Wrench.Pro

2025 Toyota Tacoma Recalls, Issues & Maintenance

The 2025 Toyota Tacoma carries 5 open NHTSA recalls — most recently covering hoses, lines/piping, and fittings and instrument cluster/panel. Owners report 4 recurring issue clusters, led by “Interior door handle failure.” Toyota's owner's manual splits service into Schedule 1 (severe) and Schedule 2 (normal). Most US drivers fall under Schedule 1 because it covers short trips, extreme temperatures, dusty roads, or heavy idling. The intervals below reflect Schedule 1 — the schedule Toyota recommends for typical real-world use.

5 Open Recalls

Source: NHTSA

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS

Campaign #25V058000 · Jun 2, 2025

Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024-2025 Tacoma 4-wheel drive vehicles. The rear brake hoses can be damaged if mud and dirt builds up inside the rear wheels. This can result in a brake fluid leak.

Risk: A brake fluid leak can reduce braking ability and increase the risk of a crash.

Fix: Dealers will replace both rear brake hoses, free of charge. Owner letters were mailed August 1, 2025. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB04 and 25TA04.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Campaign #25V595000 · Nov 9, 2025

Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.

Risk: An instrument panel display that does not show critical information can increase the risk of a crash or injury.

Fix: Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.

POWER TRAIN:DRIVELINE:DRIVESHAFT

Campaign #25V656000 · Jan 10, 2025

Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2025 Tacoma and Tacoma Hybrid vehicles. The front driveshaft constant-velocity (CV) joint may deform and break.

Risk: A broken driveshaft can impair steering. Vehicles with full-time 4WD may experience a vehicle rollaway while parked without the parking brake applied. Both scenarios increase the risk of a crash.

Fix: Dealers will inspect and replace both front driveshaft assemblies as necessary, free of charge. Owner letters were mailed August 11, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB11 and 25TA11.

EQUIPMENT:OTHER:LABELS

Campaign #26V179000 · Mar 24, 2026

Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024-2025 Toyota Tundra, Tacoma Hybrid, Tacoma, RAV4 Hybrid, Land Cruiser Hybrid, Lexus GX550, 2024-2026 Tundra Hybrid, 2025 Sequoia Hybrid, Crown Signia, Grand Highlander, Lexus TX500 Hybrid, Lexus NX350 Hybrid, 2025-2026 Grand Highlander Hybrid, and Lexus TX350 vehicles. The load carrying capacity modification label may display inaccurate added weight values. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Risk: A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.

Fix: Dealers will replace the load carrying capacity modification label, free of charge. Owner letters were mailed May 26, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 26LB04, 26LA04, 26TB07, and 26TA07.

SUSPENSION:REAR:SHOCK ABSORBER

Campaign #26V514000 · Jun 8, 2026

Issue: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2024 Tacoma Hybrid and 2024-2025 Tacoma vehicles. The metal flange on the front and rear shock absorbers may corrode and fail, resulting in detachment of the external oil reservoir.

Risk: An oil reservoir that detaches can create a road hazard, increasing the risk of a crash.

Fix: Dealers will inspect and replace the front and rear shock absorber assemblies, as necessary, free of charge. Owner notification letters are expected to be mailed September 21, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 26TB14 and 26TA14.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2025 Toyota Tacoma.

Reported to NHTSA

Interior door handle failure

STRUCTURE

24 NHTSA complaints · 2025-10 → 2026-08

“The contact owns a 2025 Toyota Tacoma. The contact stated that while stationary and attempting to exit the vehicle from the driver's side, the interior driver's side door handle fractured, preventing the opening or locking of the door from the inside”
— Owner report, NHTSA ODI #11750131
“The interior driver side door handle on my 2025 Toyota Tacoma failed and wouldn't open the door from the inside. I had to roll down my window to open from the outside. The dealership replaced the handle assembly under warranty. This happened at around 9300 miles on the odometer”
— Owner report, NHTSA ODI #11740765
“Driver's side interior door handle mechanism broke during normal usage at 8 months/6,300 miles. Breakage occured within the door panel, leaving a non-functioning handle”
— Owner report, NHTSA ODI #11733188

Read all complaints on NHTSA →

Steering and suspension alignment instability

STEERING, SUSPENSION

8 NHTSA complaints · 2025-07 → 2026-07

“I am reporting a severe safety hazard on my 2025 Toyota Tacoma caused by incorrect alignment specs and an uncorrected extreme toe setting. On a recent service visit, alignment inspection showed a Total Toe of +1.62 degrees (OEM target is approximately +0.10 degrees)”
— Owner report, NHTSA ODI #11751664
“Loose tie rod nut created a potential safety risk because it involves a steering component related to vehicle control. This could have put me, my passengers, and others drivers at risk if the condition had worsened while driving”
— Owner report, NHTSA ODI #11733479
“Turning a corner heard a loud clunk and steering went out in the middle of the street.I could of got hit”
— Owner report, NHTSA ODI #11681088

Read all complaints on NHTSA →

Front axle and drive shaft recall delay

POWER TRAIN

15 NHTSA complaints · 2025-08 → 2026-06

“In October of 2025 I was notified of a safety based recall for my 2025 Tacoma related to the front axle shafts possibly breaking which could cause loss of steering control should an incident occur”
— Owner report, NHTSA ODI #11736190
“The vehicle was being operated in 4-wheel-drive, mode 4H, and when turning to the left at low speed, there was a grinding noise from the front of the vehicle and it would not proceed”
— Owner report, NHTSA ODI #11699826
“Turning a corner my left axle broke and I only have 3100 miles on this vehicle. Still is not fixed because of warranty issues”
— Owner report, NHTSA ODI #11681892

Read all complaints on NHTSA →

Forward collision avoidance false activation

FORWARD COLLISION AVOIDANCE, LANE DEPARTURE

5 NHTSA complaints · 2025-10 → 2026-06

“While driving on a dry, clearly marked two-lane highway in Montana, I had Lane Tracing Assist and Active Lane Keep/Track Assist turned on. My hands were on the steering wheel, speed was within the limit, and visibility was clear”
— Owner report, NHTSA ODI #11694597
“My 2025 Toyota Tacoma engaged the emergency braking/pre-collision system system while my vehicle was going under 10 mph on a steep road in winter conditions”
— Owner report, NHTSA ODI #11729275
“The contact owned a 2025 Toyota Tacoma. The contact stated that while driving approximately 75 MPH, a Semi Truck attempting to merge onto the highway crashed into the passenger side of the vehicle, causing the driver to lose control of the steering and cross three lanes of…”
— Owner report, NHTSA ODI #11714169

Read all complaints on NHTSA →

Issues on other model years

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter

Every 5,000 mi

Replace 0W-20 full-synthetic oil and filter every 5,000 miles under Schedule 1, or 10,000 miles under Schedule 2. Toyota covers the first 2 oil changes through ToyotaCare.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Tire Rotation

Every 5,000 mi

Rotate tires every 5,000 miles. Toyota recommends rotation at every oil change to maximize tire life on FWD and AWD models.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 5,000 mi

Inspect brake pads, rotors, and parking brake every 5,000 miles. Toyota recommends measuring pad thickness at each service.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 30,000 mi

Replace DOT 3 brake fluid every 30,000 miles or 36 months. Critical for the integrity of the ABS, VSC, and brake assist systems.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

Engine Air Filter

Every 30,000 mi

Replace the engine air filter every 30,000 miles. Earlier under Schedule 1 if driven on unpaved roads.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Automatic Transmission Fluid

Every 60,000 mi

Toyota labels ATF as 'lifetime fill' on most automatics, but recommends inspection and replacement every 60,000 miles under severe service. Use Toyota WS or Type-IV — no substitutes.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 120,000 mi

Toyota iridium-tipped spark plugs are rated for 120,000 miles. Earlier replacement reduces fuel economy and can cause misfires on direct-injection engines.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Super Long Life Coolant (SLLC)

Every 50,000 mi

Toyota SLLC (pink): first change at 100,000 miles, then every 50,000 miles. Do not substitute green or orange coolant — it will damage the cooling system seals.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 30,000 mi

Replace the cabin air filter every 30,000 miles, sooner in dusty climates. Located behind the glove box on most Toyota and Lexus models.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Serpentine / Drive Belt Inspection

Every 60,000 mi

Inspect the serpentine belt and tensioner every 60,000 miles. Toyota uses long-life EPDM belts that rarely fail before 100,000 miles.

Estimated cost — typical U.S. ranges

Dealer

~$195–$235

Shop

~$135–$165

DIY

~$20–$50

DIY-friendly if you can reach the tensioner. Inspect for cracks rather than swap on a strict mileage interval.

Timing Chain — No Replacement

On condition / lifetime

Toyota's 2AR-FE, 2GR-FKS, A25A-FKS, and most Toyota engines built since 2010 use a timing chain rated for the life of the engine. No scheduled replacement.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Pro only

Timing chains are normally lifetime. Listen for rattle on cold start — that's the actionable signal. Replacement is major work, quote separately.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

4

complaints mentioning a crash

2

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2025 Toyota Tacoma reflects Toyota's published service intervals and the Maintenance Required Light system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.

Check another vehicle →