Wrench.Pro

2023 Ram 2500 Recalls, Issues & Maintenance

The 2023 Ram 2500 carries 8 open NHTSA recalls — most recently covering automatic transmission and relays/solenoids. Owners report 6 recurring issue clusters, led by “Left turn signal activating high beams.” Ram trucks use the Oil Change Indicator system to signal oil service based on driving conditions. The Ram 1500 (HEMI 5.7L, eTorque mild-hybrid, EcoDiesel 3.0L) and Ram 2500/3500 (Cummins 6.7L turbo-diesel) have markedly different intervals — the schedule below covers Ram 1500 gas. Cummins-equipped HD trucks have separate oil, fuel filter, and DEF service requirements.

8 Open Recalls

Source: NHTSA

POWER TRAIN:AUTOMATIC TRANSMISSION

Campaign #22V835000 · Oct 11, 2022

Issue: FCA US, LLC (Chrysler) is recalling certain 2020-2023 Ram 2500 and 2020-2022 Ram 3500 vehicles. A build-up of pressure and heat inside the transmission may result in a transmission fluid leak from the dipstick tube.

Risk: Leaking transmission fluid may contact an ignition source within the engine compartment, increasing the risk of a fire.

Fix: Dealers will replace the transmission dipstick and transmission vent assembly, free of charge. Owner notification letters were mailed December 29, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. Chrysler's number for this recall is ZA3.

ELECTRICAL SYSTEM:WIRING:RELAYS/SOLENOIDS

Campaign #23V060000 · Sep 2, 2023

Issue: Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 2500, 3500, 3500 Cab Chassis, and 4500, 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the heater grid relay with the ignition on or off.

Risk: An electrical short in the relay can result in an engine compartment fire with the ignition on or off, increasing the risk of injury.

Fix: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the relay, free of charge. This will be a Phased campaign. Phase 1 will include 2023 model year vehicles. FCA US will notify dealers on or about 3/23/2023 and begin notifying owners on or about 4/5/2023. Phase 2 will include 2022 model year vehicles and Phase 3 will include 2021 model year vehicles. FCA US will notify dealers and owners on or about 4/27/2023 for Phase 2 and 5/11/2023 for Phase 3. Interim owner notification letters informing owners of the safety risk were mailed March 28, 2023. Owner notification letters are expected to be mailed April 5, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 13A. This recall is an expansion of and supersedes recall number 21V-798.

BACK OVER PREVENTION:DISPLAY FUNCTION

Campaign #23V059000 · Sep 2, 2023

Issue: Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 1500 and 2023 Ram 2500 vehicles. The trailer reverse steering control module (TRSCM) may prevent the rearview image from displaying when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: A rearview image that does not display while in reverse decreases the driver's visibility of the rear view, increasing the risk of injury or crash.

Fix: Dealers will update the TRSCM software, free of charge. Owner notification letters were mailed March 1, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 14A. This recall supersedes and expands previous recall numbers 21V-438 and 21V-918. FCA US Recall ID 63A is a vehicle population expansion of FCA US Recall ID 14A (NHTSA Recall ID 23V-059).

BACK OVER PREVENTION:DISPLAY FUNCTION

Campaign #23V654000 · Sep 28, 2023

Issue: Chrysler (FCA US, LLC) is recalling certain 2022-2023 Ram 1500, Ram 3500 Cab Chassis with GVWR less than 10,000 lbs., and 2022-2024 Ram 2500 vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.

Fix: Dealers will update the radio software, free of charge. Owner notification letters were mailed October 24, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 97A.

STEERING:STEERING CONTROL MODULE

Campaign #23V799000 · Nov 28, 2023

Issue: Chrysler (FCA US, LLC) is recalling certain 2023 Ram 1500 Classic, Ram 3500 Classic, 3500 Cab Chassis, 2023-2024 Ram 2500, 4500/5500 Cab Chassis, and Ram 3500 vehicles. The steering column control module may cause the high beams to activate when the turn signal is used or activate the turn signal when the high beams are used. In addition, the turn signal self-canceling feature may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: Turn signals and/or high beams that do not function as intended may cause confusion or reduced visibility to other road users, increasing the risk of a crash.

Fix: Dealers will update the steering column control module (SCCM) software, and inspect and replace the module, as necessary, free of charge. Owner notification letters were mailed December 19, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are B2A and D5A.

AIR BAGS:FRONTAL:DRIVER CLOCKSPRING/SPIRAL CASSETTE

Campaign #24V199000 · Mar 14, 2024

Issue: Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2023-2024 Ram 1500, Jeep Wrangler, Jeep Wagoneer, Jeep Grand Wagoneer, Chrysler Pacifica, Ram 3500, Ram 3500 cab chassis, Ram 2500, Ram 4500 cab chassis, Ram 5500 cab chassis, 2023 Jeep Gladiator, Jeep Grand Cherokee, Jeep Grand Cherokee L, Ram 3500 Cab Chassis with a GVWR less than 10,000 lbs., and Chrysler Voyager vehicles. The steering column control module may not be welded properly, which can prevent the driver's air bag from deploying in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: An air bag that does not deploy in a crash can increase the risk of injury.

Fix: Dealers will inspect and replace the steering column control module, as necessary free of charge. Some owner notification letters were mailed April 11, 2024 through June 20, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 14B, 33B, 34B, 35B, 36B.

POWER TRAIN:AUTOMATIC TRANSMISSION

Campaign #24V413000 · Jun 6, 2024

Issue: Chrysler (FCA US, LLC) is recalling certain 2023 Ram 1500, 2500, and 3500 vehicles. An insufficient weld in the transmission control unit can allow transmission fluid to leak on to electrical components, resulting in a loss of drive power or loss of park function.

Risk: A loss of drive power or a loss of park function increase the risk of a crash.

Fix: Dealers will replace the valve body and control unit, free of charge. Owner notification letters are expecting to be mailed July 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 63B.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

Campaign #26V288000 · Jul 5, 2026

Issue: Chrysler (FCA US LLC) is recalling certain 2023-2026 Ram 2500 Pick up trucks. A software error in the powertrain control module may improperly allow the vehicle speed to exceed the tire speed rating, which can result in a loss of vehicle control.

Risk: Loss of vehicle control increases the risk of a crash.

Fix: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed May 21, 2026. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 43D. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning May 14, 2026.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2023 Ram 2500.

Reported to NHTSA

Left turn signal activating high beams

EXTERIOR LIGHTING

9 NHTSA complaints · 2023-08-07 → 2026-02-05

“When I turn on the left blinker my bright lights come on. When the turn is complete the bright lights go out. This happens during the day and night. During the day when I flash my bright lights the left turn signal comes on.”
— Owner report, NHTSA ODI #11544637
“Headlight high beams turn on with left turn signal, also when actuating the high beams it turns on the left turn signal. You can not signal left without blinding other traffic with the high beams. No service lamps, happened since I bought the truck new.”
— Owner report, NHTSA ODI #11539516
“My vehicle has exhibited frequent but intermittent problems with left turn signals and headlight high beams since new. The dealership has been unable to duplicate the problems until 12/13/23 when a service technician observed the headlight flash to pass function activating the left turn signals…”
— Owner report, NHTSA ODI #11560560

Read all complaints on NHTSA →

Transmission harsh shifting and lurching

POWER TRAIN

5 NHTSA complaints · 2024-06-03 → 2026-03-16

“Transmission just started shifting very hard causing the truck to shake. Truck was fine last week, mileage is 9600. Have notified the dealer, they said to bring it it in. There is no warning lights or alerts”
— Owner report, NHTSA ODI #11615778

Read all complaints on NHTSA →

Brake pedal sinking toward floorboard

SERVICE BRAKES, HYDRAULIC

5 NHTSA complaints · 2023-07-17 → 2025-03-20

“The contact stated while driving at approximately 50 MPH, the brake pedal was depressed; however, the brake pedal was not responding, and almost went to the floorboard. The contact stated that the parking brake was used to stop the vehicle.”
— Owner report, NHTSA ODI #11640286
“The contact stated that while driving at an undisclosed speed and attempting to slow down, the contact became aware that the brake pedal almost went to the floorboard before the vehicle responded as needed. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure…”
— Owner report, NHTSA ODI #11649458
“Brakes failed 4 times in 4 days. Computer says low brake fluid, service stabilitrack, service electronic trailer brake systems. I filled with brake fluid twice. Called dealerships and stated minimum of 2 weeks before than can even look at it.”
— Owner report, NHTSA ODI #11532714

Read all complaints on NHTSA →

Air bag non-deployment in frontal crashes

AIR BAGS

2 NHTSA complaints · 2024-12-10 → 2026-02-21

“Head on collision on February 19, 2026 in a 2023 Ram 2500 Rebel. Air bags did not deploy anywhere in the vehicle even though driver was traveling 55-60 MPH. Significant damage occurred in front of vehicle as well as all along the passenger side of the vehicle.”
— Owner report, NHTSA ODI #11719613
“I was in a bad frontal/passenger front wreck and none of my airbags deployed”
— Owner report, NHTSA ODI #11629822

Read all complaints on NHTSA →

6.7L Cummins diesel engine defects

ENGINE

8 NHTSA complaints · 2023-08-19 → 2026-02-10

“My 2023, Ram 2500 truck with a Cummins 6.7L diesel engine has a known defect with the grid heater bolt. This bolt can loosen or break off, falling into the engine and causing catastophic engine failure. This creates a suddne loss of power, espcially dangerous when towing heavy loads at highway…”
— Owner report, NHTSA ODI #11685217
“Our 2023 Ram 2500 diesel is producing visible smoke from the engine bay and a persistent ticking/clicking noise from the engine. This occurs while driving and at idle. We have video evidence of smoke coming from under the hood and recordings of the abnormal engine noise.”
— Owner report, NHTSA ODI #11716921
“The contact stated while driving approximately 74 MPH, the EGR valve de-energized seizing the turbo, causing the vehicle do decelerate to 30 MPH in less than a quarter mile. The check engine warning light was illuminated.”
— Owner report, NHTSA ODI #11601186

Read all complaints on NHTSA →

Air bag / steering recall parts unavailability

STEERING, AIR BAGS

2 NHTSA complaints · 2025-03-07 → 2025-03-07

“The contact received notification of NHTSA Campaign Number: 24V199000 (Air Bags, Steering); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair.”
— Owner report, NHTSA ODI #11647013
“The contact received notification of NHTSA Campaign Number: 24V199000 (Air Bags, Steering); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair.”
— Owner report, NHTSA ODI #11647015

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 8,000 mi

HEMI 5.7L: SAE 5W-20 every 8,000 miles per Oil Change Indicator. Pentastar 3.6L: SAE 0W-20. EcoDiesel 3.0L: full synthetic 5W-30, every 10,000 miles. Cummins 6.7L (HD): 15W-40 every 15,000 miles or 6 months.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 8,000 mi

Rotate tires every 8,000 miles. 4WD models towing or hauling regularly: rotate every 5,000 miles to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 8,000 mi

Inspect pads, rotors, and parking brake every 8,000 miles. Ram 1500 front pads typically last 40,000-60,000 miles under normal use; cut by 30-50% if towing heavily.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Fuel Filter (EcoDiesel + Cummins)

Every 30,000 mi

EcoDiesel 3.0L: dual fuel filters (under hood + frame-mounted) replace every 30,000 miles. Cummins 6.7L: replace at 30,000 miles or sooner if water-in-fuel light triggers.

Estimated cost — typical U.S. ranges

Dealer

~$195–$250

Shop

~$135–$175

DIY

~$20–$60

On many modern cars the filter lives inside the fuel tank and is lifetime — verify before paying for a 'service'.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 40,000 mi

Replace engine air filter every 40,000 miles. Trucks driven on construction sites or unpaved roads should inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid (ZF 8HP70 / 8HP75)

Every 60,000 mi

Severe service (towing, plowing): replace ATF every 60,000 miles. Normal: 120,000 miles. Use Mopar ATF+4 — substitutes cause harsh 3-4 and 5-6 shifts.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 60,000 mi

Ram 1500 4WD: replace transfer case fluid every 60,000 miles. Use Mopar ATF+4 for the BorgWarner 44-44 transfer case.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Differential Fluid (front + rear)

Every 60,000 mi

Front and rear axle fluid: replace every 60,000 miles, or 30,000 miles if towing 6,000+ lbs regularly. Limited-slip rears require Mopar friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs (HEMI — 16 plugs)

Every 100,000 mi

HEMI 5.7L runs two spark plugs per cylinder (16 total) — replace at 100,000 miles. Pentastar 3.6L: standard 6 plugs at 100,000 miles. EcoDiesel: glow plug inspection at 100,000.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

MS-12106 Coolant (Mopar HOAT)

Every 50,000 mi

Mopar HOAT (purple): first change at 100,000 miles or 5 years, then every 50,000 miles. EcoDiesel uses a different OAT formulation — do not mix.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace cabin air filter every 20,000 miles. Behind the glove box on Ram 1500.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

29 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2023 Ram 2500 reflects Ram's published service intervals and the Oil Change Indicator system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →