Wrench.Pro

2021 Chevrolet Malibu Recalls, Issues & Maintenance

The 2021 Chevrolet Malibu carries 2 open NHTSA recalls — most recently covering critical fasteners and seats. Owners report 3 recurring issue clusters, led by “Gear position sensor 'Shift to Park' false warning.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

2 Open Recalls

Source: NHTSA

SEAT BELTS:CRITICAL FASTENERS

Campaign #21V649000 · Aug 20, 2021

Issue: General Motors, LLC (GM) is recalling certain 2016-2021 Chevrolet Malibu and 2019-2021 Cadillac XT4 vehicles. The rear seat belt retractors may be improperly secured with loose or missing fasteners.

Risk: An improperly secured seat belt retractor may not function properly in a crash, increasing the risk of injury.

Fix: Dealers will inspect and tighten the rear seat belt retractors, as necessary, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020 and Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212333380.

SEATS

Campaign #22V359000 · May 19, 2022

Issue: General Motors, LLC (GM) is recalling certain 2021 Chevrolet Malibu, 2022 Chevrolet Equinox, Blazer and Cadillac XT4 vehicles. The driver's seat cushion frame may have an improper weld in the power tilt-adjustment mechanism.

Risk: An improperly welded seat frame may not adequately restrain the driver in a crash, increasing their risk of injury.

Fix: Dealers will inspect the driver's seat and replace the cushion frame, as necessary, free of charge. Owner notification letters were mailed June 23, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N212356050.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2021 Chevrolet Malibu.

Reported to NHTSA

Gear position sensor 'Shift to Park' false warning

POWER TRAIN

41 NHTSA complaints · 2023-06 → 2026-08

“Failure - B000A-00 Body Control Module Error code - Shift Lever Position not plausible . Safety - This causes the car to upon attempting to turn off the car say "Shift into Park" on the dashboard and the car refuses to turn fully off. This can cause the battery to drain”
— Owner report, NHTSA ODI #11757048
“Warning light appears on dash "Shift to Park". Car is in park. Engine will turn off, but ignition stays in accessory mode and will run down battery if ignored. Have to wiggle shifter back and forth repeatedly to get the warning light to go away and the ignition to completely…”
— Owner report, NHTSA ODI #11583570
“Took my car to the dealer for a "shift to park" problem. Vehicle would not turn off and twice it restarted itself without the button being pushed. I checked my VIN number and there was no recall regarding this but Chevy stated that they were aware of the problem since the 2018…”
— Owner report, NHTSA ODI #11691171

Read all complaints on NHTSA →

Fuel pump power control module failure and stall

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP, ELECTRICAL SYSTEM:STARTER ASSEMBLY

5 NHTSA complaints · 2025-10 → 2026-07

“The contact stated that while starting the vehicle, all the lights on the instrument panel illuminated, and the engine started to choke. The Service Vehicle light remained illuminated after the other lights turned off. The engine started choking again and failed to start. The…”
— Owner report, NHTSA ODI #11751019
“I am submitting this complaint because my vehicle, a 2021 Chevrolet Malibu (VIN [XXX] ), is included in Emission Recall N252516900 issued by General Motors concerning the Fuel Pump Power Control Module. Despite that inclusion, I have experienced the following: - A prior…”
— Owner report, NHTSA ODI #11695082
“I was driving on the highway and the check engine light came on. The car slowed down due to lack of power. I got off at the nearest exit and the car stalled. I tried to start it but it kept clicking rapidly. The car died at a dangerous intersection so I put my hazard lights on…”
— Owner report, NHTSA ODI #11724988

Read all complaints on NHTSA →

Reduced engine power and throttle body faults

ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM

5 NHTSA complaints · 2025-06 → 2026-04

“I was driving and car suddenly reduced speed,engine light came on and message came across dash “engine power reduced” and a text was sent to tell me I have a transmission issue. Now car won’t drive past 25-30mph dealership indicated this is a faulty gas pedal which cost over…”
— Owner report, NHTSA ODI #11731460
“The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the contact stated while attempting to drive from a complete stop, the vehicle hesitated while responding. The contact stated that the failure recurred several…”
— Owner report, NHTSA ODI #11673295

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

49 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

1

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2021 Chevrolet Malibu reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →