Wrench.Pro

2022 Chevrolet Suburban Recalls, Issues & Maintenance

The 2022 Chevrolet Suburban carries 4 open NHTSA recalls — most recently covering critical fasteners and software. Owners report 6 recurring issue clusters, led by “Transmission control valve body failure / limp mode.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

4 Open Recalls

Source: NHTSA

SEAT BELTS:CRITICAL FASTENERS

Campaign #22V617000 · Nov 8, 2022

Issue: General Motors, LLC (M) is recalling certain 2021-2022 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL vehicles equipped with third-row seats. The rivet that retains the buckle to the mounting bracket in the left or right side third-row seat belt buckle assembly may have been improperly formed.

Risk: A seat belt with a deformed rivet may not properly restrain an occupant, increasing the risk of injury during a crash.

Fix: Dealers will inspect the rivet head formation on both the left and right side third-row seat belt buckle assemblies and replace seat belt buckle assemblies, as necessary, free of charge. Interim owner notification letters informing owners of the safety risk were mailed September 28, 2022. Owner notification letters were mailed on November 1, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N222372380.

EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE

Campaign #22V903000 · Aug 12, 2022

Issue: General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

Fix: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.

ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL

Campaign #25V274000 · Apr 24, 2025

Issue: General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

Risk: Engine failure increases the risk of a crash.

Fix: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE

Campaign #26V085000 · Feb 13, 2026

Issue: General Motors, LLC (GM) is recalling certain 2022 Chevrolet Tahoe, Chevrolet Suburban, GMC Yukon, GMC Yukon XL, Cadillac Escalade, and Cadillac Escalade ESV vehicles equipped with 10 Speed Transmission with ETRS (Electronic Transmission Range Select). The transmission control valve may fail and lock up the rear wheels.

Risk: Rear wheels that lock up while driving increase the risk of a crash.

Fix: Dealers will install new transmission control module (TCM) software, free of charge. Owner notification letters were mailed April 7, 2026. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252536750. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2022 Chevrolet Suburban.

2 active NHTSA investigations

Source: NHTSA

  • Loss of motive power due to engine failure

    Action #EA25007 · opened Oct 23, 2025

    The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Year…

    View on NHTSA →

  • Loss of motive power due to engine failure post recall remedy

    Action #EA26005 · opened Aug 20, 2026

    On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001.  This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been comple…

    View on NHTSA →

Reported to NHTSA

Transmission control valve body failure / limp mode

POWER TRAIN

14 NHTSA complaints · 2024-11-18 → 2026-06-30

“While driving, the check engine light illuminated and the vehicle suddenly entered limp mode. The transmission lost normal operation, including reverse gear, significantly limiting the vehicle’s ability to operate. The failure occurred without warning”
— Owner report, NHTSA ODI #11747576
“On 12/28/2024, while accelerating on the highway, I received without warning a reduced engine power warning and the RPM's were racing when I depressed the gas pedal. I was in moderate traffic in excess of 55 MPH and had difficulty safely making it to the right shoulder”
— Owner report, NHTSA ODI #11636621

Read all complaints on NHTSA →

Fuel pump control module failure / engine stall

FUEL/PROPULSION SYSTEM

6 NHTSA complaints · 2023-12-18 → 2026-01-26

“Engine lost power and stalled without warning while driving down the highway. Coasted to side of road and was unable to restart engine. After engine stopped, dash indicated low fuel, although tank was 3/4 full. After coming to a stop, was unable to shift out of Park”
— Owner report, NHTSA ODI #11662679
“Without warning, vehicle stalled/ stop while traveling at highway speed, leaving us seconds to maneuver to the side. This failure created an extremely dangerous situation that could have resulted catastrophic or fatal accident for my family. Check engine light came on (code…”
— Owner report, NHTSA ODI #11713362

Read all complaints on NHTSA →

Telematics / OnStar module failure after software update

ELECTRICAL SYSTEM

4 NHTSA complaints · 2025-09-23 → 2026-05-22

“The telecommunications module for vehicle GPS and OnStar emergency services failed after a factory software update. Now the vehicle has no GPS location, information emergency OnStar services or the ability to access vehicle Telematic via cell signal or an app”
— Owner report, NHTSA ODI #11739446
“Onstar module failed, no longer have wifi, navigation or other onstar supported features. Cannot perform system updates for vehicle due to onstar module. Cannot use app due to onstar module”
— Owner report, NHTSA ODI #11689230

Read all complaints on NHTSA →

Service safety restraint system / airbag warning light

SEAT BELTS, AIR BAGS

4 NHTSA complaints · 2025-12-30 → 2026-01-28

“Car says "service safety restraint system" and airbag light comes on intermittently. Dealer won't cover under safety restraint warranty. They site TSB about a wire that GM made too short but are not sure it will fix it. This car has 42,000”
— Owner report, NHTSA ODI #11707940
““Service safety restraint system” light came on. I feel this is a defect and a serious concern. I’ve seen where others are experiencing the same issue. I bought this vehicle specifically because I wanted to a safe vehicle to drive my 4 children around in”
— Owner report, NHTSA ODI #11714022

Read all complaints on NHTSA →

Engine coolant control valve failure / limp mode

POWER TRAIN

3 NHTSA complaints · 2025-07-17 → 2025-08-27

“The coolant control valve malfunctioned on this vehichle several times during the course of ownership. It causes the vehichle to run in limp mode. This part was replaced in July 2023 at ~40,000 miles as a result. The part again began to fail in june/july 2025”
— Owner report, NHTSA ODI #11678667
“Coolant control valve failed and needs replaced. Which left me and my 3 children (one being [XXX] ) stranded on the side of [XXX] for 2 hours before someone could get to us”
— Owner report, NHTSA ODI #11677856

Read all complaints on NHTSA →

Fuel tank partial detachment from subframe

FUEL SYSTEM, GASOLINE

2 NHTSA complaints · 2025-03-02 → 2026-01-08

“The contact stated that while driving approximately 60 MPH, there was an abnormal scraping sound coming from under the vehicle. After stopping to inspect the vehicle, the contact discovered that the fuel tank had partially detached from the subframe and fuel was leaking from the…”
— Owner report, NHTSA ODI #11709715
“I WAS DRIVING HOME AT HIGHWAY, I HEAR NOISE SCRAPPING NOISE FROM UNEVEN PAVEMENT AND ROLL OVER SPEED BUMP AND A PIECE OF METAL LIKE U SHAPE FELT OFF. WHEN I GET HOME, INSPECTED I SAW MY VEHICLE FUEL TANK HAGGING ON ONE SIDE”
— Owner report, NHTSA ODI #11645877

Read all complaints on NHTSA →

Note: NHTSA also opened 2 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

4 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

4

complaints mentioning a crash

1

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2022 Chevrolet Suburban reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →