Wrench.Pro

2020 Ford Transit Connect Recalls, Issues & Maintenance

The 2020 Ford Transit Connect carries 8 open NHTSA recalls — most recently covering inflator module and cooling system. Owners report 4 recurring issue clusters, led by “Transmission failure requiring replacement.” Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.

8 Open Recalls

Source: NHTSA

AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

Campaign #20V791000 · Dec 17, 2020

Issue: Ford Motor Company (Ford) is recalling certain 2020 EcoSport and 2019-2020 Transit Connect vehicles. Depending on the model, either the driver side or passenger side frontal air bag modules are missing the first-stage booster propellant and sleeve. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Air bag modules missing the first-stage booster propellant will not deploy as intended in a crash, increasing the risk of injury.

Fix: Ford will notify owners, and dealers will replace the affected air bag module on either the driver or passenger side, free of charge. This recall began February 18, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C26.

ENGINE AND ENGINE COOLING:COOLING SYSTEM

Campaign #20V636000 · Oct 15, 2020

Issue: Ford Motor Company (Ford) is recalling certain 2019-2020 Transit Connect vehicles equipped with 2.5L engines. The powertrain control module (PCM) software has fail-safe temperature threshold values higher than intended for the engine. This may delay the fail-safe cooling strategy in the event of coolant loss and result in engine overheating.

Risk: If the engine overheats, it can result in engine damage and increase the risk of a fire.

Fix: Ford will notify owners, and dealers will update the PCM software, free of charge. The recall began November 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S60.

POWER TRAIN:AUTOMATIC TRANSMISSION

Campaign #20V550000 · Oct 9, 2020

Issue: Ford Motor Company (Ford) is recalling certain 2019-2020 Edge, Transit Connect and Lincoln MKX and 2020 Escape and Lincoln Corsair vehicles. The start/stop accumulator endcap may have missing or loose bolts.

Risk: Missing or loose bolts on the start stop accumulator endcap could result in a transmission fluid leak and may progress to a loss of transmission function. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.

Fix: Ford will notify owners, and dealers will replace the start/stop accumulator, free of charge. The recall began September 23, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S49.

POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

Campaign #21V376000 · May 24, 2021

Issue: Ford Motor Company (Ford) is recalling certain 2013-2021 Transit Connect vehicles equipped with 2.5L engines. The bushing that attaches the shifter cable to the transmission may degrade or detach.

Risk: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, causing the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.

Fix: Dealers will replace the underhood shifter cable bushing, and add a protective cap, free of charge. Owner notification letters were mailed on June 29, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S24.

VISIBILITY:WINDSHIELD

Campaign #22V192000 · Mar 25, 2022

Issue: Ford Motor Company (Ford) is recalling certain 2016 and 2020 Transit Connect vehicles. The front windshield may have been manufactured with inadequate adhesion to the vehicle body structure.

Risk: During a crash, the windshield may detach from the vehicle, increasing the risk of injury.

Fix: Dealers will inspect the windshield and, if necessary, remove and reinstall the windshield, free of charge. Owner notification letters were mailed on May 11, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S20.

POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

Campaign #22V413000 · Oct 6, 2022

Issue: Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.

Risk: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.

Fix: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Campaign #25V196000 · Mar 28, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2019-2020 Transit Connect vehicles previously repaired incorrectly under recall number 20V-636. The powertrain control module (PCM) software has fail-safe temperature threshold values higher than intended for the engine. This may delay engine cooling and result in engine overheating.

Risk: An engine that overheats increases the risk of a fire.

Fix: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 21, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S32.

BACK OVER PREVENTION:SOFTWARE

Campaign #25V442000 · Jun 27, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Fix: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2020 Ford Transit Connect.

Reported to NHTSA

Transmission failure requiring replacement

POWER TRAIN

11 NHTSA complaints · 2020-03 → 2025-10

“Transmission failure in my 2.0L Ford Transit Connect at approximately 94,000 miles. When I shift into reverse, the van sometimes drives forward instead of backing up — as if the transmission is confused or stuck in the wrong gear”
— Owner report, NHTSA ODI #11674837
“My 8F35 transmission failed at 95,000 miles, a new unit was put in and that transmission failed at about 175,000 miles, a new transmission was not put in for replacement, but was rebuilt by Ford and currently I have 185,000 miles and as I slow down the transmission starts to”
— Owner report, NHTSA ODI #11668747
“FAILURE WITH THE TRANSMISSION WITH ONLY 8000 MILES”
— Owner report, NHTSA ODI #11317230

Read all complaints on NHTSA →

ABS module failure and brake lockup

SERVICE BRAKES

6 NHTSA complaints · 2024-05 → 2026-04

“ABS Hydraulic control unit pump malfunction. vehicles brakes locked up on the highway and could of caused an accident. this is a known and common issue with these vans. this type of thing shouldnt happen my vehicle has only has 67,000 miles on it”
— Owner report, NHTSA ODI #11734688
“At highway speeds (55-70), light brake pressure resulted in major frontend vibration and front left caliper seized. After pulling off the road, the front left wheel rim was too hot to touch”
— Owner report, NHTSA ODI #11618910
“The left front wheel locked up. The dealership first replaced the brake line. When that didn’t repair the problem they said they’d need to replace the ABS Module. The vehicle has less than 30,000 miles”
— Owner report, NHTSA ODI #11641040

Read all complaints on NHTSA →

Windshield adhesive water leak

VISIBILITY

6 NHTSA complaints · 2023-02 → 2026-05

“The contact owns a 2020 Ford Transit Connect. The contact stated that while driving in a rainstorm, rainwater poured into the vehicle from the front passenger’s side windshield”
— Owner report, NHTSA ODI #11731905
“The contact owns a 2020 Ford Transit Connect. The contact stated that while the vehicle was parked, there was condensation leaking from the top of the windshield. The vehicle was not diagnosed or repaired”
— Owner report, NHTSA ODI #11626921
“The contact owns a 2020 Ford Transit Connect. The contact stated that the windshield was leaking. The vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 22V192000 (Visibility) but the vehicle was not repaired”
— Owner report, NHTSA ODI #11506041

Read all complaints on NHTSA →

Pre-Collision Assist warning and transmission hesitation

VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE

3 NHTSA complaints · 2020-08 → 2022-09

“The contact owns a 2020 Ford Transit Connect. The contact stated while driving 20-30 MPH, the message "Pro-Collision Assistant is Unable" was displayed. The accelerator pedal was depressed but the vehicle jerked and hesitated to respond”
— Owner report, NHTSA ODI #11483077
“ON TWO DIFFERENT OCCASIONS THE DASH INDICATOR STATED AS FOLLOWS: "PRE-COLLISION ASSIST NOT AVAILABLE". WHEN THIS ERROR MESSAGE APPEARS, THE CAR DOES NOT ACCELERATE PROPERLY”
— Owner report, NHTSA ODI #11384813
“WHEN WE TOOK ON THE ROAD WITH AROUND 30MILES SPEED 10MINUTES AFTER WE LEFT, SUDDENLY A WARNING MESSAGE CAME UP SAID THAT "PRE-COLLISION ASSIST NOT AVAILABLE". AS WE SAW THE MESSAGE WE HAD NEVER SEEN BEFORE, WE SLIGHTLY REDUCED A SPEED BELOW 25MILES AND KEPT DRIVING”
— Owner report, NHTSA ODI #11342857

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 7,500 mi

Replace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 10,000 mi

Rotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

Ford specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 150,000 mi

Ford 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD models)

Every 60,000 mi

F-150 4x4 and Bronco 4x4: replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Rear Differential Fluid

Every 100,000 mi

F-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Coolant

Every 50,000 mi

Motorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

6 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

2

complaints mentioning a crash

2

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2020 Ford Transit Connect reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →