Wrench.Pro

2024 Gmc Canyon Recalls, Issues & Maintenance

The 2024 Gmc Canyon carries 3 open NHTSA recalls — most recently covering tank assembly and headlights. Owners report 5 recurring issue clusters, led by “Headlight flicker during operation.” GMC trucks and SUVs use the GM Oil Life System (OLS) — the same algorithm as Chevrolet. Because GMC's lineup is exclusively trucks and SUVs, severe-service intervals apply to most owners (towing, hauling, off-roading). The schedule below surfaces the items most relevant to GMC's truck-focused buyer.

3 Open Recalls

Source: NHTSA

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Campaign #24V491000 · Jun 28, 2024

Issue: General Motors, LLC (GM) is recalling certain 2024 Chevrolet Colorado and GMC Canyon vehicles. The lock ring that secures the fuel pump to the fuel tank assembly may not have been fully locked during assembly, which can result in a fuel leak during a crash.

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

Fix: Dealers will inspect and fully lock the fuel tank lock ring as necessary, free of charge. Owner notification letters are expected to be mailed August 13, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC Customer Call Center at (888) 988-7267. GM's number for this recall is N242451330.

EXTERIOR LIGHTING:HEADLIGHTS

Campaign #24V673000 · Dec 9, 2024

Issue: General Motors, LLC (GM) is recalling certain 2024 GMC Canyon vehicles. The headlights may flicker while driving and while the vehicle is in park. As such, these vehicles fail to comply with the requirements of Federal Motor Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: Headlights flickering can reduce visibility, increasing the risk of a crash.

Fix: Dealers will replace a module in the headlight, free of charge. Owner notification letters were mailed October 10, 2024. Owners can contact GMC customer service at 1-800-462-8782. GM's number for this recall is N242468880.

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Campaign #25V856000 · Nov 12, 2025

Issue: General Motors, LLC (GM) is recalling certain 2024–2026 GMC Canyon AT4X AEV vehicles. Incorrect sensing and diagnostic module (SDM) software may cause a second stage passenger air bag deployment when only a first stage is intended. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 208, “Occupant Crash Protection."

Risk: An air bag that deploys improperly increases the risk of injury in a crash.

Fix: Dealers will update the SDM software, free of charge. Owner notification letters were mailed January 30, 2026. Owners may contact GMC customer service at 1-800-462-8782. GM's number for this recall is N252533510. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 11, 2025.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2024 Gmc Canyon.

1 active NHTSA investigation

Source: NHTSA

  • Electronic Brake Module Component Failure

    Action #EA26006 · opened Aug 21, 2026

    On April 11, 2024, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE24011 after receiving complaints concerning a loss of brake assist in 2023 MY Cadillac Lyriq vehicles. These complaints allege a hard brake pedal, followed by a “Brake System Failure” mes…

    View on NHTSA →

Reported to NHTSA

Headlight flicker during operation

EXTERIOR LIGHTING

148 NHTSA complaints · 2024-07 → 2024-11

“Headlights Flickering frequently while driving or parked. Causes other drivers in front of me to think I am high beaming them or flashing my lights at them. Causes quick moments of darkness and is disorienting when driving at night. No warning lights or signs of damage. This…”
— Owner report, NHTSA ODI #11609907
“My GMC Canyon has an issue with flickering of the headlights at night, which sometimes results in one side or the other going completely out. I'm part of several Canyon forums, and this seems to be an issue with most 2024 Canyons. The flicker is more of an annoyance, as I can…”
— Owner report, NHTSA ODI #11612200

Read all complaints on NHTSA →

Opposite-direction turn signal after completed turn

EXTERIOR LIGHTING

7 NHTSA complaints · 2024-08 → 2025-05

“The turn signal is activating in the opposite direction. After completing a 90 degree right hand turn, when the turn signal deactivates it will turn on the left turn indicator for 3-5 seconds. This only happens when making right hand turns and I have been able to replicate it on…”
— Owner report, NHTSA ODI #11616322
“When the right turn signal cancels after completing a right turn, the left turn signal activates, flashing 3 times. This appears to be the result of a defective design with the turn signal level. The dealer has acknowledged the problem and has stated that there is a bulletin…”
— Owner report, NHTSA ODI #11626108

