact stated no warning light was illuminated. The contact was able to drive to his residence and while”
— Owner report, NHTSA ODI #11433049
“The contact owns a 2019 GMC Sierra 2500. The contact stated while driving 45 MPH, the stabilitrak stopped functioning properly. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing to reset the”
— Owner report, NHTSA ODI #11479903

Read all complaints on NHTSA →

Tire tread separation at highway speed

TIRES

2 NHTSA complaints · 2020-11 → 2022-08

“Tire size LT265/60R20. Left rear tire separated while driving at highway speed. Stopped along the freeway after feeling vibration not associated with road. This is the second separated tire on the same vehicle. First tire, the right rear, separated driving at highway speed 1”
— Owner report, NHTSA ODI #11480814
“TIRE IS SEPERATING AND CUPPING. YATES GMC REFUSES TO REPLACE, THEY ARE FACTORY TIRES WITH 21034 MILES ON THEM. ONLY ONE TIRE IS DOING THIS AND THEY SAY VEHICLE IS NOT TO BLAME”
— Owner report, NHTSA ODI #11375123

Read all complaints on NHTSA →

Fuel pump failure causing loss of motive power

FUEL SYSTEM, DIESEL

5 NHTSA complaints · 2023-02 → 2026-02

“The contact owns a 2019 GMC Sierra 2500. The contact stated while driving 10 MPH, the vehicle lost motive power and stalled and shut off independently. The vehicle was towed to a dealer and was diagnosed, and it was determined that the fuel pump control module needed to be”
— Owner report, NHTSA ODI #11619152
“The Fuel pump power control module failed. The part is currently at the nearby Chevy dealership. The safety of myself and two passengers were compromised when the struck suddenly lost acceleration, then shortly after lost engine idle”
— Owner report, NHTSA ODI #11610916
“The connectors to the fuel pump have failed causing the truck to mechanically fail and not operate. This is a common problem per the diesel technician who diagnosed our truck and in his opinion should not be happening as often as it does. It’s specifically the cylinder 4”
— Owner report, NHTSA ODI #11507696

Read all complaints on NHTSA →

Vehicle fire originating from electrical system

ELECTRICAL SYSTEM

3 NHTSA complaints · 2024-06 → 2026-07

“On 07/10/2026 at approximately 1:10 a.m., the parked and unoccupied vehicle caught fire while turned off. The vehicle had not been driven for several hours. A neighbor was awakened by the horn/alarm and popping noises, observed fire near the passenger-side cab/engine area, and”
— Owner report, NHTSA ODI #11752275
“My center console wires for the charging pad broke and shorted out causing wires to burn and short the whole system out”
— Owner report, NHTSA ODI #11702171
“Vehicle was last driven on June 23 2024 and parked in my driveway. On the evening of June 29 2024 my horn was blowing in my truck at around 10:30. While I was walking out to the vehicle it was in flames. The fire started from what I understand on the driver’s side behind the”
— Owner report, NHTSA ODI #11597612

Read all complaints on NHTSA →

Trailer brake system switch failure

ELECTRICAL SYSTEM, SERVICE BRAKES

3 NHTSA complaints · 2022-10 → 2023-07

“DEFECTIVE TRAILER BRAKE SWITCH ,WHICH POSES A RISK TO MOTOR VEHICLE SAFETY IF YOU ARE TOWING A TRAVEL TRAILER, WHERE BRAKES FAIL LOCK UP IS POSSIBLE DANGEROUS TO PULL”
— Owner report, NHTSA ODI #11533680
“TRAILER BRAKE SYSTEM NEEDS SERVICE, WARNING LIGHT CAME ON AND BEEPING LOUD STARTER LAST MONTH 6-2023 , AND MAYBE THE BRAKE CONTROL MODULE IS BAD ? CODE C1117 CAME UP”
— Owner report, NHTSA ODI #11532294
“I purchased a 2019 GMC Certified 2500 Diesel Truck with 48000 miles I started getting alerts on my dash stating TRAILER BRAKE SYSTEM over and over. I would press the dismiss button but it would not stop from appearing and dinging over and over. I took vehicle to dealer ship”
— Owner report, NHTSA ODI #11490822

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when OLS reaches 0% or every 12 months. dexos1-approved synthetic required on Sierra 1500 5.3L/6.2L; dexos2 specified on Duramax diesel.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Sierra and Yukon owners running 4x4 should rotate every 5,000-7,500 miles to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, and parking brake every 7,500 miles. Towing accelerates pad wear by 30-50%; check more often if towing regularly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

DOT 3 brake fluid: test annually, replace when moisture exceeds 3% or fluid is darker than copper.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

Long-life cellulose filter rated 45,000 miles. Trucks driven on unpaved roads or construction sites should inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (towing 5,000+ lbs regularly, heavy stop-and-go): every 45,000 miles. Normal: 97,500 miles. Use Dexron-VI for 6L80/6L90, Mobil 1 LV ATF HP for 10L80/10L1000.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Sierra and Yukon 4WD: replace every 45,000 miles. Use GM Auto-Trak II for active 4WD; GM 9986115 for selectable 4WD.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Differential Fluid (front + rear)

Every 50,000 mi

Replace front and rear axle fluid every 50,000 miles, or 25,000 miles if towing. G80 limited-slip rear axles require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on the L83/L84 5.3L and L86/L87 6.2L V8 are rated 100,000 miles. AFM/DFM cylinder deactivation can cause uneven plug wear — check at 75,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000. Duramax diesel uses ELC (red) — different chemistry, do not mix.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace cabin air filter every 22,500 miles. Sierra HD and Yukon XL owners in dusty work environments should replace at 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

48 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

3

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2019 Gmc Sierra 2500 reflects GMC's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →