Wrench.Pro

2019 Toyota Tacoma Recalls, Issues & Maintenance

The 2019 Toyota Tacoma carries 4 open NHTSA recalls — most recently covering fuel pump. Owners report 8 recurring issue clusters, led by “Vibration while braking at low speeds.” Toyota's owner's manual splits service into Schedule 1 (severe) and Schedule 2 (normal). Most US drivers fall under Schedule 1 because it covers short trips, extreme temperatures, dusty roads, or heavy idling. The intervals below reflect Schedule 1 — the schedule Toyota recommends for typical real-world use.

4 Open Recalls

Source: NHTSA

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Campaign #20V682000 · Apr 11, 2020

Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Risk: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

Fix: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Campaign #20V012000 · Jan 13, 2020

Issue: Toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and certain Lexus NX 300, and ES 350 vehicles on January 13, 2020. On March 4, 2020, Toyota expanded the recall to include certain 2014-2015 Toyota 4Runner and Land Cruiser, 2018 Avalon, Corolla, 2014 FJ Cruiser, 2017 Sienna and Lexus 2018 ES 350, 2018-2019 GS 300, 2013-2014 GS350, 2014-2015 GX 460, IS 350 and LX 570, 2014 IS F, 2018-2019 IS 350, LC 500H and LS 500H, 2013-2015 LS 460, 2015 NX 200T and RC350, 2017 RC 200T and RX 350. Toyota also removed the 2018-2019 Toyota 4Runner and Land Cruiser and 2018-2019 Lexus GX 460 and LX 570 and 2019 NX300 from inclusion in this recall. On March 19, 2020, Toyota expanded the recall to include 2015 Lexus GS350 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

Risk: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

Fix: Toyota will notify owners, and dealers will replace the fuel pump, free of charge. The recall began May 4, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are 20TB02 and 20TA02 for Toyota vehicles and 20LB01 and 20LA01 for Lexus vehicles.

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Campaign #18V888000 · Dec 13, 2018

Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 Toyota Tacoma vehicles. Improper machining of the brake master cylinder may result in internal damage of one of the seals, affecting brake performance.

Risk: Reduced brake performance can lengthen the distance needed to stop the vehicle, increasing the risk of a crash.

Fix: Toyota will notify owners, and dealers will replace the brake master cylinder, free of charge. The recall began January 28, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall are J16/J06.

EQUIPMENT:OTHER:LABELS

Campaign #19V244000 · Mar 27, 2019

Issue: Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Risk: If the driver cannot read the label, they may unknowingly overload the vehicle, increasing the risk of a crash.

Fix: GST will notify owners, and dealers will provide corrected load carrying capacity modification labels, free of charge. The recall began May 24, 2019. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 19R1.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2019 Toyota Tacoma.

Reported to NHTSA

Vibration while braking at low speeds

SERVICE BRAKES

12 NHTSA complaints · 2019-07 → 2022-08

“VIBRATION IN SEAT/CAB WHILE APPLYING BRAKES BETWEEN 35-15 MPH THAT WORSENS THE MORE YOU DRIVE IT. VEHICLE WAS PURCHASED BRAND NEW AND HAS 5000 MILES ON IT AND DEALER STATES NORMAL CHARACTERISTIC OF VEHICLE- NO PROBLEM FOUND”
— Owner report, NHTSA ODI #11290379
“MY 2019 TACOMA 4X4 DBL CAB SR5 HAS 22000 MILES ON IT AND HAS A HISTORY OF THE BRAKES PULSING. THE DEALER HAS REPLACED BOTH FRONT AND REAR BRAKES AT 5K AND 11K MILES, AND NOW AGAIN AT 22K MILES”
— Owner report, NHTSA ODI #11385789
“MULTIPLE OCCURANCES - 2019 TACOMA 42XXX MILES AND ON THE 3RD ISSUE OF WARPING FRONT ROTORS. VEHICLE IS HIGHWAY DRIVEN PRIMARILY AND ROTORS WARP AND CAUSE SHAKING WHILE BRAKING AT OR AROUND 3000 MILES AFTER HAVING THEM CUT OR REPLACED”
— Owner report, NHTSA ODI #11405444

Read all complaints on NHTSA →

Hesitation and lurching on acceleration

POWER TRAIN

17 NHTSA complaints · 2019-05 → 2023-12

“ACCELERATION IS OFTEN HESITANT AND JERKY. WHEN AT A COMPLETE STOP,TURNING OR DRIVING , I WILL PUSH THE GAS TO ACCELERATE BUT THE TRUCK TAKES ABOUT 2 SECONDS TO FINALLY MOVE”
— Owner report, NHTSA ODI #11323943
“THIS TACOMA SR5 IS BRAND NEW, ABOUT 4700 MILES ON IT SO FAR. NOTICING A LOT OF HESITATION BETWEEN THE 35-60 MPH. AFTER WEEKS OF TAKING THE VEHICLE BACK TO SAVANNAH TOYOTA, ITS THE TORQUE CONVERTER. THE VEHICLE HAS SLOW PICK UP AND HARD ACCELERATION FROM A STOP TO POSITION”
— Owner report, NHTSA ODI #11282410
“A COUPLE TIMES OVER THE LAST SEVERAL MONTHS, I'VE HAD PROBLEMS WITH RPMS SURGING (BETWEEN 800 & 1200) SHORTLY AFTER STARTING THE TRUCK WHEN THE VEHICLE IS COLD; BOTH WHILE IDLING IN PARK AND SHORTLY AFTER PLACING THE VEHICLE INTO D OR R”
— Owner report, NHTSA ODI #11315875

Read all complaints on NHTSA →

Steering rack fluid leak

STEERING

7 NHTSA complaints · 2020-04 → 2025-09

“Steering rack was found to be leaking fluid onto the rubber boot during the 52,000 mile oil change and general maintenance by the Toyota dealership. This leak requires the complete steering rack to be replaced for approximately $2,100”
— Owner report, NHTSA ODI #11601792
“During a repair for a tire pressure warning light the service technician noticed that my steering rack was leaking and needed to be replaced. My vehicle has 34,651 miles on it. Repair cost $1700”
— Owner report, NHTSA ODI #11499942
“The power steering fluid, when cold , is below the “low” line. Upon looking at the steering boots I noticed that both have fluid on them indicating a leak”
— Owner report, NHTSA ODI #11511406

Read all complaints on NHTSA →

Water intrusion into rear cabin from pressure vents

STRUCTURE

5 NHTSA complaints · 2019-07 → 2025-10

“The contact stated that the rear cabin pressure vent seals had deteriorated, causing rainwater to leak into the rear cabin of the vehicle. The contact stated that there was a mildew odor inside the cabin of the vehicle”
— Owner report, NHTSA ODI #11686793
“The rear cabin pressure vent leaks water into the cabin creating an unsafe vehicle to drive during rainy days”
— Owner report, NHTSA ODI #11689472
“Water leaked through the third brake light assembly into the cab roof, soaking the ceiling, seats, and carpet. This caused extensive mold growth and electrical corrosion near the control modules”
— Owner report, NHTSA ODI #11691503

Read all complaints on NHTSA →

Head unit reboots and Bluetooth disconnection

ELECTRICAL SYSTEM

9 NHTSA complaints · 2019-10 → 2021-03

“RADIO/HEAD UNIT KEEPS REBOOTING. EVEN WHEN NO BLUETOOTH IS CONNECTED”
— Owner report, NHTSA ODI #11288165
“ENTUNE RADIO/HEADUNIT (HU) REBOOT ITSELF WHILE IN A CALL. REBOOT OCCURS WHILE VEHICLE IS IN MOTION AT ANY SPEED, DURING ANY DRIVING CONDITION. AS THE HU REBOOTS, DRIVER IS UNABLE TO USE REAR-VIEW CAMERA AND ANY OTHER FEATURE DISPLAYED IN HU”
— Owner report, NHTSA ODI #11277175
“BLUETOOTH RANDOMLY DISCONNECTS DURING A PHONE CALL. HAPPENED ABOUT 5 TIMES ON MY WAY TO WORK. USED ANOTHER PHONE AND DID SAME THING”
— Owner report, NHTSA ODI #11290736

Read all complaints on NHTSA →

Low-pressure fuel pump failure with engine stalling

FUEL/PROPULSION SYSTEM

64 NHTSA complaints · 2020-01 → 2026-05

“THE FUEL PUMP ON MY TACOMA FAILED. THE TRUCK HAS STALLED AT HIGH SPEED MULTIPLE TIMES. THE TRUCK HAS FAILED TO RESTART AFTER STALLING”
— Owner report, NHTSA ODI #11352514
“Fuel pump failure at 63k miles. Check Engine light came on. P0171 code thrown. Truck began hard starting, and rough idling. Stalled on freeway, stuck at 4k RPM and would not drop. Had to pull off and restart”
— Owner report, NHTSA ODI #11476896
“low pressure fuel pump in fuel tank failed. This part was already repaired from previous recall and failed again. Error code P0087. Vehicle shuttered and stopped in traffic. Broken bits of fuel pump were left in gas tank”
— Owner report, NHTSA ODI #11736679

Read all complaints on NHTSA →

Brake master cylinder leak with pedal sinking to floor

SERVICE BRAKES

27 NHTSA complaints · 2019-08 → 2026-05

“Brakes pedal inside car was dripping brake fluid and there was a loss of power when breaking. The vehicle was taken to a Toyota dealership and they diagnosed the problem as a failure of the brake master cylinder (part # 47050-04180)”
— Owner report, NHTSA ODI #11643249
“Brake fluid leaking from master cylinder through the firewall back inside the cab and down the brake pedal.Appears it has a Defective seal in the master cylinder.Brake pedal seems harder than normal”
— Owner report, NHTSA ODI #11499885
“PUSHED ON THE BRAKES, THE PEDAL WENT TO THE FLOOR AND DID NOT STOP OR SLOW THE VEHICLE DOWN. PUMPED THE BRAKES AND WAS ABLE TO SAFELY DECELERATE, BUT NOT BEFORE ALMOST CRASHING INTO THE CAR IN FRONT OF ME”
— Owner report, NHTSA ODI #11439788

Read all complaints on NHTSA →

Engine ticking noise and cylinder damage

ENGINE

11 NHTSA complaints · 2022-02 → 2026-02

“The contact stated that while driving at an undisclosed speed, there was an abnormal clattering sound coming from the engine, with a misfire coming from the engine. The check engine warning light was illuminated”
— Owner report, NHTSA ODI #11716829
“Experienced a check engine light and took the 2019 Toyota Tacoma to the Toyota dealer where they ran diagnostic check revealing the # 1 cylinder had little to no compression due to damaged valves. Mileage at the time of failure was 59966 miles”
— Owner report, NHTSA ODI #11572698
“Engine making ticking noise, this is approximately 4000 miles after repeated engine stalls”
— Owner report, NHTSA ODI #11504747

Read all complaints on NHTSA →

Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 5,000 mi

Replace 0W-20 full-synthetic oil and filter every 5,000 miles under Schedule 1, or 10,000 miles under Schedule 2. Toyota covers the first 2 oil changes through ToyotaCare.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 5,000 mi

Rotate tires every 5,000 miles. Toyota recommends rotation at every oil change to maximize tire life on FWD and AWD models.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 5,000 mi

Inspect brake pads, rotors, and parking brake every 5,000 miles. Toyota recommends measuring pad thickness at each service.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 36 months. Critical for the integrity of the ABS, VSC, and brake assist systems.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. Earlier under Schedule 1 if driven on unpaved roads.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 60,000 mi

Toyota labels ATF as 'lifetime fill' on most automatics, but recommends inspection and replacement every 60,000 miles under severe service. Use Toyota WS or Type-IV — no substitutes.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 120,000 mi

Toyota iridium-tipped spark plugs are rated for 120,000 miles. Earlier replacement reduces fuel economy and can cause misfires on direct-injection engines.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Super Long Life Coolant (SLLC)

Every 50,000 mi

Toyota SLLC (pink): first change at 100,000 miles, then every 50,000 miles. Do not substitute green or orange coolant — it will damage the cooling system seals.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 30,000 mi

Replace the cabin air filter every 30,000 miles, sooner in dusty climates. Located behind the glove box on most Toyota and Lexus models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Serpentine / Drive Belt Inspection

Every 60,000 mi

Inspect the serpentine belt and tensioner every 60,000 miles. Toyota uses long-life EPDM belts that rarely fail before 100,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Timing Chain — No Replacement

On condition / lifetime

Toyota's 2AR-FE, 2GR-FKS, A25A-FKS, and most Toyota engines built since 2010 use a timing chain rated for the life of the engine. No scheduled replacement.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

60 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

11

complaints mentioning a crash

1

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2019 Toyota Tacoma reflects Toyota's published service intervals and the Maintenance Required Light system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →