2025 Volvo Xc90 Recalls, Issues & Maintenance

The 2025 Volvo Xc90 carries 2 open NHTSA recalls — most recently covering software. Owners report 7 recurring issue clusters, led by “Backup camera unavailability and screen freeze.” Volvo schedules maintenance every 10,000 miles or 12 months, whichever comes first — the cluster's service reminder counts down to it. Drive-E four-cylinder engines (2015+) require Volvo-spec 0W-20; the older five-cylinder turbos (XC70, C30) run on a timing belt with a firm replacement interval, not a chain. AWD Volvos use a Haldex-style rear coupling whose fluid service is the difference between an AWD system that lasts and a four-figure pump-and-clutch repair.

2 Open Recalls

Source: NHTSA

BACK OVER PREVENTION:SOFTWARE

Campaign #25V282000 · Aug 5, 2025

Issue: Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: A rearview camera image that does not display reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.

Fix: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10320.

BACK OVER PREVENTION:SOFTWARE

Campaign #25V908000 · Dec 23, 2025

Issue: Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: A rearview camera image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.

Fix: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed February 24, 2026. Owners may contact Volvo Car’s customer service at 1-800-458-1552. Volvo Car's number for this recall is R10333. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 16, 2026. This recall replaces previous NHTSA recall number 25V282. Vehicles previously repaired under recall 25V282 will need to have the new remedy performed.

Recall data refreshed Sep 6, 2026.

Known issues for this vehicle

What drivers and federal regulators have officially reported about the 2025 Volvo Xc90.

Reported to NHTSA

Backup camera unavailability and screen freeze

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

5 NHTSA complaints · 2025-01-01 → 2026-07-31

When I try to back the car out of parking lot, it shows "Camera temporary unavailable". The problem disappears sometime. It is a new car and this has happened a couple of times already
Owner report, NHTSA ODI #11633554
The contact stated that while reversing, the rear-view camera screen seized. The contact stated that the rear-view camera displayed a still image
Owner report, NHTSA ODI #11753962
The screens and backup camera are repeatedly crashing, even after the recall "fix" from the dealership. This happens multiple times a week
Owner report, NHTSA ODI #11679507

Read all complaints on NHTSA →

Automatic emergency braking false activation

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

3 NHTSA complaints · 2025-09-09 → 2026-04-29

The accident avoidance system engaged during a 55mph drive on a divided 4 lane road. no other cars on road, no animals. Car swerved sharply to left half way into left lane and brakes engaged sharply, enough that driver and passenger in front went forward
Owner report, NHTSA ODI #11734492
My fiance and I were driving on the highway with our four children at a speed of >50 MPH. There were no cars around us (front or sides) and no debris in the road, and the automatic emergency braking system engaged and brought the car to an abrupt stop in the middle of the highway
Owner report, NHTSA ODI #11686070

Read all complaints on NHTSA →

Brake pedal unresponsiveness and complete brake loss

SERVICE BRAKES

4 NHTSA complaints · 2025-02-16 → 2026-03-18

on March 15, 2026, while driving, I experienced a critical and dangerous failure: my brakes became unresponsive, and I was unable to stop the vehicle using the brake pedal. Multiple warning lights appeared simultaneously
Owner report, NHTSA ODI #11725183
Complete brake failure. Vehicle would no slow at all. Brake failure warning on dash. Now multitude of warnings
Owner report, NHTSA ODI #11643056
The contact stated that while driving downhill at 15 MPH, while depressing the brake pedal, the vehicle would not come to a complete stop as intended. No warning light illuminated. The contact stated that he drove up a hill in order to come to a stop
Owner report, NHTSA ODI #11661009

Read all complaints on NHTSA →

Electrical system and infotainment intermittent shutdown

ELECTRICAL SYSTEM

4 NHTSA complaints · 2025-01-21 → 2025-12-17

The vehicle’s interface shuts down frequently, which is extremely dangerous—especially at highway speeds. On several occasions, including at night, the entire system has gone completely blank
Owner report, NHTSA ODI #11705607
Remote start, infotainment system which controls everything, dashboard, lights, and cigarette lighter all intermittently turn off and on. Everyday, something else seems to stop working. My vehicle is 2.5 weeks old
Owner report, NHTSA ODI #11637435

Read all complaints on NHTSA →

Lane-keeping assist erratic steering intervention

LANE DEPARTURE: LANE KEEP: STEERING ASSIST

2 NHTSA complaints · 2025-12-30 → 2025-12-30

The contact stated that while driving through a construction zone at an undisclosed speed, the lane-keeping assist malfunctioned, causing the vehicle to become erratic, which required the contact to forcefully engage the steering wheel to regain control of the vehicle
Owner report, NHTSA ODI #11707882
LANE DEPARTURE ASSIST has a hard time identifying lanes in some construction zones (this is extremely dangerous as the car is constantly trying to over-correct me)
Owner report, NHTSA ODI #11707902

Read all complaints on NHTSA →

OEM tire sidewall cracking and structural failure

TIRES

1 NHTSA complaint · 2026-04-06 → 2026-04-06

The tires exhibit severe sidewall bulging, starburst cracking indicating internal structural failure, and at least one tire shows a deep gash with internal steel cords exposed. Three of the four original tires are affected
Owner report, NHTSA ODI #11729554

Read all complaints on NHTSA →

Gear selector failure and recurrent service warning

UNKNOWN OR OTHER

1 NHTSA complaint · 2026-07-08 → 2026-07-08

The gear selector system failed, triggering a “Gear Selector Service Required” warning. The vehicle is a plug-in hybrid and remains available for inspection upon request. Safety risk: During the first incident, the vehicle became disabled while being driven, losing the ability…
Owner report, NHTSA ODI #11749143

Read all complaints on NHTSA →

Source: NHTSA Office of Defects Investigation (ODI). Complaint data refreshed Sep 11, 2026. Investigation data refreshed Sep 11, 2026.

We display NHTSA's record with attribution; we don't editorialize on what these complaints mean for any specific vehicle.

Essential maintenance

Critical for safety and preventing major damage

Engine Oil & Filter (Annual Service)

Every 10,000 mi

Replace every 10,000 miles or 12 months with Volvo-spec oil (VCC 0W-20 on Drive-E engines). Turbo five-cylinders in the older XC70/C30 are harder on oil — many specialists suggest 7,500 miles on those.

Estimated cost — typical U.S. ranges

Dealer

~$120–$160

Shop

~$85–$115

DIY

~$25–$55

Full synthetic costs more than conventional. 5-quart 0W-20 + filter is the typical bill.

Timing Belt (5-Cylinder — XC70, C30)

Every 105,000 mi

Volvo's five-cylinder engines use a timing belt: replace around 105,000 miles or 10 years (verify your year's exact interval). Interference engine — do the tensioner and idlers in the same job. Drive-E four-cylinders (2015+) use a chain instead.

Estimated cost — typical U.S. ranges

Dealer

~$935–$1175

Shop

~$655–$825

DIY

Pro only

On interference engines, a snapped belt destroys valves. Worth doing on schedule. Bundle water pump + tensioner — labor is already there.

Tire Rotation

Every 10,000 mi

Rotate at every annual service. AWD models: replace tires in matched sets — tread mismatch works the Haldex coupling constantly.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Often free at the shop where you bought the tires — worth asking before paying.

Brake Inspection

Every 10,000 mi

Inspect pads, rotors, and hoses at every service. Heavy XC90s wear front pads quickly in city duty; check electronic parking-brake function on 2016+ models.

Estimated cost — typical U.S. ranges

Dealer

~$85

Shop

~$60

DIY

Free

Most shops do this free as a courtesy with any service. Don't pay separately if you can avoid it.

Brake Fluid

Every 24,000 mi

Replace DOT 4 fluid every 2 years regardless of miles — standard practice for the moisture-absorbing fluid, and cheap insurance for the ABS unit.

Estimated cost — typical U.S. ranges

Dealer

~$180–$200

Shop

~$125–$140

DIY

~$10–$25

DOT 3 or 4 — match the cap. Vacuum bleeders make this a one-person DIY.

Important maintenance

Keeps your vehicle running smoothly and efficiently

AWD Coupling Fluid (Haldex)

Every 40,000 mi

AWD models: replace the rear coupling's fluid roughly every 40,000 miles (Volvo's published interval varies by generation — check your manual). Skipping it clogs the pump filter and kills the AWD unit; whirring from the rear axle is the classic late symptom.

Estimated cost — typical U.S. ranges

Dealer

~$220–$290

Shop

~$155–$205

DIY

~$40–$90

VW/Audi/Volvo AWD coupling — specific fluid required. Filter usually swapped at the same time.

Automatic Transmission Fluid

Every 60,000 mi

The Aisin 8-speed is labeled long-life, but Volvo specialists broadly recommend fluid service around 60,000 miles — sooner with towing. Use the specified JWS/Toyota WS-type fluid for your gearbox.

Estimated cost — typical U.S. ranges

Dealer

~$330–$500

Shop

~$235–$355

DIY

~$60–$180

Some sealed transmissions have no dipstick — fill is precise and best left to a shop. Many drivers can still DIY drain-and-fill.

Spark Plugs

Every 60,000 mi

Drive-E turbo fours: plugs around every 60,000 miles. Supercharged+turbocharged T6/T8 engines run higher cylinder pressures — don't stretch the interval.

Estimated cost — typical U.S. ranges

Dealer

~$285–$390

Shop

~$200–$275

DIY

~$25–$100

Iridium plugs cost more but last 100k+ miles. V6/V8 access varies wildly — some are tough.

Engine Air Filter

Every 30,000 mi

Replace roughly every 30,000 miles; inspect annually in dusty climates.

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

5-minute job on most cars; the airbox lid usually has clips, no tools needed.

Recommended maintenance

Extends the life of your vehicle and improves comfort

Cabin Air Filter

Every 10,000 mi

Volvo specifies frequent cabin-filter replacement — annually on most models, in keeping with the brand's air-quality focus (CleanZone on newer cars).

Estimated cost — typical U.S. ranges

Dealer

~$60–$95

Shop

~$45–$70

DIY

~$15–$40

Usually behind the glovebox. Shops charge labor for a 10-minute job — easy DIY win.

Engine Coolant

On condition / lifetime

Volvo long-life coolant typically runs ~10 years on the schedule; refresh with Volvo-spec coolant around 100,000 miles per independent-specialist practice.

Estimated cost — typical U.S. ranges

Dealer

~$285–$330

Shop

~$200–$235

DIY

~$25–$60

Use the manufacturer-specified coolant — wrong color/chemistry can damage the cooling system.

Fatal crash history & reported problems

Occupant deaths in fatal crashes (FARS)

No occupant deaths in FARS 2010–2024 crashes are on record for this year and model. That is the census answer for the window, and it says nothing more than that.

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road. How to read this number

Owner-reported problem signals

Separate from the federal fatality data above: complaints owners filed with NHTSA about this year and model. These are reports of problems, unverified, and are counted here only as signals.

0

complaints mentioning a crash

0

complaints mentioning a fire

Reviewed known issues for this vehicle·Open recalls for this vehicle

Typical U.S. ranges. Actual quotes vary by shop, parts choice, and vehicle condition.

How we estimate: Dealer = OEM parts × 1.4 + labor × $165/hr. Shop = parts + labor × $115/hr. DIY = parts only.

This maintenance schedule for the 2025 Volvo Xc90 reflects Volvo's published service intervals and the Volvo Service Reminder system. Your actual service needs may vary based on driving conditions, climate, and vehicle usage. Always consult your owner's manual for model-specific recommendations.