Wrench.Pro

2022 Chevrolet Bolt Ev Recalls, Issues & Maintenance

The 2022 Chevrolet Bolt Ev carries 7 open NHTSA recalls — most recently covering frontal and traction battery. Owners report 7 recurring issue clusters, led by “High-voltage battery recall parts unavailability.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

7 Open Recalls

Source: NHTSA

AIR BAGS:FRONTAL

Campaign #21V517000 · Aug 7, 2021

Issue: General Motors, LLC. (GM) is recalling certain 2022 Chevrolet Bolt EV and Bolt EUV vehicles. One of the two fasteners that secure the driver's frontal air bag to the steering wheel may be missing or improperly tightened.

Risk: An improperly installed air bag may not deploy properly in a crash, increasing the risk of injury.

Fix: Dealers will inspect and replace as necessary, the driver-side air bag fasteners. If the fasteners cannot be tightened properly, the air bag assembly will be replaced. All repairs will be performed free of charge. Owner notification letters were mailed on July 29, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212340860.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Campaign #21V650000 · Aug 20, 2021

Issue: General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. The high voltage battery could catch fire when charged to full or nearly full capacity.

Risk: A battery fire increases the risk of injury.

Fix: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Defective battery modules will be replaced by GM, free of charge. Owner notification letters were mailed on October 1, 2021 and June 23, 2023. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. This recall is an expansion of NHTSA recall 21V-560. GM's number for this recall is N212345940.

STRUCTURE:BODY:ROOF AND PILLARS

Campaign #22V930000 · Dec 15, 2022

Issue: General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.

Risk: A vehicle fire can increase the risk of injury.

Fix: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.

AIR BAGS:FRONTAL

Campaign #23V567000 · Oct 8, 2023

Issue: General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Bolt EV vehicles. The instrument panel may be missing the perforation on the underside of the panel cover that allows the passenger-side air bag to deploy properly.

Risk: An air bag that does not deploy properly in a crash increases the risk of injury.

Fix: Dealers will replace the instrument panel, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232414710.

STRUCTURE:BODY:ROOF AND PILLARS

Campaign #23V845000 · Dec 14, 2023

Issue: General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.

Risk: A fire increases the risk of injury.

Fix: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Campaign #24V481000 · Jun 27, 2024

Issue: General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles that were previously remedied under recall number 21V-650. The advanced diagnostic software may have been incorrectly installed and fail to detect defective battery modules, possibly resulting in a battery fire.

Risk: A battery fire increases the risk of injury.

Fix: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall the advanced diagnostic software, free of charge. Owner notification letters were mailed on August 1, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's numbers for this recall are N242443000 and N242443002.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Campaign #24V812000 · Oct 31, 2024

Issue: General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Bolt EV and 2022 Bolt EUV vehicles previously repaired under Recall 21V-650. The installation of advanced diagnostic software may have failed. As such, the high voltage battery could catch fire when charged to full or nearly full capacity.

Risk: A battery fire increases the risk of injury.

Fix: Owners are advised to take the following interim steps: Set the Target Charge Level feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Dealers will reinstall advanced diagnostic software, free of charge. Owner notification letters were mailed December 3, 2024. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N242470160.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2022 Chevrolet Bolt Ev.

Reported to NHTSA

High-voltage battery recall parts unavailability

ELECTRICAL SYSTEM

16 NHTSA complaints · 2021-09 → 2025-08

“The contact owns a 2022 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V650000 (Electrical system) however, the part to do the recall repair was not available. The contact stated that the recall instructions to set the high-voltage battery”
— Owner report, NHTSA ODI #11433698
“I am filing this complaint regarding my 2022 Chevrolet Bolt, which has been awaiting battery replacement at McCluskey Chevrolet for over 30 days, creating significant safety concerns and violating federal warranty requirements. Safety Concerns: The vehicle's safety systems”
— Owner report, NHTSA ODI #11683726

Read all complaints on NHTSA →

Sudden propulsion loss and speed reduction at highway speed

FUEL/PROPULSION SYSTEM, POWER TRAIN, VEHICLE SPEED CONTROL

7 NHTSA complaints · 2022-09 → 2026-01

“I was driving on the highway above 60 mph, and I suddenly got a "propulsion power reduced" alert, along with a yellow indicator light. I almost immediately thereafter got a message saying "speed reduced to 50 mph" and then "speed reduced to 30 mph." I got no acceleration when I…”
— Owner report, NHTSA ODI #11710387
“The contact owns a 2022 Chevrolet Bolt EV. The contact stated that while his wife was driving 70 MPH, the vehicle inadvertently decelerated to 30 MPH with the transmission warning light and three other unknown warning lights illuminated. The failure nearly caused a collision”
— Owner report, NHTSA ODI #11493485

Read all complaints on NHTSA →

Transmission shift lock and inability to move vehicle

POWER TRAIN, ELECTRICAL SYSTEM

7 NHTSA complaints · 2022-09 → 2023-10

“Complete transmission failure shortly after seeing "Service Transmission" message in 2022 Chevy Bolt EV Drivers Information Center. When message first appeared selected option to dismiss message and continued to drive as normal. After turning vehicle off and then back on the…”
— Owner report, NHTSA ODI #11542304
“As I was driving I felt the Chevrolet Bolt stutter twice, as if it was loosing power. Then, when I stopped at the stop light at Purcell and Hoadly the car shifted into park and would not shift into any other gear, including neutral. Any attempts to shift would give an error…”
— Owner report, NHTSA ODI #11488609

Read all complaints on NHTSA →

Electric power steering failure and lockup

STEERING

4 NHTSA complaints · 2023-12 → 2026-06

“2022 Chevy Bolt, less than 10,000 miles. Problem began 11/24/23. Steering wheel locks up at low speeds, gives warning "Steering Assistance reduced" at higher speeds. At low speeds, steering wheel turns only a small amount before it clicks and stops. Very dangerous in tight…”
— Owner report, NHTSA ODI #11560134
“I have a faulty electric power steering, it prevents the steering wheel to return to center”
— Owner report, NHTSA ODI #11716390

Read all complaints on NHTSA →

Unintended automatic braking activation while driving

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, SERVICE BRAKES, ELECTRICAL SYSTEM

3 NHTSA complaints · 2023-12 → 2024-02

“About 1 month ago I picked up my daughter from school. Just as we exited the parking lot, there was nothing in front and the brakes came on and the car turned off and would not restart for a few minutes. The same day, we were on the way home I was traveling about 35mph. All of…”
— Owner report, NHTSA ODI #11562166
“I was driving 72 mph, and went to accelerate to 75 mph to set my cruise control. As soon as I stepped on the accelerator pedal, my 2022 Chevy Bolt EUV jerked violently and immediately applied braking to car to take it from 72 mph to about 30 mph within 1 second. Had someone…”
— Owner report, NHTSA ODI #11569705

Read all complaints on NHTSA →

Brake light placement and rear visibility

EXTERIOR LIGHTING

2 NHTSA complaints · 2022-11 → 2023-01

“The car was changed for 2022 where the brake lights are no longed displayed with the tail lights and instead lower down in the bumper area on small lights. Cars following me do not notice these lights and end up almost hitting me. The dealer states that this is how GM has…”
— Owner report, NHTSA ODI #11494379
“While braking I have had multiple cars almost crash into the rear of my vehicle due to the breaking system of the vehicle. The break lights are too low and people expect the “running lights” on the rear to indicate breaking. I have also had multiple people tell me my break…”
— Owner report, NHTSA ODI #11504229

Read all complaints on NHTSA →

Front lower ball joint failure and suspension collapse

POWER TRAIN, STEERING, SUSPENSION

1 NHTSA complaint · 2026-04 → 2026-04

“While driving at a low speed (approx. 5–10 mph), the front passenger-side lower ball joint suffered a catastrophic structural shear without warning. This caused the wheel assembly to collapse outward and the CV axle to pull out of the transmission. The failure caused a complete…”
— Owner report, NHTSA ODI #11733483

Read all complaints on NHTSA →

Note: NHTSA also opened 1 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

5 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

3

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2022 Chevrolet Bolt Ev reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →