Wrench.Pro

2024 Lincoln Corsair Recalls, Issues & Maintenance

The 2024 Lincoln Corsair carries 4 open NHTSA recalls — most recently covering labels and management system/energy control module (bms/becm). Owners report 7 recurring issue clusters, led by “PHEV high-voltage battery recall 26V091 repair unavailability.” Lincoln uses Ford's Intelligent Oil-Life Monitor: it tracks how the vehicle is actually driven and calls for oil service when needed — up to 10,000 miles or 12 months on normal duty, much sooner with towing or repeated short trips. EcoBoost-powered Aviators and Nautilus models are turbocharged: heat is their maintenance story, so oil quality and cooling-system health matter more than on the old naturally aspirated V8s. Traditional V8 Navigators and Town Cars are long-interval machines — 100,000-mile plugs — that mostly reward fluid discipline.

4 Open Recalls

Source: NHTSA

EQUIPMENT:OTHER:LABELS

Campaign #24V852000 · Aug 11, 2024

Issue: Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Fix: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:MANAGEMENT SYSTEM/ENERGY CONTROL MODULE (BMS/BECM)

Campaign #24V954000 · Dec 20, 2024

Issue: Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

Risk: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

Fix: Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.

BACK OVER PREVENTION:SOFTWARE

Campaign #25V315000 · Sep 5, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Risk: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Fix: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

EXTERIOR LIGHTING

Campaign #25V688000 · Oct 10, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2024-2025 Lincoln Corsair vehicles. Water may leak into the left and right rear combination lights, possibly resulting in a loss of reverse light, tail light, brake light, or rear turn signal function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: Loss of rear lighting functions can reduce vehicle visibility and fail to alert other drivers that the vehicle is braking, turning, or reversing, increasing the risk of a crash.

Fix: Dealers will inspect and replace the rear combination light assemblies, as necessary, free charge. Owner notification letters were mailed November 14, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C53. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 14, 2025.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2024 Lincoln Corsair.

Reported to NHTSA

PHEV high-voltage battery recall 26V091 repair unavailability

ELECTRICAL SYSTEM

6 NHTSA complaints · 2025-10-10 → 2026-06-23

“The manufacturer's interim safety instructions for Recall 26V091 are failing. Lincoln instructs drivers to use Pure EV mode to prevent battery fires. However, the Corsair's software actively overrides Pure EV mode, automatically turning on the gas engine and completely defeating…”
— Owner report, NHTSA ODI #11746032
“The contact received notification of NHTSA Campaign Number: 26V091000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the vehicle was experiencing an abnormally high voltage battery rapid discharge after an 80 percent…”
— Owner report, NHTSA ODI #11745647

Read all complaints on NHTSA →

12V battery parasitic drain and charge loss

ELECTRICAL SYSTEM

5 NHTSA complaints · 2025-12-19 → 2026-04-06

“For the last three months, after the car sits for 12 hours or more, I get a "battery saver mode" on my phone and many of the online features won't work. Dealer measured the battery power on first visit - read 93 percent. Went to dealer a month later, battery read 59 percent.…”
— Owner report, NHTSA ODI #11729336
“I have noticed that when the battery is lower than 85% available power sensor effectiveness is greatly reduced. This is noticed with vehicle going into remote battery saver mode and the Auto Start/Stop function ceases to function. This also greatly reduces front collision, rear…”
— Owner report, NHTSA ODI #11715760

Read all complaints on NHTSA →

ADAS sensor and pre-collision assist inoperability

ELECTRICAL SYSTEM:ADAS:BLINDSPOT:SENSORS, FORWARD COLLISION AVOIDANCE

4 NHTSA complaints · 2025-06-16 → 2025-12-19

“The AEB and DA have not functioned at all since we bought the car (08/10/2024). A dealer has had the Corsair 3 times for a total of 12 days and has not fixed the problem. In fact the dealer has stated: "Customer should not expect the car to stop"”
— Owner report, NHTSA ODI #11706063
“I had my new car for five months and began receiving pre-collision assist not available and park aid malfunction. I have been receiving these since March. I took it into the dealer and they said that there would be a software update by May 1, 2025, this is the middle of June”
— Owner report, NHTSA ODI #11667221

Read all complaints on NHTSA →

Air bag non-deployment in crash events

AIR BAGS

3 NHTSA complaints · 2025-02-25 → 2026-03-03

“The contact stated that while driving 35-40 MPH, the contact noticed that another vehicle driving approximately 60 MPH crashed into the vehicle directly behind the contact's vehicle, and then crashed into the contact's vehicle. The contact's face hit the steering wheel. The…”
— Owner report, NHTSA ODI #11721806
“Impact with deer on I-79 in WV at 70mph Air bags did not deploy. I was not injured but had it been a vehicle I would have been. Not inspected or confirmed by anyone. No messages or warning before collision”
— Owner report, NHTSA ODI #11734945

Read all complaints on NHTSA →

Sunroof spontaneous breakage while driving

VISIBILITY:SUN/MOON ROOF ASSEMBLY

1 NHTSA complaint · 2026-07-13 → 2026-07-13

“The contact stated that while driving approximately 45 MPH, the sunroof suddenly exploded without warning or impact. There were no injuries sustained. The contact notified the local dealer of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was…”
— Owner report, NHTSA ODI #11749968

Read all complaints on NHTSA →

Unintended forward acceleration during parking maneuver

ENGINE

1 NHTSA complaint · 2025-03-27 → 2025-03-27

“The contact stated that while his wife was attempting to park while shifted into reverse, the vehicle launched forward, accelerated independently, and collided with another vehicle that was parked, colliding with the other vehicle's front passenger side. The other vehicle was…”
— Owner report, NHTSA ODI #11651124

Read all complaints on NHTSA →

Infotainment screen delay disabling camera display

UNKNOWN OR OTHER, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

2 NHTSA complaints · 2024-06-12 → 2024-08-11

“Since we purchased the vehicle new, the Sync Touch Screen can take several minutes to come on line and as a result all camera features are disabled and this is a safety issue. We have had frightening experiences when trying to back up in a parking lot of our own driveway with…”
— Owner report, NHTSA ODI #11594022
“When I am backing out of my garage, the emergency brake activates. And my information screen is black, the volume goes up and down, and sometimes it does not connect to my cell phone”
— Owner report, NHTSA ODI #11607819

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Oil-Life Monitor)

Every 10,000 mi

Change when the Oil-Life Monitor calls it — up to 10,000 miles or 12 months. EcoBoost engines (Aviator 3.0T): use the specified synthetic and don't stretch the monitor; turbos cook marginal oil.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 7,500 mi

Rotate every 7,500 miles. Heavy Navigators shift a lot of weight — even wear is a ride-quality item, not just a tire-budget item.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect pads, rotors, and parking brake at every oil service. Town Car livery duty and Navigator towing both count as severe service for brakes.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Automatic Transmission Fluid

Every 150,000 mi

Ford schedules the 10-speed (10R80) and 6-speed automatics at 150,000 miles normal duty — but 60,000 miles with towing or livery use, which describes many Lincolns. Mercon ULV / the specified Mercon type only.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 100,000 mi

V8 Navigator and Town Car: 100,000-mile plugs. EcoBoost V6 (Aviator, Nautilus 2.7T): commonly around 60,000 miles — check your year's guide; turbo engines run shorter plug lives.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 30,000 mi

Replace every 30,000 miles per Ford's schedule; sooner in dusty climates.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Rear Differential Fluid (RWD/4WD)

Every 60,000 mi

Navigator, Aviator RWD, and Town Car: replace rear axle fluid around 60,000 miles with towing or livery duty (150,000 normal per Ford). Limited-slip axles need the friction modifier.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Serpentine / Accessory Belt

Every 60,000 mi

Inspect from 60,000 miles; replace on cracking. The 5.4L Navigator's belt also drives the cooling fan clutch on some years — a failure overheats fast.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace every 20,000 miles where equipped. (2004-era Town Cars predate cabin filters; modern Lincolns locate it behind the glovebox.)

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Coolant Replacement

Every 100,000 mi

Motorcraft Orange (OAT) on modern models: first change around 10 years / 200,000 miles per Ford, though shops commonly refresh by 100,000. Older green-coolant V8s: every 5 years. Never mix chemistries.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Battery Test & Service

Every 25,000 mi

Test annually after year 3. Feature-heavy Lincolns (air suspension compressors, power everything) expose weak batteries as electrical gremlins first.

Estimated cost — typical U.S. ranges

Dealer

~$225–$390

Shop

~$160–$280

DIY

~$130–$250

Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

2

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2024 Lincoln Corsair reflects Lincoln's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →