Wrench.Pro

2024 Tesla Model X Recalls, Issues & Maintenance

The 2024 Tesla Model X carries 8 open NHTSA recalls — most recently covering instrument cluster/panel and warning light/devices. Owners report 7 recurring issue clusters, led by “FSD and adaptive cruise phantom braking and control loss.” Tesla vehicles have no engine oil, no transmission fluid, no spark plugs, no timing belt, and no exhaust system to maintain. The schedule below is the entire factory-recommended service list. Tesla does not require dealer-stamped service intervals to maintain warranty — owners can service most items at home or at any qualified shop.

8 Open Recalls

Source: NHTSA

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Campaign #24V051000 · Jan 30, 2024

Issue: Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

Risk: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.

Fix: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.

SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

Campaign #24V376000 · May 28, 2024

Issue: Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Risk: A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.

Fix: Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

Campaign #24V554000 · Jul 24, 2024

Issue: Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.

Risk: An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.

Fix: Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.

EXTERIOR LIGHTING:HEADLIGHTS

Campaign #24V904000 · Feb 12, 2024

Issue: Tesla, Inc. (Tesla) is recalling certain 2024 Model X vehicles. The parking lights and low beam headlights may flicker. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: Flickering headlights or parking lights may not suffciently illuminate the roadway, increasing the risk of a crash.

Fix: Tesla released an over-the-air (OTA) software update, free of charge. All vehicles were updated by September 17, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-017.

AIR BAGS:FRONTAL:DRIVER SIDE:CUSHION

Campaign #24V967000 · Dec 24, 2024

Issue: Tesla, Inc. (Tesla) is recalling certain 2021-2025 Model S and Model X vehicles. The driver's air bag could tear during deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208, "Occupant Crash Protection" and 212, "Windshield Mounting."

Risk: A torn air bag may not adequately protect an occupant in a crash, increasing the risk of injury.

Fix: Tesla service will replace the air bag assembly, free of charge. Owner notification letters were mailed February 21, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-20-001.

BACK OVER PREVENTION:SOFTWARE

Campaign #25V002000 · Jul 1, 2025

Issue: Tesla, Inc. (Tesla) is recalling certain 2024-2025 Model 3, Model S, 2023-2025 Model X, and Model Y vehicles. The computer circuit board may short, resulting in the loss of the rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Risk: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.

Fix: Tesla released an over-the-air (OTA) software update, free of charge. Tesla will also identify any vehicles that experienced a circuit board failure, or stress that may lead to a circuit board failure, and replace the affected computers, free of charge. Owner notification letters were mailed March 7, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-00-001.

AIR BAGS

Campaign #25V172000 · Mar 19, 2025

Issue: Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model S and 2021-2025 Model X vehicles. An air bag with the incorrect horn pad may have been installed, preventing the horn from sounding.

Risk: An inoperative horn may prevent the driver from alerting other drivers, increasing the risk of a crash.

Fix: Tesla service will inspect and install an air bag with the correct horn pad as necessary, free of charge. Owner notification letters were mailed May 20, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-20-001.

STEERING: STEERING WHEEL/HANDLE BAR

Campaign #23V743000 · Mar 11, 2023

Issue: Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model S and Model X vehicles. An incorrect air bag may have been installed when the steering yoke or round steering wheel was replaced with a different style of yoke or steering wheel.

Risk: An air bag that is not designed to function with the replacement steering yoke or wheel may deploy incorrectly, increasing the risk of injury during a crash.

Fix: Tesla Service will inspect and replace the driver air bag as necessary, free of charge. Owner notification letters were mailed January 2, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-20-005.

Recall data refreshed Sep 13, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2024 Tesla Model X.

4 active NHTSA investigations

Source: NHTSA

  • Compliance with Standing General Order 2021-01 Reporting Requirements

    Action #AQ25002 · opened Aug 20, 2025

    The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The ma…

    View on NHTSA →

  • FSD Collisions in Reduced Roadway Visibility Conditions

    Action #EA26002 · opened Mar 18, 2026

    The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, w…

    View on NHTSA →

  • Traffic safety violations while Full Self Driving ("FSD") is engaged

    Action #PE25012 · opened Oct 7, 2025

    The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that T…

    View on NHTSA →

  • Recall 23V838 Remedy Effectiveness

    Action #RQ24009 · opened Apr 25, 2024

    The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot…

    View on NHTSA →

Reported to NHTSA

FSD and adaptive cruise phantom braking and control loss

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

7 NHTSA complaints · 2025-02-20 → 2026-04-13

“Phantom Breaking and vehicle slow down events occur near daily when using the highway when adaptive cruise control is engaged. The vehicle will abruptly try to stop, or slow down aby 5-10 MPH. This has caused several close calls with other drivers on the highways”
— Owner report, NHTSA ODI #11644347
“i was in full self driving mode. the car wanted to turn left but i thought it was going in the wrong direction so i tried to continue straight by turning the wheel to the right forcefully but the car would not let me take over and i crashed into a guard rail”
— Owner report, NHTSA ODI #11682400
“we have experienced four separate incidents in which the vehicle has either driven off the road or abruptly slammed on the brakes without warning. Despite two prior service appointments at the Tesla Service Center in Sarasota, FL, these issues remain unresolved”
— Owner report, NHTSA ODI #11693108

Read all complaints on NHTSA →

FSD disengagement touchscreen prompt requiring driver input

LANE DEPARTURE: WARNING, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, LANE DEPARTURE: BLIND SPOT DETECTION

2 NHTSA complaints · 2026-05-04 → 2026-05-05

“once full self-driving is disengaged a pop-up menu shows up at the main part of the screen requesting a feedback why full self-driving was disengaged you cannot dismiss the questionnaire easily without being distracted during the driving extremely dangerous”
— Owner report, NHTSA ODI #11735665
“this prompt does not automatically dismiss and requires manual interaction with the touchscreen to clear. This design creates a safety concern because: - It introduces a mandatory driver interaction immediately after a disengagement event. - It diverts driver attention away…”
— Owner report, NHTSA ODI #11735945

Read all complaints on NHTSA →

Steering wheel turn signal button operability

EXTERIOR LIGHTING

4 NHTSA complaints · 2024-03-25 → 2024-12-10

“It is very difficult to use these buttons to switch on the turn signal, especially if the steering is not pointing absolutely straight. In other words, if the steering is turned at even a small angle, it becomes almost impossible to press the correct touch screen button without…”
— Owner report, NHTSA ODI #11597451
“I have found myself pressing the wrong turn signal button and was nearly in an accident more than once. That’s because the turn signals are placed too close together (see attachment). You have to take your eyes off the road and look down to make sure you are pressing the correct…”
— Owner report, NHTSA ODI #11635007
“Turn signal buttons do not work for short periods of time while driving. It is available for inspection upon request. I am unable to signal for merging and turning which is unsafe”
— Owner report, NHTSA ODI #11579409

Read all complaints on NHTSA →

Falcon Wing door electronic system failure and entrapment risk

STRUCTURE:BODY

3 NHTSA complaints · 2024-04-05 → 2026-07-31

“Door becomes stuck in a partially closed position and cannot be opened from inside or outside. Vehicle and component are available for inspection. SAFETY RISK: Falcon-wing doors have NO exterior mechanical release accessible to occupants when the electronic system fails. An…”
— Owner report, NHTSA ODI #11736437
“due to buffering/retry logic during the network reconnect, the system unexpectedly transmitted a follow-up "Close" command without any driver input. Because this automated ghost command executed while the vehicle was actively backing out, the overhead garage door unexpectedly…”
— Owner report, NHTSA ODI #11754055
“1) Yes, upon opening the falcon door there is water flooding down”
— Owner report, NHTSA ODI #11728896

Read all complaints on NHTSA →

Airbag and seat belt warning system faults

AIR BAGS, SEAT BELTS

2 NHTSA complaints · 2024-04-05 → 2024-12-10

“Passenger (next to driver) side no-belt warning is not working. Seat belt warning is not shown even when the passenger (adult) does not wear belt. It is consistently reproducible even when the vehicle is at highway speeds. 2. Passenger side airbag is always OFF even when there…”
— Owner report, NHTSA ODI #11629997
“The vehicle consistently displays the message "Rear right safety restraint system fault" on the dashboard since its delivery in January 2024. This indicates a potential malfunction in the airbag or seatbelt system, posing a safety risk to passengers occupying the rear right seat”
— Owner report, NHTSA ODI #11581428

Read all complaints on NHTSA →

Simultaneous disabling of multiple active safety systems

SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, STEERING

2 NHTSA complaints · 2025-09-08 → 2026-07-29

“multiple critical safety systems simultaneously failed on my 2024 Tesla Model X (VIN: [XXX]). Dashboard warnings indicated that ABS, stability control, traction control, steering assist, and automatic emergency braking were all simultaneously disabled. The vehicle was taken to…”
— Owner report, NHTSA ODI #11753633
“On each occasion, acceleration was either severely delayed or completely unresponsive, and the vehicle rolled backward when attempting to move forward on an incline. The following warnings appeared on the dashboard: “Stability Control Disabled,” ESC (Electronic Stability…”
— Owner report, NHTSA ODI #11685764

Read all complaints on NHTSA →

Unintended vehicle acceleration and unexpected self-movement

SERVICE BRAKES, VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

2 NHTSA complaints · 2024-06-28 → 2025-03-10

“when my husband backed the vehicle out of the garage slowly, the vehicle suddenly accelerated and it hit the stone column causing a big damage to the car. I believe the pedal speed control and emergency brake have problems”
— Owner report, NHTSA ODI #11616937
“When the vehicle is placed in reverse with the steering wheel turned to full lock, it unexpectedly initiates self-movement without any driver input. I raised this issue with Tesla Service, and they responded with the following statement: "We are aware of this and [it is]…”
— Owner report, NHTSA ODI #11647480

Read all complaints on NHTSA →

Note: NHTSA also opened 2 defect investigation(s) on this vehicle that closed without action.

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 13, 2026. Investigation data refreshed Sep 13, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Tire Rotation

Every 6,250 mi

Rotate tires every 6,250 miles or when tread depth difference exceeds 2/32". Performance models (Model 3 Performance, Model Y Performance) wear front tires faster — rotate at 5,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Fluid Test

On condition / lifetime

Test brake fluid for moisture every 2 years on Model 3/Y, every 4 years on Model S/X. Replace if moisture content exceeds the test threshold. Regenerative braking dramatically extends fluid life vs ICE vehicles.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Tire Pressure Check

Every 1,000 mi (monthly)

Check tire pressure monthly. Tesla's range estimates assume manufacturer-spec pressure; under-inflation costs 5-10% range and accelerates tire wear.

Estimated cost — typical U.S. ranges

Dealer

~$15

Shop

~$10

DIY

Free

Free at any gas station. A $10 gauge pays for itself the first time you catch a slow leak.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Wheel Alignment Check

Every 12,500 mi

Check alignment at 12,500 miles or any time tire wear is uneven. Tesla's instant torque amplifies misalignment-driven tire wear.

Estimated cost — typical U.S. ranges

Dealer

~$165

Shop

~$115

DIY

Pro only

Needs an alignment rack — not a DIY job. Most shops charge $80–$150 for a four-wheel.

A/C Desiccant Bag

On condition / lifetime

Model 3 / Model Y: replace A/C desiccant bag every 4 years. Model S (2021+) / Model X (2021+): every 6 years. Required to keep heat pump operating efficiently.

Estimated cost — typical U.S. ranges

Dealer

~$290–$360

Shop

~$205–$255

DIY

Pro only

Refrigerant handling is EPA-regulated — shop-only. Often deferred unless AC performance drops.

Brake Caliper Service (cold climates)

Every 12,500 mi

Owners in cold-climate regions (snow, road salt) should clean and lubricate brake calipers every 12,500 miles or annually. Light brake use from regen lets caliper sliders seize.

Estimated cost — typical U.S. ranges

Dealer

~$275–$330

Shop

~$195–$235

DIY

~$20–$60

Pin lube + boot inspection. Stuck calipers cause uneven pad wear — worth doing if you DIY the pads anyway.

12V Auxiliary Battery (legacy lead-acid)

On condition / lifetime

Pre-2021 Model 3, pre-2022 Model Y, and earlier Model S/X use a 12V lead-acid auxiliary battery — typical service life 3-4 years. Newer models use a 16V lithium-ion battery rated for the life of the vehicle.

Estimated cost — typical U.S. ranges

Dealer

~$225–$390

Shop

~$160–$280

DIY

~$130–$250

Most auto-parts stores test and install batteries free with purchase. Skip the dealer markup.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

On condition / lifetime

Model 3 / Model Y: replace every 2 years. Model S / Model X: replace every 3 years (HEPA filter, larger). Sooner in dusty climates or wildfire-prone regions.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

HEPA Filter (Model S / X with Bioweapon Defense Mode)

On condition / lifetime

Model S and Model X equipped with Bioweapon Defense Mode use a HEPA filter — replace every 3 years.

Estimated cost — typical U.S. ranges

Dealer

~$130–$210

Shop

~$95–$150

DIY

~$35–$90

HEPA-grade replacement; aftermarket is improving but selection is narrower than standard cabin filters.

High-Voltage Battery — No Service

On condition / lifetime

The high-voltage battery is sealed and has no scheduled maintenance. Tesla's 8-year/100,000-150,000-mile battery warranty covers capacity retention to 70%.

Estimated cost — typical U.S. ranges

Dealer

—

Shop

—

DIY

—

Traction battery service varies dramatically by vehicle ($5k–$20k+). Get a quote — we won't pretend to know.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

16 crashes 2010–2024

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2024 Tesla Model X reflects Tesla's published service intervals. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →