2012 Volvo S60: raw data

Every record we hold for this vehicle, as plain tables, with nothing added. The consumer page shows the same records with the maintenance schedule, price ranges and nearby shops around them.

vehicle	2012 / volvo / s60
known issues	5 clusters (reviewed 2026-09-03)
complaints	121 on file (2011-07-13 → 2026-06-23)
recalls	8
investigations	0
fars	13 occupant deaths, crash years 2010-2024 (legacy-code)
indexed	yes
license	CC BY 4.0 (derived)

Known Issues clusters all years →

Steering wheel and interior trim delamination, sharp edgesSTEERING6 complaints2013-03 → 2022-09volvo-s60-2012-trim-delamination-sharp-edges

10503380 THE STEERING WHEEL BEZEL DELAMINATES ON THE BOTTOM OF THE STEERING WHEEL AND BECOMES VERY SHARP CAUSING CUTS ON HANDS. DEALER REPLACED THE BEZEL AND WE HAVE THE SAME PROBLEM AGAIN. IT APPEARS TO BE A DEFECT IN THE DESIGN OR MANUFACTURE OF THE BEZEL
11483292 The steering wheel trim peeled and created a razor sharp surface at the bottom which sliced through my finger and caused pain and bleeding. It is difficult to avoid touching the sharp part of the steering wheel especially at highway speeds
11321399 INTERIOR ADHESIVE CHROME TRIM DELAMINATING AND VERY SHARP CAUSING A CUT HAND ON THE STEERING WHEEL AND CENTER CONSOLE

Front seat belt recall parts delay and buckle stickingSEAT BELTS5 complaints2020-11 → 2023-02volvo-s60-2012-seat-belt-recall-buckle

11453320 I have a 2012 S60R. I just received the recall notice for the front seat belts last week. In September of 2021, the warning light on the dash board intermittently comes on with a warning sound stating that my rear seat belt is not in use
11406764 TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V378000 (SEAT BELTS) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL
11476537 The drivers seat belt to lock in place or unlock gets stuck ! Makes it very difficult to ge try out of my vehicle daily. This is a major concern if i am ever in an emergency and cannot get out of my seat

Excessive oil consumption without low-oil warningENGINE39 complaints2015-01 → 2026-04volvo-s60-2012-oil-consumption-no-warning

11298483 EXCESSIVE OIL CONSUMPTION BETWEEN OIL CHANGE INTERVALS. SINCE THE PURCHASE OF THIS CAR (2/1/2016) I HAVE USED FULLY SYNTHETIC OIL (CASTROL). OIL LEVEL SLOWLY DROPS BETWEEN SCHEDULED OIL CHANGES. PRIOR TO THE LAST SCHEDULED OIL CHANGE (1/10/2020) I CHECKED THE OIL IT IT WAS VERY
10992073 THE CAR WAS CONSUMING OIL AT A SHOCKING RATE - 12 QUARTS OVER THE COURSE OF 2 MONTHS AND THE OIL LIGHT DID NOT ILLUMINATE, EVEN WHEN THE ENGINE WAS COMPLETELY OUT OF OIL! I OPENED A CASE WITH VOLVO USA AT THE TIME AND WAS TOLD TO BRING THE CAR TO A DEALER
11599825 Discovered that my engine is burning oil. There was no warning from my vehicle or from Volvo (during regular maintenance) that this was happening. It was just sudden that the check engine light went on and I checked the oil and found that it was basically empty

Drive belt failure causing stall and timing damageENGINE5 complaints2018-08 → 2024-05volvo-s60-2012-drive-belt-timing-failure

11558481 The contact owns a 2012 Volvo S60. The contact stated while driving approximately 40 MPH, the vehicle lost motive power and stalled. The vehicle was later towed to the local dealer who diagnosed the vehicle and determined that the drive belt had failed, causing damage to the
11122049 ON DECEMBER 24, 2015, OUR 2012 VOLVO S60 FWD T5 ENGINE BROKE DOWN ON A CITY STREET. THE BELT WAS REPLACED AT THE VOLVO DEALERSHIP WITH A STANDARD "VOLVO-BELT." MILEAGE ON THE CAR AT THE TIME WAS 43843. FAST FORWARD TO AUGUST 21, 2018, THE CAR BREAKS DOWN AGAIN ON CITY STREET
11560890 Surpintine belt shredded due to faulty belt tensioner. Shreds of belt wedged between crankshaft timing sprocket on engine causing engine to jump timing while driving down highway and vehicle lost all power and very hard to steer due to all valves in motor bent because of poor

Airbag failure to deploy in a crashAIR BAGS4 complaints2014-01 → 2026-06volvo-s60-2012-airbag-nondeployment

10788882 TL* THE CONTACT OWNED A 2012 VOLVO S60. WHILE DRIVING APPROXIMATELY 40 MPH, ANOTHER VEHICLE CUT IN FRONT OF THE CONTACT. AS A RESULT, THE CONTACT CRASHED INTO A POLE ON THE SIDE OF THE ROAD. THE AIR BAGS DID NOT DEPLOY
10560896 ON AUGUST 24, 2013, I WAS INVOLVED IN A CAR ACCIDENT. A CAR STOPPED SHORT ON THE HIGHWAY. THE CAR IN FRONT OF ME HIT THAT CAR. I THEN HIT THE CAR IN FRONT OF ME. I HAD ONLY A FEW SECONDS TO REACT. ANOTHER CAR THEN RE-ENDED ME. MY AIRBAG NOR SEATBELT PRETENTIONERS DEPLOYED
11742523 The driver's side seat airbag system failed. Specifically, diagnostic trouble code SRS-B002011 was retrieved, indicating a circuit short to ground in the left side airbag deployment control system. The technician found a broken clip on the airbag

NHTSA complaints (summary) all years →

count	earliest_date	latest_date	crash_flagged	fire_flagged	top_components
121	2011-07-13	2026-06-23	8	0	ENGINE:61; ELECTRICAL SYSTEM:17; UNKNOWN OR OTHER:15; SEAT BELTS:9; STEERING:8

Recalls all years →

campaign_number	report_received_date	component	summary	consequence	remedy
11V508000	18/10/2011	EQUIPMENT:OTHER:LABELS	VOLVO IS RECALLING CERTAIN MODEL YEAR 2006-2012 C70 VEHICLES MANUFACTURED FROM NOVEMBER 15, 2005, THROUGH JULY 31, 2011, AND MODEL YEAR 2011-2012 S60 VEHICLES MANUFACTURED FROM JULY 14, 2010, THROUGH APRIL 16, 2011, THAT WERE EQUIPPED WITH OPTIONAL ACCESSORY SPARE TIRE KIT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES DO NOT CONTAIN THE CORRECT INFORMATION FOR VEHICLES EQUIPPED WITH THE OPTIONAL ACCESSORY SPARE TIRE AND WHEEL KIT.	A MISPRINTED LABEL COULD LEAD TO IMPROPER TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.	VOLVO WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE VEHICLE AND INSTALL THE LABEL AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 23, 2012. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
11V303000	01/06/2011	FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP	VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 PASSENGER CARS MANUFACTURED FROM NOVEMBER 18, 2010, THROUGH MAY 5, 2011. THE SOFTWARE FOR THE FUEL PUMP UNITS MAY NOT BE COMPATIBLE WITH ALL FUEL PUMPS AND COMPONENTS RESULTING IN INSUFFICIENT FUEL TRANSFER IN THE PUMP UNIT.	UNDER CERTAIN DRIVING CONDITIONS, THERE MAY BE ENGINE HESITATION AND POSSIBLE ENGINE STALL EVEN THOUGH THE FUEL GAUGE INDICATES UP TO 1/4 OF THE FUEL IS LEFT IN THE TANK. THIS CONDITION INCREASES THE RISK OF A VEHICLE CRASH.	VOLVO WILL NOTIFY OWNERS AND DEALERS WILL UPGRADE THE ENGINE CONTROL MODULE SOFTWARE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 1, 2011. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
12V075000	28/02/2012	ELECTRICAL SYSTEM:WIRING	VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60, XC60, S80 AND XC70 VEHICLES MANUFACTURED FROM MAY 16, 2011, THROUGH OCTOBER 6, 2011. IN THESE VEHICLES, THE WIRE HARNESS UNDER THE FRONT SEATS MAY HAVE NOT BEEN ATTACHED PROPERLY TO THE SEAT FRAME. AS A RESULT, WHEN THE SEATS ARE MOVED TO ADJUST THE SEATING POSITION, THE WIRE HARNESS MAY GET PULLED, CAUSING IT TO DISCONNECT.	IN THE EVENT OF CRASH, THE FRONT AND/OR SIDE IMPACT AIR BAGS MAY DEPLOY IMPROPERLY OR NOT AT ALL, INCREASING THE RISK OF INJURY. ALSO, THE LAP BELT PRETENSIONER MAY NOT DEPLOY.	VOLVO WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND, IF NECESSARY, SECURE THE SEAT WIRE HARNESS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
11V311000	06/06/2011	FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS	VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 PASSENGER CARS MANUFACTURED FROM JANUARY 18, 2011, THROUGH JANUARY 28, 2011. THE MALE PART OF THE FUEL LINE QUICK CONNECTOR END SHAPE WAS PRODUCED WITH DIMENSIONS OUT OF SPECIFICATION, LEADING TO EXCESSIVE ASSEMBLY FORCE ON THE FEMALE CONNECTOR ASSEMBLY AND THE POSSIBILITY THAT THE LOCKING FUNCTION MAY NOT BE ENGAGED.	IF A VEHICLE EXHIBITS THIS CONDITION, THE FUEL LINE QUICK CONNECTOR MAY DETACH AND THE ENGINE MAY STALL, INCREASING THE RISK OF A CRASH. THE CUSTOMER MAY ALSO NOTICE A FUEL SMELL AND LEAKAGE. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.	VOLVO DEALERS WILL REPLACE THE FUEL LINES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 24, 2011. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
12V101000	14/03/2012	STRUCTURE:BODY	VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 AND XC60 PASSENGER VEHICLES. AN INCORRECT MIXTURE OF UNDERBODY COATING AND OVER-APPLICATION CAN RESULT IN RIGID, ICICLE-LIKE AREAS HANGING FROM VEHICLES UNDERCARRIAGE.	IF THIS CONDITION EXISTS, THE UNDERBODY COATING MAY PENETRATE THE FUELS LINES AND CAUSE FUEL LEAKAGE, INCREASING THE RISK OF A FIRE.	DEALERS WILL INSPECT THE VEHICLE UNDERCARRIAGE, AND IF EXCESSIVE UNDERBODY COATING IS FOUND IN THE FUEL LINE AREA, IT WILL BE REMOVED. IF THE INSPECTION REVEALS THAT THE FUEL LINES ARE DAMAGED, THEY WILL BE REPLACED. THE SAFETY RECALL BEGAN ON APRIL 25, 2012. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552.
13V592000	22/11/2013	ENGINE AND ENGINE COOLING:ENGINE	Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2011-2012 S60 vehicles manufactured June 22, 2010, through May 14, 2012, and equipped with 5-cylinder B5254T5 (VIN code 62) engines. In the affected vehicles, the vehicle may not alert the driver of a low oil pressure situation.	Without being warned of a low oil pressure situation, the driver may continue to drive the vehicle until it stalls, which increases the risk of a crash.	Volvo will notify owners, and dealers will update the vehicle's software so that the driver is alerted should there be a low oil pressure situation, free of charge. The recall began on January 10, 2014. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R29436.
20V378000	30/06/2020	SEAT BELTS:FRONT	Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.	An unsecured occupant has an increased risk of injury in the event of a crash.	Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
19V849000	26/11/2019	LATCHES/LOCKS/LINKAGES:DOORS:LATCH	Volvo Car of USA LLC (Volvo) is recalling certain 2011-2017 S60, S60I, V60, S60CC and V60CC vehicles. A component within the door latches may break, making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.	A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.	Volvo will notify owners, and dealers will replace all four door latches, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89978.

Investigations all years →

none listed

FARS occupant deaths all years →

crash_years	occupant_deaths	match_type	vpic_recovered
2010-2024	13	legacy-code	0

FARS counts every occupant death in a fatal crash, whatever the cause — it does not mean the vehicle was at fault or defective. Counts are not adjusted for how many of each vehicle are on the road.

Cite this

Derived data is CC BY 4.0. Link back to the page you used. Text and BibTeX below.

Wrench.Pro (2026). 2012 Volvo S60 vehicle data [dataset]. https://www.wrench.pro/data/vehicles/2012/volvo/s60

@misc{wrenchpro_2012_volvo_s60_2026,
  author = {Wrench.Pro},
  title = {Wrench.Pro vehicle data: 2012 Volvo S60},
  year = {2026},
  howpublished = {\url{https://www.wrench.pro/data/vehicles/2012/volvo/s60}},
  note = {Derived from NHTSA public records. CC BY 4.0.}
}

hub · known-issues · methodology · license · research (interpretation)