Wrench.Pro

2025 Ford Maverick Recalls, Issues & Maintenance

The 2025 Ford Maverick carries 12 open NHTSA recalls — most recently covering electrical system and status indicator lamp/light. Owners report 7 recurring issue clusters, led by “Forward collision avoidance system unavailability.” Ford uses the Intelligent Oil-Life Monitor (IOLM) to determine when oil changes are due based on actual driving load — not just mileage. Ford's published cap is 10,000 miles or 1 year, whichever comes first. The schedule below reflects Ford's Normal service intervals; F-Series trucks and Super Duty have additional towing-specific items.

12 Open Recalls

Source: NHTSA

ELECTRICAL SYSTEM

Campaign #25V343000 · May 23, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2024-2025 Lincoln Nautilus, 2023-2025 Escape, 2023 Lincoln Corsair, 2025 Lincoln Corsair, Maverick, and Bronco Sport vehicles equipped with a 1.5L or 2.0L MPC engine and an engine block heater. The engine block heater may overheat when the vehicle is parked with the block heater plugged in.

Risk: An overheated engine block heater can increase the risk of a fire.

Fix: Dealers will replace the block heater element and inspect the electrical cord, replacing it if necessary, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug coupled, and remove the block heater electrical cord. Owner notification letters were mailed June 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S52.

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:STATUS INDICATOR LAMP/LIGHT

Campaign #25V350000 · Sep 6, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2025 Maverick vehicles. The air bag indicator light on the dashboard may be loose or dislodged, and not visible to occupants. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Risk: The air bag indicator light may fail to warn occupants of a deactivated air bag, increasing the risk of injury in a crash.

Fix: Dealers will install air bag indicator light retaining clips, free of charge. Owner notification letters were mailed June 24, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C17.

ELECTRONIC STABILITY CONTROL (ESC)

Campaign #25V787000 · Nov 14, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2025 Maverick and Escape vehicles. The cover for the electric brake booster's ECU may cause the printed circuit board to overheat and result in a loss of vehicle stability control systems (anti-lock braking, electronic stability control, and traction control) or a loss of brake power assist.

Risk: Loss of vehicle stability control or brake power assist can increase the risk of a crash.

Fix: Dealers will replace the electric brake booster, free of charge. Owner notification letters were mailed on November 28, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SC6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 17, 2025.

ENGINE

Campaign #25V828000 · Jan 12, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2026 Explorer, Mustang, Lincoln Corsair, and 2025 Maverick vehicles. The cylinder head may have been improperly manufactured, which can cause the ball plugs to fail, resulting in an oil leak.

Risk: An oil leak in the presence of an ignition source such as hot engine or exhaust components increases the risk of a fire. In addition, the loss of oil can result in engine seizure and loss of motive power, increasing the risk of a crash.

Fix: Dealers will replace the cylinder head assembly, free of charge. All affected vehicles are still within dealership inventory and therefore no owner notification letters will be mailed. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD3. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on November 24, 2025.

POWER TRAIN:AUTOMATIC TRANSMISSION:INTERNAL:PARK PAWL

Campaign #25V863000 · Dec 12, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2022-2026 F-150 Lightning BEV, 2024-2026 Mustang Mach-E, and 2025-2026 Maverick vehicles. The integrated park module may fail to lock into the park position when the driver shifts into park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."

Risk: A loss of park function can allow the vehicle to rollaway, increasing the risk of a crash.

Fix: The park module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed February 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C69. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 26, 2026.

STRUCTURE:INTERIOR PANELS:DASHBOARD

Campaign #25V884000 · Dec 18, 2025

Issue: Ford Motor Company (Ford) is recalling certain 2025-2026 Maverick vehicles. The instrument panel cover may separate when the air bag deploy.

Risk: An instrument panel cover separation can cause pieces of the cover to strike occupants, increasing the risk injury during a crash.

Fix: Dealers will replace the instrument panel cover, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SE7. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 19, 2025.

ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL

Campaign #26V104000 · Feb 20, 2026

Issue: Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Risk: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Fix: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)

Campaign #26V122000 · Mar 3, 2026

Issue: Ford Motor Company (Ford) is recalling certain 2025 Ranger, Lincoln Nautilus, Mustang, Maverick, Explorer, Escape, Lincoln Corsair, Bronco Sport, and Bronco vehicles. The exhaust gas recirculation (EGR) valve may fail, resulting in an unexpected loss of drive power.

Risk: An unexpected loss of drive power increases the risk of a crash.

Fix: Dealers will replace the EGR valves, free of charge. Owner notification letters were mailed July 31, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S10. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.

VISIBILITY:SUN/MOON ROOF ASSEMBLY

Campaign #26V157000 · Mar 17, 2026

Issue: Ford Motor Company (Ford) is recalling certain 2025-2026 Maverick vehicles. The moonroof glass may not have been bonded correctly to the moonroof frame, which could result in the glass panel detaching from the vehicle.

Risk: A detached glass panel may become a road hazard, increasing the risk of a crash.

Fix: Dealers will inspect the moonroof glass and replace the glass if necessary, free of charge. Owner notification letters were mailed April 17, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.

AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:FRONT PASSENGER

Campaign #26V201000 · Mar 31, 2026

Issue: Ford Motor Company (Ford) is recalling certain 2025-2026 Bronco Sport and Maverick vehicles. The Occupant Classification Sensor (OCS) unit may fail to correctly detect the presence of an adult or child in the front passenger seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Risk: Failure to correctly detect a passenger may result in the air bag not deploying as intended, increasing the risk of injury during a crash.

Fix: Dealers will replace the passenger seat occupant classification sensor, free of charge. Owner notification letters were mailed June 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C19. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 2, 2026.

EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER

Campaign #26V239000 · Apr 14, 2026

Issue: Ford Motor Company (Ford) is recalling certain 2025 Maverick and 2026 Bronco Sport vehicles equipped with a 1.5L or 2.0L MPC engine and an engine block heater. The engine block heater may overheat when the vehicle is parked with the block heater plugged in.

Risk: An overheated engine block heater can increase the risk of a fire.

Fix: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, and inspect and replace the electrical cord if necessary, free of charge. Owners will also have an alternative option to replace the engine block heater element with a threaded plug, and remove the block heater electrical cord. Owner notification letters were mailed June 10, 2026. This recall expands previous NHTSA recall number 25V343. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S52. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 14, 2026.

SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Campaign #26V340000 · May 27, 2026

Issue: Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.

Risk: A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.

Fix: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 4, 2026. Additional letters will be sent once the remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S36. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 29, 2026.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2025 Ford Maverick.

Reported to NHTSA

Forward collision avoidance system unavailability

FORWARD COLLISION AVOIDANCE: WARNINGS

8 NHTSA complaints · 2025-08-09 → 2026-08-13

“Precollision assist became unavailable twice while driving during my first few days of driving”
— Owner report, NHTSA ODI #11699266
“Pre-collision system became unavailable. System reported camera obstruction, but windshield was clear. Similar to issues in August 2025. August issue was temporary fixed via software update and reset at dealership”
— Owner report, NHTSA ODI #11700636
“When I first bought the vehicle the "pre-collision assist not available" light on the dashboard was on from the factory. Service did something and got rid of it. However, it still comes on and off intermittently every now and then”
— Owner report, NHTSA ODI #11679852
“The contact stated that while driving approximately 45 MPH, the pre-collision warning light suddenly activated, and the vehicle abruptly stopped. After pulling over and waiting for several minutes, the contact was able to continue driving”
— Owner report, NHTSA ODI #11753287

Read all complaints on NHTSA →

Service brake loss and unexpected vehicle movement

SERVICE BRAKES

7 NHTSA complaints · 2025-08-20 → 2026-08-10

“In the first week with only 107 miles, the brakes failed 3 times at very low speeds. Once while backing out and no brakes at all. 2 days later while turning a corner in a parking light they totally failed and I just missed hitting a car”
— Owner report, NHTSA ODI #11690294
“Pressed brake pedal and vehicle did not stop. Then vehicle came to an abrupt stop after brakes floored for several seconds. Felt like the brakes locked up. Display flashed E-Brake”
— Owner report, NHTSA ODI #11737936
“I bought the vehicle new and after 15,000 miles my electric brake booster is making a noise when I depress the brake pedal. I am concerned the internal mechanism will fail and I will lose the brake booster”
— Owner report, NHTSA ODI #11756013
“While using the Auto Hold feature and stopped at a light, the truck went forward on its own - then made a loud clunk noise. Turned Auto Hold off and brought truck to Ford Service Dept. They could not find the problem”
— Owner report, NHTSA ODI #11747529

Read all complaints on NHTSA →

Audio speaker electrical burning, smoke, and fire

ELECTRICAL SYSTEM

2 NHTSA complaints · 2025-08-24 → 2026-08-13

“On 5/21/26 this happened once again, turning vehicle off didn’t work. The static sound stayed playing even after the truck was turned off completely. I proceeded on my route to my destination when I smelled electrical burning smell, suddenly the front left driver”
— Owner report, NHTSA ODI #11739451
“*** VEHICLE FIRE RISK *** Drivers dash tweeter started smoking and the dash became hot to the touch near the windshield. Smelled something electrical burning. Smoke stain on LWR LH windshield corner. Removed key. Exited vehicle and heard static from drivers door”
— Owner report, NHTSA ODI #11756848

Read all complaints on NHTSA →

Hybrid drivetrain power loss and Stop Safely Now alert

ELECTRICAL SYSTEM, ENGINE

3 NHTSA complaints · 2025-08-09 → 2026-06-25

“On [XXX] I was driving on the freeway when a high voltage sign and the message "Pull off road when safe" lit up the dashboard. The engine lost all power and I was able to coast to a stop on the shoulder”
— Owner report, NHTSA ODI #11679536
“A year ago while driving on the interstate, my Ford Maverick suddenly threw a "Stop Safely Now" alert. I was able to turn the ignition off and back on to safely exit the highway”
— Owner report, NHTSA ODI #11746575
“Shortly after purchase, my 2025 Ford Maverick Hybrid AWD experienced a sudden and severe electrical burning or melting odor while driving at freeway speed (approximately 75 mph). The odor was extremely strong and clearly coming from my vehicle”
— Owner report, NHTSA ODI #11705804

Read all complaints on NHTSA →

Water intrusion into passenger cabin via cowl

STRUCTURE:BODY

4 NHTSA complaints · 2025-05-21 → 2026-03-09

“Water leak/intrusion into the passengers side of the vehicle during a rain storm. The leak allows water to enter the car interior which causes mold to grow in the carpet. Also the area where the water enters is directly above the main fuse panel for the car”
— Owner report, NHTSA ODI #11662717
“The passenger side floor is soaking wet every time it rains. Google says this is a defect with the windshield cowl, which other owners say is a common problem. Our safety is at risk with potential for mold, rust, and water intrusion into the electrical system”
— Owner report, NHTSA ODI #11728937
“During heavy rain the HVAC system can fill with water to the point it leaks on the passenger floor. The cabin air filter is full of water and high humidity air is blown from the vents. This results in diminished defrost performance”
— Owner report, NHTSA ODI #11663470

Read all complaints on NHTSA →

Suspension failure and loss of vehicle control

SUSPENSION

2 NHTSA complaints · 2026-06-08 → 2026-06-08

“The contact stated while her son was driving at an undisclosed speed, the vehicle became difficult to maneuver and her son loss control of the vehicle causing the front passenger side corner of the vehicle to crash into another vehicle”
— Owner report, NHTSA ODI #11742701
“The car has extreme vibration almost like speed wobbles when accelerating. Difficult to steer particularly if accelerating to change lanes. Appears the cv axles / have gone bad”
— Owner report, NHTSA ODI #11742730

Read all complaints on NHTSA →

Electric power steering fault and loss of assist

STEERING

2 NHTSA complaints · 2026-01-29 → 2026-02-10

“Got a warning chime and light that said electric steering fault. Power steering failed completely reverting to manual non power steering making it very hard to steer vehicle. This has happened twice, once at about 1200 miles and again at about 4800 miles”
— Owner report, NHTSA ODI #11714167
“Purchased vehicle new and after 3 days the power steering became inoperable as well as traction control , hillstart assist and showed that the fowrad camers was in default”
— Owner report, NHTSA ODI #11641826

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 7,500 mi

Replace synthetic-blend or full-synthetic Motorcraft oil per the IOLM, or every 7,500-10,000 miles. EcoBoost engines require full synthetic; Coyote 5.0L V8 specifies SAE 5W-30.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 10,000 mi

Rotate tires every 10,000 miles, or with every other oil change. F-150 4x4 owners should rotate every 5,000-7,500 miles to even out drivetrain bias wear.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect brake pads, rotors, and brake fluid level every 10,000 miles. Front pads on F-150 and Explorer typically last 40,000-60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 45,000 mi

Ford specifies brake fluid replacement on an inspection basis, but moisture testing every 3 years is recommended. Replace if reading exceeds 3% water content.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. EcoBoost turbocharged engines are sensitive to airflow restriction — don't extend.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 150,000 mi

Ford 6R80, 10R80, and 8F transmissions use Mercon LV fluid rated 150,000 miles under normal service. Severe service (towing, plowing) drops this to 60,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Transfer Case Fluid (4WD models)

Every 60,000 mi

F-150 4x4 and Bronco 4x4: replace transfer case fluid every 60,000 miles. Use Motorcraft XL-12 — do not substitute generic transfer case fluid.

Estimated cost — typical U.S. ranges

Dealer

~$105–$140

Shop

~$75–$100

DIY

~$15–$40

AWD/4WD vehicles only. Easy drain-and-fill on most platforms.

Rear Differential Fluid

Every 100,000 mi

F-Series and Expedition: replace rear axle fluid every 100,000 miles, or 50,000 miles if towing. Limited-slip rear ends require friction-modifier additive.

Estimated cost — typical U.S. ranges

Dealer

~$150–$195

Shop

~$105–$135

DIY

~$20–$50

Drain plug + fill plug — straightforward DIY. AWD vehicles have two; budget for both.

Spark Plugs

Every 100,000 mi

Iridium spark plugs on Coyote 5.0L, EcoBoost 2.7L/3.5L, and 2.3L are rated 100,000 miles. EcoBoost engines: never exceed the interval — gap erosion causes coil failure.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Coolant

Every 50,000 mi

Motorcraft Orange (Dex-Cool compatible) coolant: first change at 100,000 miles, then every 50,000. Older trucks with Yellow Motorcraft coolant: 50,000 miles throughout.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 20,000 mi

Replace the cabin air filter every 20,000 miles. On F-150, located behind the glove box; on Escape and Explorer, accessed from the passenger footwell.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2025 Ford Maverick reflects Ford's published service intervals and the Intelligent Oil-Life Monitor system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →