Wrench.Pro

2020 Chevrolet Malibu Recalls, Issues & Maintenance

The 2020 Chevrolet Malibu carries 1 open NHTSA recall — most recently covering critical fasteners. Owners report 5 recurring issue clusters, led by “Shift to Park message with shifter in park.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

1 Open Recall

Source: NHTSA

SEAT BELTS:CRITICAL FASTENERS

Campaign #21V649000 · Aug 20, 2021

Issue: General Motors, LLC (GM) is recalling certain 2016-2021 Chevrolet Malibu and 2019-2021 Cadillac XT4 vehicles. The rear seat belt retractors may be improperly secured with loose or missing fasteners.

Risk: An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.

Fix: Dealers will inspect and tighten the rear seat belt retractors, as necessary, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212333380.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2020 Chevrolet Malibu.

1 active NHTSA investigation

Source: NHTSA

  • DTN Air Bag Inflator Rupture

    Action #EA25005 · opened Oct 21, 2025

    The Office of Defects Investigation (ODI) has become aware of eight vehicle crashes in which a rupture of a Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN) air bag inflator occurred during the deployment of the driver side air bag. All eight drivers in these cra…

    View on NHTSA →

Reported to NHTSA

Shift to Park message with shifter in park

POWER TRAIN

63 NHTSA complaints · 2021-09 → 2026-05

“My vehicle displays a "shift to park" message on the dashboard, even when the gear selector is in the park position. This prevents the car from being shut off, and in sometimes, the doors may not be able to be locked. Not understanding the issue initially has thus caused me to…”
— Owner report, NHTSA ODI #11701454
“After pressing the button to turn the vehicle off the message board displays a "shift to park" alert. The vehicle will not completely turn off until you clear the message. I do not know how to clear the message so the vehicle will completely turn off and to keep this from…”
— Owner report, NHTSA ODI #11663888
“The contact owns a 2020 Chevrolet Malibu. The contact stated that upon parking and attempting to turn off the vehicle, the message "Shift to Park" was displayed while the gear shifter was already in park(P). The contact stated that upon shifting out of park(P) and shifting back…”
— Owner report, NHTSA ODI #11629833
“My car is displaying a "Shift to Park" message on the dashboard even when the shifter is already in the park position, preventing the vehicle from being turned off and potentially leading to a dead battery or the vehicle rolling away. The "Shift to Park" issue poses safety…”
— Owner report, NHTSA ODI #11670615

Read all complaints on NHTSA →

Brake vacuum pump failure and hard brake pedal

SERVICE BRAKES

36 NHTSA complaints · 2021-08 → 2026-05

“To Whom It May Concern, ​I am writing to formally report a critical safety defect regarding my 2020 Chevrolet Malibu. This defect resulted in a life-threatening incident while I was driving on the highway, during which my vehicle failed to stop as required. ​While operating at…”
— Owner report, NHTSA ODI #11735781
“I was driving in the interstate at about 4pm on May 16th and the check engine light came on. Thus is nothing new because since I bought the car on Feb. 14th, 2024 the check engine light is on about 75% of the time. I went to use my brakes and the pedal was hard as a rock. I had…”
— Owner report, NHTSA ODI #11663572
“Vacuum pump blew . Causing me to lose brakes on the highway. It led to a series of events. Camshaft broke in the midst of this so my car will not start again.”
— Owner report, NHTSA ODI #11698371

Read all complaints on NHTSA →

Reduced engine power and stalling

VEHICLE SPEED CONTROL

11 NHTSA complaints · 2021-07 → 2026-04

“Reduced Engine Power Light: The car limits acceleration, often accompanied by a check engine light. Stalling or Hesitation: Engine stalls or acts sluggish when accelerating, particularly in traffic. Limp Mode: The vehicle restricts speed, making it difficult to accelerate. The…”
— Owner report, NHTSA ODI #11728914
“Getting engine power reduced messsge in shop 4th time now in 3 weeks, 2 service bulletins, now they want to put new engine, found over 800 complaints about same issue on car complaint.com website and more on Reddit of same issue . Car wouldn't go more than 5mph extremely…”
— Owner report, NHTSA ODI #11673603

Read all complaints on NHTSA →

Transmission hard shifts and replacement

POWER TRAIN

12 NHTSA complaints · 2022-06 → 2026-01

“The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving at various speeds, the vehicle lost motive power and failed to accelerate while depressing the accelerator pedal properly. The vehicle was taken to the local dealer, who discovered metal debris…”
— Owner report, NHTSA ODI #11700027
“Problems with my transmission for over two years, I've searched the website and have taken it to a dealership since. The vehicle has had a hard shift and problems to accelerate. The issue continues to get worse and my car has stopped while in drive, only allowing me to go…”
— Owner report, NHTSA ODI #11701372

Read all complaints on NHTSA →

Stalling and fuel injector failure

FUEL SYSTEM, GASOLINE

19 NHTSA complaints · 2020-07 → 2026-04

“The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving approximately 35 MPH, the vehicle started losing motive power. The contact stated that the vehicle stalled, with the check engine warning light illuminated. The vehicle was towed to an independent…”
— Owner report, NHTSA ODI #11715939
“The contact owns a 2020 Chevrolet Malibu. The contact stated that while driving approximately 35 MPH, an unknown warning light illuminated, and the vehicle started to lose motive power. The contact stopped at a traffic signal and after depressing the accelerator pedal when the…”
— Owner report, NHTSA ODI #11730116

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

102 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

10

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2020 Chevrolet Malibu reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →