The 2025 Chevrolet Silverado 2500 carries 1 open NHTSA recall — most recently covering pressure monitoring and regulating systems. Owners report 5 recurring issue clusters, led by “Infotainment audio loss muting safety warning chimes.” Chevrolet vehicles use the GM Oil Life System (OLS) — a percentage-based monitor that calculates oil life from driving conditions, not fixed mileage. When the OLS drops to 0%, oil and filter are due. The schedule below reflects GM's Normal Use intervals for everything else.
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
Campaign #26V530000 · Aug 13, 2026
Issue: General Motors, LLC (GM) is recalling certain 2024-2025 Chevrolet Silverado 2500 and GMC Sierra 2500 vehicles equipped with the enhanced towing option and 20-inch accessory tire/wheel package. The tire information label may state the incorrect rear tire pressure, resulting in underinflated tires and preventing the tire pressure monitoring system (TPMS) from displaying a low tire pressure warning.
Risk: Driving with underinflated tires can increase the risk of a crash.
Fix: Dealers will inspect, update the engine control module (ECM) software, apply a tire label overlay, inflate tires to the correct pressure, and perform a tire pressure monitor system (TPMS) re-learn process as necessary, free of charge. Owner notification letters are expected to be mailed September 28, 2026. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N262561970. Vehicle Identification Numbers (VIN) involved in this recall became searchable on NHTSA.gov on August 13, 2026.
What drivers and federal regulators have officially reported about the 2025 Chevrolet Silverado 2500.
ELECTRICAL SYSTEM
4 NHTSA complaints · 2025-12 → 2026-08
“Radio does not emit sound also canceling all warning noises for fuel level, turn signals, seat belts, open door in motion. This problem is not only a saftey hazard for drivers its a major annoyance”
“Following vehicle startup, the entire audio system defaults to a muted state, affecting all sound output channels”
UNKNOWN OR OTHER
2 NHTSA complaints · 2025-07 → 2025-09
“Tailgate has been coming open while driving. Multiple times. The last time it landed on the jack of my enclosed trailer. Without me knowing. First time was 2-3-25 and the last time was 9-2-25”
“Tailgate went down on its own while driving and pulling a trailer”
POWER TRAIN
3 NHTSA complaints · 2025-01 → 2025-12
“Since owning the vehicle, I have experienced a noticeable shutter/vibration at highway speeds, consistently between 70–75 mph, whether towing or not”
“Have had issues since purchase of paint chipping severely / cloudy. Transmission shudder and “jumped forward” when coming to a stop. lighting system “blinked” or went dark and come back up a few seconds later while driving”
“Transmission lock-up while driving. Rear end of vehicle jumped up felt like I was rear ended. If this happened at higher speed or when towing it could cause serious injury to myself or others”
ENGINE
4 NHTSA complaints · 2025-01 → 2025-06
“The contact owns a 2025 Chevrolet Silverado 2500. The contact stated while driving 30 MPH, the engine light illuminated. There was an extremely loud knocking sound coming from the engine”
“Vehicle loses power when entering roadway. Vehicle fires at idle. Vehicle dies on roadway. Vehicle lurches aggressively without control. Vehicle shifts erratically and with aggression”
“Whining noise from engine or powertrain, seems to have lost some power”
STEERING
2 NHTSA complaints · 2025-08 → 2026-03
“The contact owns a 2025 Chevrolet Silverado 2500. The contact stated that while driving 75 MPH, the vehicle independently pulled to the left. The vehicle was taken to the dealer, and the contact was informed that an alignment was needed”
“I was driving the truck on my way to work in [XXX] , last March 12, 2026, at around 6:50 am. It was raining when I entered the exit ramp to work going west; the truck died, and the steering wheel locked”
Issues on other model years
Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.
We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.
Critical for safety and preventing major damage
Change oil when the Oil Life System reaches 0% or every 12 months — whichever comes first. dexos1-approved synthetic oil required on all gas engines since 2011.
Estimated cost — typical U.S. ranges
Dealer
~$120–$160
Shop
~$85–$115
DIY
~$25–$55
Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.
Rotate tires every 7,500 miles. Silverado 4x4 and Tahoe owners benefit from earlier rotations to even out drivetrain wear.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Often free at the shop where you bought the tires — worth asking before paying.
Inspect brake pads, rotors, and parking brake at each tire rotation. Equinox and Malibu front pads typically last 40,000-50,000 miles.
Estimated cost — typical U.S. ranges
Dealer
~$85
Shop
~$60
DIY
Free
Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.
GM specifies brake fluid replacement based on contamination testing. Test every 30,000 miles; replace if moisture content exceeds 3% or fluid appears dark.
Estimated cost — typical U.S. ranges
Dealer
~$180–$200
Shop
~$125–$140
DIY
~$10–$25
DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.
Keeps your vehicle running smoothly and efficiently
GM long-life cellulose air filters are rated 45,000 miles. Direct-injection engines are sensitive to airflow restriction; inspect at every oil change.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
5-minute job on most cars; the airbox lid usually has clips, no tools needed.
Severe service (heavy towing, frequent stop-and-go, dusty conditions): replace every 45,000 miles. Normal service: 97,500 miles. Use Dexron-VI on 6L80/8L90 transmissions.
Estimated cost — typical U.S. ranges
Dealer
~$330–$500
Shop
~$235–$355
DIY
~$60–$180
Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.
Silverado 4WD and Tahoe 4WD: replace transfer case fluid every 45,000 miles, sooner if towing or off-roading. Use GM Auto-Trak II fluid.
Estimated cost — typical U.S. ranges
Dealer
~$105–$140
Shop
~$75–$100
DIY
~$15–$40
AWD/4WD vehicles only. Easy drain-and-fill on most platforms.
GM iridium spark plugs are rated 100,000 miles on most LS and LT engines. The 5.3L V8 in Silverado 1500 commonly fouls plugs early under heavy idling.
Estimated cost — typical U.S. ranges
Dealer
~$285–$390
Shop
~$200–$275
DIY
~$25–$100
Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.
GM Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000 miles. Mixing with green coolant creates a sludge that destroys the cooling system.
Estimated cost — typical U.S. ranges
Dealer
~$285–$330
Shop
~$200–$235
DIY
~$25–$60
Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.
Silverado and Tahoe: replace rear axle fluid every 50,000 miles, or 25,000 miles if towing. Limited-slip differentials require GM friction-modifier additive.
Estimated cost — typical U.S. ranges
Dealer
~$150–$195
Shop
~$105–$135
DIY
~$20–$50
Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.
Extends the life of your vehicle and improves comfort
Replace the cabin air filter every 22,500 miles. Silverado and Tahoe owners in dusty climates should replace earlier.
Estimated cost — typical U.S. ranges
Dealer
~$60–$95
Shop
~$45–$70
DIY
~$15–$40
Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.
Occupant deaths in fatal crashes (FARS)
1 crashes 2010–2024
FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number
Owner-reported problem signals
Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.
1
complaints mentioning a crash
0
complaints mentioning a fire
Reviewed known issues for this vehicle·Open recalls for this vehicle
Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.
How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.
This maintenance schedule for the 2025 Chevrolet Silverado 2500 reflects Chevrolet's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.