2023 Chevrolet Suburban Recalls, Issues & Maintenance

“With no warning lights or indication there was a problem the engine suddenly died and shifted itself into neutral. I had just started going up hill, no left lane median but I managed to barely make the right shoulder, when the vehicle came to a stop it shifted into Park”

“Approximately 6,000 miles later, on XXX, the replacement engine failed while I was driving on the interstate highway near Billings, Montana. There were no warning indicators of any kind until I suddenly lost power. Only at the moment power was lost did the check engine light…”

“the vehicle began losing power and making a loud noise. My wife exited the highway and contacted OnStar, who told her the tow would take over an hour and only cover three miles to closest dealer, leaving her stranded in an unsafe area”

“Transmission malfunction. This has appeared several times at highway speeds and low speeds. We have dad to limp along in the slow lane to exit ramp and take back roads to the nearest dealership. The current problem has been confirmed with error codes P0747”

“2023 Chevy Suburban transmission control valve failures causing wheel lockup or deceleration causing the vehicle to be unsafe to operate. Chevrolet refuses to acknowledge”

“Following extensive research & uncovering the fact that there are several class action lawsuits underway calling out GM for not issuing a formal recall when they should have from the start, we've been forced to personally absorb significant costs tied to replacing our 2023…”

“The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the messages “Coolant Control Valve” and “Acceleration Reduced – Stop Vehicle” were displayed. The vehicle was taken to the dealer, where it was diagnosed…”

“Our Chevrolet suburban has 57,000 miles on it. We have started getting a check engine light and I’m getting code P1098 for the cooling control valve. This is a very common issue on these vehicles I’m noticing now”

“Coolant control valve failed. Reduced engine power, and engine fan on high”

“Sun Roof has leaked. The Sun roof leaked a considerable amount of water and it came through the head liner around the ceiling mounted control panel as well as the back of the car. This is the second time it has happened and I have been told it is not covered under warranty”

“The sunroof drains continue to fail. I’ve had multiple occasions where the car has had drains back up or be disconnected.. This is a safety issue because it creates mold as water falls in the headliner and then the cabin. It also creates rust, particularly behind the dashboard”

“While driving in the rain the front windshield wipers stopped moving and were stuck in the down position. They would not activated with auto, manual, or wash commands. Rear wiper still functioned. This happened while driving down the interstate which resulted in having to…”

“While driving on the highway at night during rainy conditions the wipers stopped in the up position, and at the same time, the headlights turned off. After a few seconds they resumed normal operation. My headlights were in the auto position and my wipers were also in the…”

“my [XXX] son was seated in the second-row center seat and was properly buckled in with the factory shoulder/lap belt. He turned around briefly to grab something from the back of the vehicle, and during that movement the seatbelt fully extended and then locked in the automatic…”

“The drivers side, female end, of the seatbelt comes undone when cold. This is reproduced every single time it is cold for approximately 5 minutes of driving until the inside of the vehicle warms up. This happens with both primary divers of the vehicle”

“Since purchasing the car in March 2023, the battery has died 5-7 times. We contacted our dealer and they claimed nothing wrong and the battery was fine. We have contacted them about this issue and there is no fix. They performed an update in June 2025 which was supposed to fix…”

“My vehicle suddenly stalled while driving. I later replaced the battery and discovered the telecom module was damaged, making the OnStar system inoperable. GM disagreed with my warranty claim and required me to replace the module at my own expense”

“Automatic Emergency Braking system activated at ~77mph. Essentially I had started braking appropriately and at about the same time the AEB system seemed to conclude more breaking was needed. This led to brief loss of vehicle control when brakes COMPLETELY LOCKED at high rate of…”

“The contact stated while driving at an undisclosed speed, the vehicle experienced phantom braking. Additionally, the windshield wipers were inoperable. On another occasion, while driving at approximately 70 MPH, the vehicle experienced phantom braking. There was no warning light…”