Wrench.Pro

2023 Chevrolet Silverado 2500 Recalls, Issues & Maintenance

The 2023 Chevrolet Silverado 2500 carries 1 open NHTSA recall — most recently covering latch. Owners report 4 recurring issue clusters, led by “10L1000 transmission valve body failure.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.

1 Open Recall

Source: NHTSA

LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH

Campaign #24V060000 · Jan 2, 2024

Issue: General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.

Risk: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

Fix: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232426400.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2023 Chevrolet Silverado 2500.

Reported to NHTSA

10L1000 transmission valve body failure

POWER TRAIN

14 NHTSA complaints · 2024-06-01 → 2026-07-27

“While driving, the 10l1000 transmission in the truck attempted to shift from 6th gear to 7th gear. The transmission locked up causing a violent "buck" from the rear end of the truck. The road was icy and could have caused the truck to lose control due to the lock up of the rear wheels…”
— Owner report, NHTSA ODI #11710432
“The Allison 10‑speed (10L1000) transmission valve body catastrophically failed on [XXX], while driving Sunday afternoon down Galveston Seawall Blvd. The truck abruptly dropped from 45 mph into limp mode in heavy traffic, forcing me to pull into the bike lane to avoid being rear‑ended…”
— Owner report, NHTSA ODI #11671056
“Truck has less than. 30k miles on it. Went into limp mode, was less than a mile from home. Parked it had it towed to nearest dealer. They then informed me they have 4 other truck sitting and waiting for Gm to fix parts with allison 10 speed transmission valve body…”
— Owner report, NHTSA ODI #11646442

Read all complaints on NHTSA →

"Shift to park" warning and key release failure

ELECTRICAL SYSTEM, POWER TRAIN

7 NHTSA complaints · 2025-07-17 → 2026-03-26

“Switch fails in shifter assembly that is supposed to sense the vehicle is in park. Does not allow the key to be removed. Dealership explained that complete failure may cause the vehicle to actually get stuck in drive. Very common problem that typically occurs just outside of bumper to bumper warranty…”
— Owner report, NHTSA ODI #11731334
“When putting vehicle in park, I get a message on dash that says "shift to park" when the vehicle is already in park. The vehicle electrical components does not turn off. Sometimes if I wiggle/hit or stick my hand under the steering wheel adjustment lever I can get it to turn off…”
— Owner report, NHTSA ODI #11721726

Read all complaints on NHTSA →

Infotainment screen blackout and freeze

LANE DEPARTURE: BLIND SPOT DETECTION, LANE DEPARTURE: WARNING, ELECTRICAL SYSTEM

2 NHTSA complaints · 2023-06-08 → 2026-04-22

“The entire infotainment system has gone black. Nothing shows on the screen. This is a safety issue as it does not show blind spot monitoring, heads up display, lane change warnings, allow hands free calling, gps, and much more. None of the safety features are available with a trailer hookup as well…”
— Owner report, NHTSA ODI #11733001
“when driving radio and display will freeze up. sometimes screen will black out other times screen will just freeze where ever i had it last. when problem happens i am unable to turn radio down or off. back up camera will freeze with no directional lines…”
— Owner report, NHTSA ODI #11525966

Read all complaints on NHTSA →

Vehicle fire events

ELECTRICAL SYSTEM

2 NHTSA complaints · 2023-05-23 → 2026-06-15

“The contact stated that after opening the garage door flames were present coming from the hood and front fender wells of the vehicle. The fire department was called to the home and extinguished the flames. During the incident, the vehicle was destroyed. A second vehicle parked inside the garage was also destroyed…”
— Owner report, NHTSA ODI #11523495
“Was driving east on i40 between Hinton and calumet when my truck through a check engine light and service parking break. I pulled over it smelt like burning wires I cleared the codes with a code reader and turn the truck on the accessory when smoke filled the cab I got out and the truck was in flames.”
— Owner report, NHTSA ODI #11744216

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Spark Plugs

Every 100,000 mi

GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Rear Differential Fluid

Every 50,000 mi

Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

18 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

2

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2023 Chevrolet Silverado 2500 reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →