Wrench.Pro

2025 Chevrolet Blazer Recalls, Issues & Maintenance

The 2025 Chevrolet Blazer carries 1 open NHTSA recall — most recently covering latch. Owners report 6 recurring issue clusters, led by “Telematics control module failure disabling OnStar.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

1 Open Recall

Source: NHTSA

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Campaign #24V737000 · Feb 10, 2024

Issue: General Motors, LLC (GM) is recalling certain 2025 Chevrolet Blazer, Blazer EV, and Equinox vehicles. The door strikers were not properly heat-treated, which can cause them to break.

Risk: A broken door striker can cause the door to open unexpectedly, increasing the risk of injury.

Fix: Dealers will replace all four side door strikers and attachment bolts, free of charge. All affected vehicles are still in dealership inventory and therefore no owner notification letters are expected to be mailed. Owners may call Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242477131.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2025 Chevrolet Blazer.

Reported to NHTSA

Telematics control module failure disabling OnStar

ELECTRICAL SYSTEM

9 NHTSA complaints · 2025-11 → 2026-05

“The Telematics Module failed and is on backorder. This is a known issue across the U.S. This makes it so OnStar doesn't work and I am paying for it. Not just that the safety concern of it not working. GPS, Maps, Level 3 Tesla doesn't work”
— Owner report, NHTSA ODI #11738977
“2025 Chevrolet Blazer EV AWD purchased 5/23/25 (under 3,100 miles) The vehicle's Telematics Control Module (TCM) has failed, disabling the built-in navigation system, OnStar services, remote start, and My Chevrolet app connectivity”
— Owner report, NHTSA ODI #11727054
“Telematics control module failure”
— Owner report, NHTSA ODI #11706011

Read all complaints on NHTSA →

Windshield water leak and wiper visibility failure

VISIBILITY/WIPER

3 NHTSA complaints · 2025-10 → 2026-06

“windshield leaking water inside of drivers compartment, headliner & side pillars (causing stained areas) as well as the top of onstar and electrical buttons on the overhead console . Found wet cup holder. Vehicle does not have a sun roof”
— Owner report, NHTSA ODI #11742550
“The visibity in sunlight is dangerously impaired with the reflection of the dashboard on the windshield . Hard to see and really distracting while driving”
— Owner report, NHTSA ODI #11701807
“I was driving on a rainy day, and noticed my windshield wipers were not working. I tried adjusting wiper speed and even the spray function, which sprayed but did not wipe”
— Owner report, NHTSA ODI #11696151

Read all complaints on NHTSA →

Tire sidewall bubble and tread failure

TIRES

2 NHTSA complaints · 2025-06 → 2026-03

“Bridgestone Alenza A/S 2.0 275/45R21 I stopped to charge my vehicle, and noticed a large bubble in the sidewall. The tire has just under 11,000 miles”
— Owner report, NHTSA ODI #11722913
“Driving home about 25 mph, front passenger tire blew. Put donut spare on,. Took to Dealer next morning. front control arm bushing torn out of control. This is dangerous and should not have happened”
— Owner report, NHTSA ODI #11664759

Read all complaints on NHTSA →

Parking brake failure and recall part backorder

PARKING BRAKE

3 NHTSA complaints · 2026-01 → 2026-01

“The contact owns a 2025 Chevrolet Blazer. The contact received notification of NHTSA Campaign Number: 25V433000 (PARKING BRAKE). The contact stated that while driving 35 MPH, the vehicle vibrated abnormally”
— Owner report, NHTSA ODI #11714258
“The contact owns a 2025 Chevrolet Blazer. The contact received notification of NHTSA Campaign Number: 25V433000 (Parking Brake); however, the part to do the recall repair was not yet available. The local dealer was contacted”
— Owner report, NHTSA ODI #11709693
“On December 22, 2025, I purchased a brand-new Chevrolet Blazer EV SS from a dealership located approximately 1 hour and 10 minutes away from my home. Immediately after leaving the dealership lot, I noticed a grinding / grunting noise coming from the vehicle”
— Owner report, NHTSA ODI #11711601

Read all complaints on NHTSA →

Forward collision avoidance and unintended acceleration

FORWARD COLLISION AVOIDANCE

4 NHTSA complaints · 2025-10 → 2026-07

“The contact owns a 2025 Chevrolet Blazer. The contact stated that the Forward Collision Avoidance system had erroneously activated on several occasions. While driving very slowly, the braking system suddenly activated while leaving a dealer”
— Owner report, NHTSA ODI #11750366
“The vehicle accelerated without input and the brakes failed to respond. I am notifying you that this vehicle is a life-threatening safety risk and should not be rented again until a master technician clears the electronic throttle control and breaking system”
— Owner report, NHTSA ODI #11726743
“I was going to park in a parking lot, when my car suddenly accelerated rapidly crashing into the building”
— Owner report, NHTSA ODI #11742623

Read all complaints on NHTSA →

Engine stall or total power loss while driving

ENGINE

3 NHTSA complaints · 2025-04 → 2026-02

“On two separate occasions the vehicle lost all power while driving. On December 5, 2025 turning on to a main road from parking lot the vehicle shut off with no prior warning lights. Shifted vehicle to park”
— Owner report, NHTSA ODI #11720946
“The engine started acting weird in traffic going down hill on freeway. Eventually turned off turning into my driveway. No warning or engine light. Towed to dealer and is in for inspection, not sure if they can repair or if they have to replace the engine”
— Owner report, NHTSA ODI #11714080
“1).Engine stopped on Interstate hiway with just 2024 miles. Towed to Chevy dealer. New engine installed. Upon return of car emission system failure. 2) Car delivered with defective windshield with major (crackle) throughout very distracting at sunrise/sunset”
— Owner report, NHTSA ODI #11655111

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

1

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2025 Chevrolet Blazer reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →