Wrench.Pro

2021 Buick Envision Recalls, Issues & Maintenance

The 2021 Buick Envision carries 2 open NHTSA recalls — most recently covering srs malfunction warning lamp/light and software. Owners report 7 recurring issue clusters, led by “Transmission slipping, lurching, and gear loss.” Buick uses the GM Oil Life System: an algorithm tracks engine revolutions and temperature, then lights the change-oil message — typically every 7,500 miles in mixed driving, capped at 12 months, using dexos-approved oil. Current Encore GX and Envista run 1.2/1.3L turbo three-cylinders where oil quality matters more than volume drivers expect (the sump is small and turbo-heated). Front-drive models pair to a CVT with a published fluid interval — it is not a lifetime part.

2 Open Recalls

Source: NHTSA

AIR BAGS:SRS MALFUNCTION WARNING LAMP/LIGHT

Campaign #21V421000 · Oct 6, 2021

Issue: General Motors, LLC (GM) is recalling certain 2021 Buick Envision, Cadillac CT4, CT5, Escalade, Escalade ESV, Chevrolet Tahoe, Corvette, Suburban, GMC Yukon, Yukon XL vehicles. The communications gateway module incorrectly processes a loss of communication with the sensing diagnostic module (SDM), causing the air bag malfunction indicator light to inconsistently illuminate.

Risk: The air bag malfunction indicator light may fail to warn the driver of a problem with the air bag, increasing the risk of injury.

Fix: The communications gateway module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on July 1, 2021. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N212338110.

EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE

Campaign #22V903000 · Aug 12, 2022

Issue: General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

Fix: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2021 Buick Envision.

Reported to NHTSA

Transmission slipping, lurching, and gear loss

POWER TRAIN

5 NHTSA complaints · 2023-08 → 2026-01

“This has happened about 4-5 times now, car has approximately 17.5k miles. While accelerating attempting to reach speed limit, transmission has slipped out of gear and power to wheels is not happening. Have learned to switch into neutral and then drive and transmission will…”
— Owner report, NHTSA ODI #11668858
“11/25/25 DRIVING AT A SLOW SPEED, THE TRANSMISION WAS IN DRIVE. THE TRANSMISSION SLIPPED OUT OF DRIVE INTO NEUTRAL. THE CAR STOP. I PUT THE CAR IN DRIVE AND CONTINUED TO THE FINAL DESTINATION”
— Owner report, NHTSA ODI #11702035
“When I start at a low speed it's like it does not know which gear to go in. You push on the gas and it does not move much and then launches forward. It has done this since I purchased it in April 2025 used”
— Owner report, NHTSA ODI #11708450

Read all complaints on NHTSA →

Fuel pump control module failure and no-start

FUEL/PROPULSION SYSTEM

6 NHTSA complaints · 2023-04 → 2025-11

“My vehicle's motor stopped without any warning in the middle lane of a busy freeway. I put the emergency flashers on but when I tried to restart the motor it overrode the flashers, causing a semi truck to just miss hitting me. The transmission went into Park mode and since this…”
— Owner report, NHTSA ODI #11522086
“Driving at 45 mph the vehicle stopped running in traffic. Able to get off road and vehicle would not start. Engine turned over but did not fire. Waited about 10 min. while on phone with dealer and tried again. It started. Able to drive approx. 2 miles to dealer. Dealer…”
— Owner report, NHTSA ODI #11516960
“Fuel pump and fuel control module failed. Car will not stay running. Currently at GM dealership. Confirmed and repair cost about $500. No warning lights”
— Owner report, NHTSA ODI #11701652

Read all complaints on NHTSA →

Electrical system faults and interior lighting

ELECTRICAL SYSTEM

3 NHTSA complaints · 2024-08 → 2024-12

“Interior light keep coming on while driving when I turn it off it comes back on”
— Owner report, NHTSA ODI #11607181
“Electircal System, Interior Lighting: Purchased car used 11/05/24. Interior rear lights come on while driving, once started they will not automatically turn off, and remain on when the vehicle is turned off. This incident is the same as NHTSA ID Number: 11607181, dated: 08/03/24”
— Owner report, NHTSA ODI #11633461
“Car shut off in middle of the highway. Couldn’t get it to start. Fortunately there was light traffic. Couldn’t get the car in neutral to push on side of road. Had it towed to a shop and it was a faulty fuel pump module. Manufacturer won’t honor warranty”
— Owner report, NHTSA ODI #11536085

Read all complaints on NHTSA →

HVAC defrost failure and window fogging

VISIBILITY/WIPER

1 NHTSA complaint · 2025-01 → 2025-01

“When driving 2021 Buick Envision, the windshield and side windows do not defrost with HVAC set to defrost mode. Service Climate system is displayed on dash. Vehicle was inspected by dealer finding replacement of HVAC case half housing required on 1/22/24 ( a year ago). GM…”
— Owner report, NHTSA ODI #11634337

Read all complaints on NHTSA →

Engine hesitation and turbo lag on acceleration

ENGINE

2 NHTSA complaints · 2023-12 → 2025-06

“When I push on the accelerator the car hesitates and then surges forward. I took the vehicle to the dealership where they recreated the problem however it was not throwing any codes. After examination they determined that the problem was turbo lag”
— Owner report, NHTSA ODI #11560207
“The contact stated that while operating the vehicle, the contact heard a popping sound coming from the front end of the vehicle, and the vehicle became difficult to steer. The vehicle was taken to the local dealer who determined that the front driver’s and passenger’s side ball…”
— Owner report, NHTSA ODI #11615453

Read all complaints on NHTSA →

Floor mat interference and unintended acceleration

EQUIPMENT:ACCESSORY:FLOOR MAT, VEHICLE SPEED CONTROL, SERVICE BRAKES

1 NHTSA complaint · 2026-02 → 2026-02

“The contact stated that while his wife was driving at an undisclosed speed on the freeway, the vehicle unintendedly accelerated around a corner, with the floor mat stuck under the pedal. The driver depressed the brake pedal for an extended time, but the vehicle continued…”
— Owner report, NHTSA ODI #11719389

Read all complaints on NHTSA →

Tire blowout and tread delamination

TIRES:TREAD/BELT

2 NHTSA complaints · 2022-09 → 2023-11

“245/45 R 20 all four tires are pitting and delaminating and the rubber is falling off. These are Continental pro contact 99 h. Mold number s-908480 and mold number s-50879”
— Owner report, NHTSA ODI #11553354
“As going down the road the tire blew out. The vehicle is new and only has 6389 miles on the vehicle. Feel there was a defect in the tire that caused this. No warning or anything came on to advise that it was low or needed attention”
— Owner report, NHTSA ODI #11485807

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Oil Life System)

Every 7,500 mi

Change when the Oil Life System calls it — typically around 7,500 miles, never beyond 12 months. dexos1 0W-20 on modern engines. Small-displacement turbos (Encore GX, Envista): don't stretch the indicator.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate every 7,500 miles with the oil change — GM pairs the two in its schedule.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, and lines at every service. Older Centurys: check rear drum adjustment and parking-brake cables, which seize with age.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

CVT Fluid (Encore GX / Envista FWD)

Every 45,000 mi

FWD Encore GX and Envista use a CVT: GM schedules fluid replacement around 45,000 miles under severe service — which includes most city commuting. AWD Encore GX uses a 9-speed automatic instead (see transmission fluid).

Estimated cost — typical U.S. ranges

Dealer

~$360–$500

Shop

~$255–$355

DIY

~$80–$180

CVT fluid is manufacturer-specific and pricey — do NOT substitute conventional ATF.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Automatic Transmission Fluid

Every 45,000 mi

Conventional automatics (Century's 4T65-E, Regal's Aisin, AWD Encore GX's 9-speed): GM lists 45,000 miles severe / longer normal. Older Buicks respond well to a simple drain-and-fill — avoid pressure flushes on high-mile units.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 60,000 mi

Small-turbo three-cylinders (Encore GX, Envista): roughly every 60,000 miles — check the manual. Older 3.1/3.8 V6s: iridium plugs last to 100,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 45,000 mi

GM schedules replacement around 45,000 miles; inspect at every oil change in dusty regions.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Serpentine Belt

Every 60,000 mi

Inspect from 60,000 miles; replace on cracking or glazing rather than mileage alone.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace roughly every 22,500 miles per GM's schedule — behind the glovebox on modern Buicks.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Coolant Replacement (Dex-Cool)

Every 150,000 mi

Dex-Cool is rated 5 years / 150,000 miles. On older 3.1/3.8 V6s, intake-gasket seepage was the classic failure — check coolant level and condition at every oil change on a Century.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Battery Test & Service

Every 25,000 mi

Test annually after year 3. Stop-start-equipped Encore GX/Envista use AGM batteries — replace like-for-like, not with a cheaper flooded battery.

Estimated cost — typical U.S. ranges

Dealer

~$225–$390

Shop

~$160–$280

DIY

~$130–$250

Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

7 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

2

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2021 Buick Envision reflects Buick's published service intervals and the GM Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →