Wrench.Pro

2020 Bmw X7 Recalls, Issues & Maintenance

The 2020 Bmw X7 carries 12 open NHTSA recalls — most recently covering rack and exterior lighting. Owners report 6 recurring issue clusters, led by “Oil pump failure due to fracturing plastic component.” BMW vehicles use Condition-Based Service (CBS) — the dashboard shows each service item with its own remaining mileage and time, calculated by sensors. The schedule below shows BMW's underlying targets. BMW Ultimate Care covers the first 3 years / 36,000 miles of factory-scheduled maintenance on most new vehicles.

12 Open Recalls

Source: NHTSA

STEERING:RACK AND PINION:RACK

Campaign #19V631000 · Aug 28, 2019

Issue: BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive40i, X5 xDrive40i, X5 M50i, X7 xDrive40i and X7 M50i vehicles. The steering rack pinion teeth may break under load, resulting in a loss of steering control.

Risk: A loss of steering control increases risk of a crash.

Fix: BMW will notify owners, and dealers will replace the steering rack, free of charge. The recall began August 21, 2019. Owners may contact BMW customer service at 1-800-525-7417.

EXTERIOR LIGHTING

Campaign #20V052000 · Jan 30, 2020

Issue: BMW of North America, LLC (BMW) is recalling certain 2020 X7 xDrive40i and X7 xDrive50i vehicles. The rear reflex reflectors may not reflect an adequate amount of light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: An inadequate amount of reflected light will decrease the vehicle's visibility to other drivers, increasing the risk of a crash.

Fix: BMW will notify owners, and dealers will replace both rear reflex reflectors, free of charge. The recall began March 30, 2020. Owners may contact BMW customer service at 1-800-525-7417.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Campaign #21V096000 · Feb 19, 2021

Issue: BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Risk: If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.

Fix: BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Campaign #19V684000 · Sep 27, 2019

Issue: BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

Risk: The lack of an image in the back-up camera display increases the risk of a crash.

Fix: BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.

EXTERIOR LIGHTING:HEADLIGHTS

Campaign #20V528000 · Jan 9, 2020

Issue: BMW of North America, LLC (BMW) is recalling certain 2020-2021 X5 sDrive40i, xDrive40i, xDrive50i, X5 M50i, X5M, X6 sDrive40i, xDrive40i, X6 M50i, X6M, X7 M50i and 2021 X5 xDrive45e vehicles. The headlamps may allow a blue light to illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: Oncoming drivers may be confused by the blue light of approaching vehicles, which could potentially increase the risk of a crash.

Fix: BMW will notify owners, and dealers will inspect the headlamps and, if necessary, replace them, free of charge. The recall began October 30, 2020. Owners may contact BMW customer service at 1-800-525-7417.

SERVICE BRAKES, HYDRAULIC

Campaign #21V062000 · Oct 2, 2021

Issue: BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.

Risk: A loss of ABS and a reduction in braking assistance can increase the risk of a crash.

Fix: BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.

POWER TRAIN:AUTOMATIC TRANSMISSION

Campaign #20V465000 · Jul 8, 2020

Issue: BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive 40i, X5 xDrive 40i and one X7 xDrive 40i vehicle. The starter motor may have an extra bolt that could potentially fall into the transmission housing and cause an engine stall.

Risk: An engine stall increases the risk of a crash.

Fix: BMW will notify owners, and dealers will inspect the starter motor for the extra bolt, removing it if necessary. Dealers will also inspect the starter for damage, and check if the bolt has fallen into the transmission housing, replacing any damaged parts as necessary. All repairs will be performed free of charge. The recall began on October 2, 2020. Owners may contact BMW customer service at 1-800-525-7417.

SUSPENSION:FRONT:CONTROL ARM

Campaign #20V678000 · Apr 11, 2020

Issue: BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive40i, xDrive40i, X5 M50i, X5M, X7 xDrive40i, X7 M50i, X6 xDrive40i, X6 M50i and X6M vehicles and 2021 X5 xDrive45e vehicles. The weld between the front axle support and the right front control arm bearing bracket may separate.

Risk: If the weld between the front axle support and the right front control arm bearing bracket separates, vehicle handling and control may be affected, increasing the risk of a crash.

Fix: BMW will notify owners, and dealers will replace the front axle support, free of charge. The recall began December 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

Campaign #22V267000 · Apr 20, 2022

Issue: BMW of North America, LLC (BMW) is recalling certain 2022 4 Series Gran Coupe (430i, 430i xDrive, M440i xDrive); 2019-2022 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M; 2021-2022 X5 xdrive45e; 2020-2022 X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6M and 2019-2023 X7 xDrive40i, X7 xDrive50i, X7 M50i, X7 xDrive60i, X7 M60i, X7M, Alpina XB7 vehicles. The roof function control unit may be programmed incorrectly, allowing the sunroof to close without the key fob present inside the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

Risk: A sunroof that closes without the key fob present inside the vehicle can increase the risk of injury.

Fix: Dealers will reprogram the roof function control unit, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact BMW customer service at 1-800-525-7417.

SEATS

Campaign #22V670000 · Jul 9, 2022

Issue: BMW of North America, LLC (BMW) is recalling certain 2019-2022 BMW X7 xDrive40i, X7 Drive50i, X7 M50i vehicles with third-row seats. One or more of the compression springs that lock the backrest may not have been installed properly, and could dislodge or detach.

Risk: In a crash, the seat backrest may not fully lock, increasing the risk of injury.

Fix: Dealers will inspect the third-row seat and, if necessary, remove and reinstall improperly installed compression springs, and reinstall any missing springs, free of charge. Owner notification letters were mailed November 4, 2022. Owners may contact BMW customer service at 1-800-525-7417.

ELECTRICAL SYSTEM:STARTER ASSEMBLY

Campaign #24V576000 · Jan 8, 2024

Issue: BMW of North America, LLC is recalling certain 2019-2020 X5, X7, 2020 3 Series Sedan, X6, 2020-2021 7 Series Sedan, 2020 8 Series Convertible, 8 Series Coupe, and 2020 8 Series Gran Coupe vehicles. Please see the recall report for the complete list of models. In the event the starter motor fails, repeated attempts to start the vehicle can cause the starter motor to overheat from an electrical overload.

Risk: A starter motor that overheats can ignite nearby combustible material in the engine compartment, increasing the risk of a fire.

Fix: Dealers will update the vehicle software, free of charge. Owner notification letters were mailed September 27, 2024. Owners may contact BMW customer service at 1-800-525-7417.

ELECTRICAL SYSTEM:STARTER ASSEMBLY

Campaign #25V644000 · Sep 25, 2025

Issue: BMW of North America, LLC (BMW) is recalling certain 2020 340I, X6, 2020-2025 840I, 2020-2022 740LI, 2019-2020 X7, and X5 vehicles. After repeated attempts, the starter motor may overheat from an electrical overload.

Risk: An overheated starter motor can ignite nearby combustible material in the engine compartment, increasing the risk of a fire.

Fix: Dealers will replace the engine starter, free of charge. This recall includes vehicles repaired under recall 24V576 and those owners will need to have their vehicle repaired again. Owner notification letters were mailed February 9, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 17, 2025.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2020 Bmw X7.

Reported to NHTSA

Oil pump failure due to fracturing plastic component

ENGINE

7 NHTSA complaints · 2025-08 → 2026-06

“I am writing to formally report a potential safety-related defect involving BMW vehicles equipped with the B58TU engine, primarily affecting model years 2019 through 2021. My vehicle experienced a sudden loss of engine oil pressure that resulted in catastrophic engine failure”
— Owner report, NHTSA ODI #11733459
“Low oil sensor continues to light up and says i am low on oil. Found out that my oil pump was the main cause of the issue. At this time I have to have the oil pump replaced”
— Owner report, NHTSA ODI #11745685
“The contact owns 2020 BMW X7. The contact stated while driving 30 MPH, the message "Oil Pump Leak Over - Get the Vehicle Towed to Local Service Dealer" was displayed”
— Owner report, NHTSA ODI #11677774

Read all complaints on NHTSA →

Transfer case and front differential failure

POWER TRAIN

11 NHTSA complaints · 2025-04 → 2026-06

“The transfer case on my 2020 BMW X7 failed and had to be replaced. Turning the vehicle became unstable as the vehicle shuttered badly. BMW confirmed the shuttering and first changed the transfer case fluid”
— Owner report, NHTSA ODI #11721850
“There is no recommended service and maintenance schedule for replacing fluids for the front differential so I thinking that this failure is due to an engineering design flaw including no recommended schedule to service the unit”
— Owner report, NHTSA ODI #11701054
“The vehicle was then towed to the dealer, where it was diagnosed and determined that the front trans-axle had disintegrated, causing the shaft to pinch and to create an 8-inch hole at the bottom of the oil pan”
— Owner report, NHTSA ODI #11697151

Read all complaints on NHTSA →

Third-row power seat entrapment

SEATS

3 NHTSA complaints · 2025-01 → 2025-12

“Third-row seat in my 2020 BMW X7 failed during normal operation and trapped my [XXX] daughter between the seatbacks”
— Owner report, NHTSA ODI #11703716
“The third-row seat malfunctioned while my child was exiting the vehicle. The powered seat began moving unexpectedly and trapped my child’s leg, and we had extreme difficulty getting the seat to release”
— Owner report, NHTSA ODI #11703170
“Third row seat malfunction sending rear seat back unlocked appearing on dash. Switch for third row seat is faulty and need to be replaced”
— Owner report, NHTSA ODI #11639667

Read all complaints on NHTSA →

Steering system malfunction while driving

STEERING

3 NHTSA complaints · 2021-04 → 2025-07

“I was driving and as I parked on my driveway a message popped up on my dash board saying " " Increased Steering efforts" then I wasn't able to move the steering wheel at all, it feel like it got locked”
— Owner report, NHTSA ODI #11677519
“The contact owns a 2020 BMW X7. The contact stated that while turning the steering wheel in either direction there was a squeaking sound coming from the steering column”
— Owner report, NHTSA ODI #11580898
“WHILE DRIVING ON THE FREEWAY AT 70MPH, MY STEERING AND BRAKE SYSTEM BECOME LESS RESPONSIVE. COULD NOT BRAKE FULLY”
— Owner report, NHTSA ODI #11406356

Read all complaints on NHTSA →

Starter motor failure causing stalling or no-start

ELECTRICAL SYSTEM

8 NHTSA complaints · 2024-10 → 2026-04

“The contact owns a 2020 BMW X7. The contact stated that while attempting to start the vehicle, the engine failed to turn over. The message "Starter Motor Overheating" was displayed; however, there was no warning light illuminated”
— Owner report, NHTSA ODI #11660517
“The contact owns a 2020 BMW X7. The contact received notification of NHTSA Campaign Number: 25V644000 (Electrical System). The contact stated that while driving at an undisclosed speed and making a left turn, the vehicle stalled in the middle of traffic”
— Owner report, NHTSA ODI #11704522
“The car just stopped in the middle of the road and wouldn’t restart. The starter is fried. I didn’t know about the starter recall”
— Owner report, NHTSA ODI #11622017

Read all complaints on NHTSA →

Unexpected vehicle fire

ENGINE

3 NHTSA complaints · 2021-11 → 2023-12

“Nov 28, 2023: Car burst into flames 5 minutes after oil change and passed multipoint inspection. Car burned completely to the ground Escaped unharmed but met with rudeness and dismissal from dealership”
— Owner report, NHTSA ODI #11561478
“On 11/23/2021 while driving the computer screen stated malfunction with personal protection device with in 10 seconds the rear of the car burst into flames the fire inspector from our insurance company traced the cause of the event to the fuse box”
— Owner report, NHTSA ODI #11460379
“The BMW X7 caught on fire going down the HW”
— Owner report, NHTSA ODI #11441886

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil Service (CBS)

Every 10,000 mi

Replace BMW Longlife-04 (LL-04) full-synthetic oil and filter every 10,000 miles or annually — whichever the CBS system signals first. M-series engines may require shorter intervals; check the vehicle-specific iDrive screen.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Brake Fluid Service (CBS)

Every 24,000 mi

Replace DOT 4 LV brake fluid every 2 years regardless of mileage. CBS triggers based on time, not miles, due to moisture absorption.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Vehicle Check / Inspection (CBS)

Every 30,000 mi

Multi-point inspection covering brakes, suspension, steering, exhaust, fluids, lighting, and underbody. CBS signals every 30,000 miles or 2 years.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free with any paid service. A flashlight and 10 minutes covers the basics yourself.

Engine Air Filter

Every 40,000 mi

Replace engine air filter every 40,000 miles. Higher-performance N55, B58, and S58 engines should be inspected at every oil service.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Spark Plugs

Every 60,000 mi

B48 (2.0L turbo) and B58 (3.0L turbo) require new spark plugs every 60,000 miles. N20/N55 engines often spec 45,000 miles. M-series typically 30,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Automatic Transmission Fluid (ZF 8HP)

Every 60,000 mi

BMW labels the ZF 8HP automatic as 'lifetime fill,' but independent transmission specialists strongly recommend replacement every 60,000 miles. Use BMW-spec ZF Lifeguard 8 — no substitutes.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Rear Differential Fluid

Every 60,000 mi

RWD and xDrive AWD: replace rear diff fluid every 60,000 miles, sooner with M-Sport or active differential. M-cars require BMW SAF-XO synthetic.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

xDrive Transfer Case Fluid

Every 60,000 mi

BMW xDrive AWD: replace transfer case fluid every 60,000 miles. Skipping this causes the most common xDrive failure — actuator stuck in 100/0 split.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Microfilter (Cabin Air Filter)

Every 30,000 mi

Replace the activated-carbon microfilter every 30,000 miles. Most BMWs have a single combined cabin/charcoal filter behind the engine bay firewall.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Engine Coolant (G48 / HT-12)

On condition / lifetime

BMW labels coolant as lifetime fill on most modern vehicles. Independent BMW specialists recommend replacement every 4-5 years to prevent water-pump and thermostat housing degradation.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

2

complaints mentioning a crash

3

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2020 Bmw X7 reflects BMW's published service intervals and the Condition-Based Service system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →