Radiator coolant leak without warning indicators
ENGINE
2 NHTSA complaints · 2026-02 → 2026-08
“The radiator developed a leak at around 36k miles and needed to be replaced. My understanding is that this is an ongoing problem with this vehicle.”
2023 Chevrolet Blazer Recalls, Issues & Maintenance
The 2023 Chevrolet Blazer carries 2 open NHTSA recalls — most recently covering driveshaft and automatic transmission. Owners report 4 recurring issue clusters, led by “Radiator coolant leak without warning indicators.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.
2 Open Recalls
Source: NHTSAPOWER TRAIN:DRIVELINE:DRIVESHAFT
Campaign #23V042000 · Feb 2, 2023
POWER TRAIN:DRIVELINE:DRIVESHAFT
Campaign #23V042000 · Feb 2, 2023
Issue: General Motors, LLC (GM) is recalling certain 2023 Chevrolet Blazer and Traverse vehicles. The left-side half-shaft assemblies may be missing a retaining ring.
Risk: A missing retaining ring on the half-shaft can cause half-shaft inner joint separation, resulting in a loss of drive power or vehicle rollaway when the vehicle is placed in park. Either of these scenarios can increase the risk of a crash.
Fix: Dealers will replace the left-side half-shaft assembly, free of charge. Owner notification letters were mailed February 23, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222390180.
POWER TRAIN:AUTOMATIC TRANSMISSION
Campaign #23V172000 · Mar 16, 2023
POWER TRAIN:AUTOMATIC TRANSMISSION
Campaign #23V172000 · Mar 16, 2023
Issue: General Motors, LLC (GM) is recalling certain 2023 Cadillac XT6, GMC Acadia, Chevrolet Blazer, Traverse, and 2022-2023 Cadillac XT5 vehicles. The transmission may have been built with an incorrect sun gear, which can result in the driver-side half-shaft disengaging from the transmission.
Risk: A half-shaft disengaging from the transmission can result in a loss of drive power or vehicle rollaway when the vehicle is placed in park. Either of these scenarios can increase the risk of a crash.
Fix: Dealers will replace the sun gears, free of charge. Owner notification letters were mailed on July 27, 2023. The remedy is expected to become available August 31, 2023. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GMC's number for this recall is N222389310.
Recall data refreshed Sep 6, 2026.
Known issues for this vehicle
What drivers and federal regulators have officially reported about the 2023 Chevrolet Blazer.
Reported to NHTSA
Instrument cluster and speedometer screen intermittent blackout
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
2 NHTSA complaints · 2026-07 → 2026-07
“The digital odometer and speedometer screen intermittently crashes and goes completely black for 15 to 20 seconds while the vehicle is in motion on public roads. This creates an immediate safety hazard as I am left with zero knowledge of my current speed.”
“Odometer Fraud. The contact purchased a 2023 Chevrolet Blazer. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of the purchase the vehicle mileage was 57,692.”
Headlight illumination failure and automatic high-beam malfunction
EXTERIOR LIGHTING
3 NHTSA complaints · 2023-05 → 2026-02
“My bright lights do not go off when oncoming vehicles or vehicles in front of me are close and when they do dim they go on and off. People flash their brights at me causing me not to be able to sleep and this happens even when they turned off of auto.”
Thermostat failure causing cooling fan continuous operation
STEERING, ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
2 NHTSA complaints · 2025-09 → 2026-05
“while driving, a code appeared on the dashboard P0128. When the vehicle's engine was switched off, the engine cooling fan continued to run. Warning light stating the steering would be disable.; however power steering was not lost. The vehicle was taken to a dealer where it was diagnosed with a thermostat failure.”
“Thermostat not working. Causing fan to run as if the vehicle is overheating”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Essential maintenance
Critical for safety and preventing major damage
Engine Oil & Filter (per Oil Life System)
Every 7,500 miChange oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Tire Rotation
Every 7,500 miRotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Brake Inspection
Every 7,500 miInspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
Brake Fluid
Every 45,000 miGM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Important maintenance
Keeps your vehicle running smoothly and efficiently
Engine Air Filter
Every 45,000 miGM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Automatic Transmission Fluid
Every 45,000 miSevere service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Transfer Case Fluid (4WD)
Every 45,000 miSilverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
Spark Plugs
Every 100,000 miGM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
Dex-Cool Engine Coolant
Every 50,000 miGM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Rear Differential Fluid
Every 50,000 miSilverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Recommended maintenance
Extends the life of your vehicle and improves comfort
Cabin Air Filter
Every 22,500 miReplace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Fatal crash history & reported problems
Occupant deaths in fatal crashes (FARS)
3 crashes 2010–2024
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
3
complaints mentioning a crash
0
complaints mentioning a fire
Reviewed known issues for this vehicle·Open recalls for this vehicle
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2023 Chevrolet Blazer reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.