The 2019 Ford Transit Connect carries 8 open NHTSA recalls — most recently covering inflator module and cooling system. Owners report 4 recurring issue clusters, led by “Transmission failure and hard shifting.” Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Campaign #20V791000 · Dec 17, 2020
Issue: Ford Motor Company (Ford) is recalling certain 2020 EcoSport and 2019-2020 Transit Connect vehicles. Depending on the model, either the driver side or passenger side frontal air bag modules are missing the first-stage booster propellant and sleeve. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk: Air bag modules missing the first-stage booster propellant will not deploy as intended in a crash, increasing the risk of injury.
Fix: Ford will notify owners, and dealers will replace the affected air bag module on either the driver or passenger side, free of charge. This recall began February 18, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C26.
ENGINE AND ENGINE COOLING:COOLING SYSTEM
Campaign #20V636000 · Oct 15, 2020
Issue: Ford Motor Company (Ford) is recalling certain 2019-2020 Transit Connect vehicles equipped with 2.5L engines. The powertrain control module (PCM) software has fail-safe temperature threshold values higher than intended for the engine. This may delay the fail-safe cooling strategy in the event of coolant loss and result in engine overheating.
Risk: If the engine overheats, it can result in engine damage and increase the risk of a fire.
Fix: Ford will notify owners, and dealers will update the PCM software, free of charge. The recall began November 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S60.
POWER TRAIN:AUTOMATIC TRANSMISSION
Campaign #20V550000 · Oct 9, 2020
Issue: Ford Motor Company (Ford) is recalling certain 2019-2020 Edge, Transit Connect and Lincoln MKX and 2020 Escape and Lincoln Corsair vehicles. The start/stop accumulator endcap may have missing or loose bolts.
Risk: Missing or loose bolts on the start stop accumulator endcap could result in a transmission fluid leak and may progress to a loss of transmission function. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.
Fix: Ford will notify owners, and dealers will replace the start/stop accumulator, free of charge. The recall began September 23, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S49.
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Campaign #21V376000 · May 24, 2021
Issue: Ford Motor Company (Ford) is recalling certain 2013-2021 Transit Connect vehicles equipped with 2.5L engines. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Risk: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, causing the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Fix: Dealers will replace the underhood shifter cable bushing, and add a protective cap, free of charge. Owner notification letters were mailed on June 29, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S24.
POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)
Campaign #22V413000 · Oct 6, 2022
Issue: Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Risk: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Fix: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
VISIBILITY:FIXED PANARAMIC ROOF/SKY LIGHT ASSEMBLY
Campaign #24V294000 · Apr 26, 2024
Issue: Ford Motor Company (Ford) is recalling certain 2017-2019 Transit Connect vehicles. An improper bond may exist between the panoramic roof and the vehicle body, which can result in the panel detaching from the vehicle.
Risk: A roof panel that detaches while driving can create a road hazard and increase the risk of a crash.
Fix: Dealers will remove, clean, and reinstall the panoramic roof panel, free of charge. Owner notification letters were mailed June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S29.
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Campaign #25V196000 · Mar 28, 2025
Issue: Ford Motor Company (Ford) is recalling certain 2019-2020 Transit Connect vehicles previously repaired incorrectly under recall number 20V-636. The powertrain control module (PCM) software has fail-safe temperature threshold values higher than intended for the engine. This may delay engine cooling and result in engine overheating.
Risk: An engine that overheats increases the risk of a fire.
Fix: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 21, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S32.
BACK OVER PREVENTION:SOFTWARE
Campaign #25V442000 · Jun 27, 2025
Issue: Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Fix: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
What drivers and federal regulators have officially reported about the 2019 Ford Transit Connect.
POWER TRAIN
23 NHTSA complaints · 2021-04 → 2026-06
“Catastrophic failure of the transmission”
“Transmission failure after all known transmission recalls were repaired”
“Transmission Issues sometimes vehicle rolls back. Not in gear hesitates at high speeds”
BACK OVER PREVENTION
4 NHTSA complaints · 2022-03 → 2026-05
“Description of Defect: When the vehicle is shifted into reverse, the rearview camera display freezes for several seconds before going black”
“The contact owns a 2019 Ford Transit Connect. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available”
VISIBILITY
2 NHTSA complaints · 2022-05 → 2025-02
“The contact owns a 2019 Ford Transit Connect. The contact stated that while driving at an undisclosed speed, wind noises were heard coming from the front windshield”
“During a rainy day, I had water coming in from around the top driver's side windshield and from the inside light above the dash”
SERVICE BRAKES
16 NHTSA complaints · 2020-05 → 2026-05
“Brakes locked up while car was in motion and brake pedal was not depressed. Smoke came from brakes. Happened with front and rear brakes. Able to stop and restart vehicle and move it off roadway”
“The vehicle has only been driven for 24K miles and there was an issue with the ABS Hydraulic Control Unit (HCU) and the recommendation is for it to be completely replaced”
“The contact owns a 2019 Ford Transit Connect. The contact stated that while her son was driving approximately 65 MPH, the braking system erroneously activated causing the vehicle to suddenly decelerate”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Replace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Ford specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
Replace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Ford 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
F-150 4x4 and Bronco 4x4: replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
F-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Iridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Motorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Extends the life of your vehicle and improves comfort
Replace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
3 crashes 2010–2024
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
2
complaints mentioning a crash
0
complaints mentioning a fire
Reviewed known issues for this vehicle·Open recalls for this vehicle
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2019 Ford Transit Connect reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.