Read all complaints on NHTSA →

Coolant leak at upper radiator hose connection

ENGINE

8 NHTSA complaints · 2025-10 → 2026-03

“Upper radiator hose connection to radiator is faulty causing leak of coolant. Yes it is available for inspection upon request. Truck began to run cooling fan at full speed in the middle of winter with no warnings of high heat or low coolant. After two weeks, check engine light…”
— Owner report, NHTSA ODI #11721052
“Upper radiator hose leaks where it connects to radiator. 40k miles and my truck has no coolant”
— Owner report, NHTSA ODI #11707894

Read all complaints on NHTSA →

Brake failure and premature rotor wear

SERVICE BRAKES

7 NHTSA complaints · 2024-08 → 2026-03

“Upon starting the vehicle, I got multiple warning lights. The most important was brake failure. I had no brake function. I took it to the dealer and they replaced the brake module after 3 days.”
— Owner report, NHTSA ODI #11713383
“I first noticed the brakes squealing in August 2025 at 15,000 miles. The dealership said I needed to resurface the front rotors. I mistook this a coating and brake debris, but it was actually the rotors warping. By 21,000 the vehicle is pulsing heavily when stopping. I went back…”
— Owner report, NHTSA ODI #11727764

Read all complaints on NHTSA →

Adaptive cruise control unintended braking

FORWARD COLLISION AVOIDANCE

4 NHTSA complaints · 2024-09 → 2025-05

“On [XXX] I took a trip with family through Ohio from Pennsylvania. While truck was in adaptive cruise control on highway, phantom braking occurred where truck slowed down from 70mph to about 60mph 5 times. No objects or vehicles in front of truck or around truck during the…”
— Owner report, NHTSA ODI #11634803
“Adaptive Cruise Control has applied brakes multiple times while cruise has been sent at speeds ranging from 55-75 MPH. Vehicle aggressively slowed down 10-20 MPH then picked up speed. No vehicles in sight ahead of vehicle, aggressively applied braking without warning. Aggressive…”
— Owner report, NHTSA ODI #11614391

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (per Oil Life System)

Every 7,500 mi

Change oil when OLS reaches 0% or every 12 months. dexos1-approved synthetic required on Sierra 1500 5.3L/6.2L; dexos2 specified on Duramax diesel.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate tires every 7,500 miles. Sierra and Yukon owners running 4x4 should rotate every 5,000-7,500 miles to even out drivetrain wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 7,500 mi

Inspect pads, rotors, and parking brake every 7,500 miles. Towing accelerates pad wear by 30-50%; check more often if towing regularly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

DOT 3 brake fluid: test annually, replace when moisture exceeds 3% or fluid is darker than copper.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 45,000 mi

Long-life cellulose filter rated 45,000 miles. Trucks driven on unpaved roads or construction sites should inspect at every oil change.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 45,000 mi

Severe service (towing 5,000+ lbs regularly, heavy stop-and-go): every 45,000 miles. Normal: 97,500 miles. Use Dexron-VI for 6L80/6L90, Mobil 1 LV ATF HP for 10L80/10L1000.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD)

Every 45,000 mi

Sierra and Yukon 4WD: replace every 45,000 miles. Use GM Auto-Trak II for active 4WD; GM 9986115 for selectable 4WD.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Differential Fluid (front + rear)

Every 50,000 mi

Replace front and rear axle fluid every 50,000 miles, or 25,000 miles if towing. G80 limited-slip rear axles require GM friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on the L83/L84 5.3L and L86/L87 6.2L V8 are rated 100,000 miles. AFM/DFM cylinder deactivation can cause uneven plug wear — check at 75,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Dex-Cool Engine Coolant

Every 50,000 mi

Dex-Cool (orange): first change at 150,000 miles or 5 years, then every 50,000. Duramax diesel uses ELC (red) — different chemistry, do not mix.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 22,500 mi

Replace cabin air filter every 22,500 miles. Sierra HD and Yukon XL owners in dusty work environments should replace at 15,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2024 Gmc Canyon reflects GMC's published service intervals and the Oil Life System system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →